Page 1 Hardware Maintenance Manual ThinkPad Edge 13², E30, and E31...
Page 2 Appendix A “Notices” on page 117. Fourth Edtion (August 2011) © Copyright Lenovo 2009, 2011. LIMITED AND RESTRICTED RIGHTS NOTICE: If data or software is delivered pursuant a General Services Administration “GSA” contract, use, reproduction, or disclosure is subject to restrictions set forth in Contract No. GS-35F-05925.
Page 3: Table Of Contents
Checkout guide ....Diagnostics using PC-Doctor for DOS..Lenovo ThinkVantage Toolbox ..FRU tests ....
Page 4 2050 Wireless LAN antenna assembly, wireless WAN antenna assembly, and LCD rear cover assembly ....Chapter 9. Locations ..89 Front view .
Page 5: About This Manual
Use this manual along with the advanced diagnostic tests to troubleshoot problems effectively. Before servicing a ThinkPad product, be sure to read all the information under Chapter 1 “Safety information” on page 1. © Copyright Lenovo 2009, 2011 ® products.
Page 6 Hardware Maintenance Manual...
Page 7: Chapter 1. Safety Information
• Fan louvers on the machine help to prevent overheating of internal components. Do not obstruct fan louvers or cover them with labels or stickers. Electrical safety Observe the following rules when working on electrical equipment. © Copyright Lenovo 2009, 2011...
Page 8 Important: Use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have, near their equipment, rubber floor mats that contain small conductive fibers to decrease electrostatic discharges.
Page 9: Safety Inspection Guide
Safety inspection guide The purpose of this inspection guide is to assist you in identifying potentially unsafe conditions. As each machine was designed and built, required safety items were installed to protect users and service technicians from injury. This guide addresses only those items. You should use good judgment to identify potential safety hazards due to attachment of non-ThinkPad features or options not covered by this inspection guide.
Page 10: Grounding Requirements
• Keep the parts in protective packages until they are inserted into the product. • Avoid contact with other people. • Wear a grounded wrist strap against your skin to eliminate static on your body. • Prevent the part from touching your clothing. Most clothing is insulative and retains a charge even when you are wearing a wrist strap.
Page 11 DANGER DANGER DANGER DANGER DANGER Chapter 1 Safety information...
Page 12 DANGER Hardware Maintenance Manual...
Page 13 PERIGO PERIGO PERIGO Chapter 1 Safety information...
Page 14 PERIGO PERIGO PERIGO PERIGO PERIGO DANGER Hardware Maintenance Manual...
Page 15 DANGER DANGER DANGER DANGER DANGER Chapter 1 Safety information...
Page 16 DANGER DANGER VORSICHT VORSICHT VORSICHT Hardware Maintenance Manual...
Page 17 VORSICHT VORSICHT VORSICHT VORSICHT VORSICHT Chapter 1 Safety information...
Page 18 Hardware Maintenance Manual...
Page 19 Chapter 1 Safety information...
Page 20 Hardware Maintenance Manual...
Page 21 Chapter 1 Safety information...
Page 22 Hardware Maintenance Manual...
Page 23 Chapter 1 Safety information...
Page 24 Hardware Maintenance Manual...
Page 25: Chapter 2. Important Service Information
– “FRU identification for CTO, CMV, and GAV products” on page 21 Important: Advise customers to contact the Lenovo Customer Support Center if they need any assistance in obtaining or installing any software fixes, drivers, and BIOS downloads. Telephone numbers for Lenovo Support are available at: http://www.lenovo.com/support/phone...
Page 26: Strategy For Replacing A Hard Disk Drive
Dynamic Configure To Order (CTO) This provides the ability for a customer to configure a Lenovo solution from an eSite, and have this configuration sent to fulfillment, where it is built and shipped directly to the customer. The machine label, Product Entitlement Warehouse (PEW), eSupport, and the HMM will load these products as the 4-digit MT and 3-digit model, where model = “CTO”...
Page 27: Fru Identification For Cto, Cmv, And Gav Products
= a “fixed part number”, not “CTO” (Example: 1829-F1U). • PEW can be accessed at the following Web site: http://www.lenovo.com/support/site.wss/document.do?lndocid=LOOK-WARNTY Select Warranty lookup. Input the MT and the Serial number and the list of key commodities will be returned in the PEW record under COMPONENT INFORMATION.
Page 28 Hardware Maintenance Manual...
Page 29: Chapter 3. General Checkout
• “Checkout guide” on page 24 – “Diagnostics using PC-Doctor for DOS” on page 24 – “Lenovo ThinkVantage Toolbox ” on page 27 – “FRU tests” on page 27 • “Power system checkout” on page 28 The descriptions in this chapter apply to any ThinkPad model that supports the PC-Doctor diagnostics program.
Page 30: Checkout Guide
• Forgotten computer password (making the computer unusable) • Sticky keys caused by spilling a liquid onto the keyboard • Use of an incorrect AC adapter on laptop products The following symptoms might indicate damage caused by nonwarranted activities: • Missing parts might be a symptom of unauthorized service or modification.
Page 31: Testing The Computer
Configuration utility for DOS. The utility is available on the following Web site: http://support.lenovo.com Testing the computer In this product, you need an external optical drive to use the PC-Doctor diagnostic CD to test the hardware features.
Page 32 Diagnostics • Run Normal Test • Run Quick Test • CPU/Coprocessor • System board • Video Adapter • Fixed Disks • Diskette Drives • Other Devices • Wireless LAN • Advanced Memory Tests Notes: • In the Keyboard test in Interactive Tests, the Fn key should be held down for at least 2 seconds; otherwise, it cannot be sensed.
Page 33: Lenovo Thinkvantage Toolbox
The latest Lenovo ThinkVantage Toolbox is available at the following Web site: http://support.lenovo.com To install the latest Lenovo ThinkVantage Toolbox on the computer, follow the instructions on the Web site. To run this program, do as follows: Click Start ➙ Control Panel ➙ System and Security ➙ Lenovo's System Health and Diagnostics Follow the instructions on the screen.
Page 34: Power System Checkout
Table 1. FRU tests (continued) Applicable test 1. If two DIMMs are installed, remove one of them and run Diagnostics ➙ Advanced Memory 2. If the problem does not recur, return the DIMM to its place, remove the other one, TrackPoint or pointing If the TrackPoint does not work, check the configuration as specified in the BIOS Setup device...
Page 35: Checking Operational Charging
(20V) Note: Output voltage of pin no.2 of the AC adapter may different from the one you are servicing. 3. If the voltage is not correct, replace the AC adapter. 4. If the voltage is acceptable, do the following: • Replace the system board. •...
Page 36: Checking The Backup Battery
2(+) 1(+) 3. If the voltage is less than +11.0 V dc, the battery pack has been discharged. Note: Recharging will take at least 3 hours, even if the indicator does not turn on. If the voltage is still less than +11.0 V dc after recharging, replace the battery. 4.
Page 37: Chapter 4. Related Service Information
Use the arrow keys to select Startup Boot. c. Select the CD/DVD drive as the 1st Boot Device. 2. Insert the Operating System Recovery Disc into the DVD drive. © Copyright Lenovo 2009, 2011 ® Windows operating system. Use this disc to start the recovery...
Page 38: Passwords
Attention: If the user HDP has been forgotten, check whether a master HDP has been set. If it has, it can be used for access to the hard disk drive. If no master HDP is available, neither Lenovo nor Lenovo authorized...
Page 39: Supervisor Password
Attention: If User only mode is selected and the user HDP has been forgotten and cannot be made available to the service technician, neither Lenovo nor Lenovo authorized service technicians provide any services to reset the user HDPs or to recover data from the hard disk drive. The hard disk drive can be replaced for a scheduled fee.
Page 40: Power Management
2. When the ThinkPad logo comes up, immediately press F1 to enter BIOS Setup Utility.For models supporting the Passphrase function, press F1 while HDP icon is appearing on the screen; then enter the master HDP. For the other models, enter the master HDP. Note: To check whether the ThinkPad Notebook you are servicing supports the Passphrase function, enter the BIOS Setup Utility and go to Security ➙...
Page 41: Symptom-To-Fru Index
Symptom-to-FRU index This section contains following information: • “Numeric error codes” on page 35 • “Error messages” on page 37 • “No-beep symptoms” on page 37 • “LCD-related symptoms” on page 38 • “Intermittent problems” on page 38 • “Undetermined problems” on page 39 The symptom-to-FRU index in this section lists symptoms and errors and their possible causes.
Page 42 Table 2. Numeric error codes (continued) Symptom or error (beeps, if any) 0230 Shadow RAM error—Shadow RAM fails at offset nnnn. (two short beeps) 0231 System RAM error—System RAM fails at offset nnnn. (two short beeps) 0232 Extended RAM error— Extended RAM fails at offset nnnn. (two short beeps) 0250 System battery error—System battery is dead.
Page 43: Error Messages
Table 2. Numeric error codes (continued) Symptom or error (beeps, if any) 02F7 Fail-safe timer NMI failed (two short beeps) 1802 Unauthorized network card is plugged in—Turn off and remove the miniPCI network card. (two short beeps) 1804 Unauthorized WAN card is plugged in—Power off and remove the WAN card.
Page 44: Lcd-Related Symptoms
If the LCD you are servicing has two or less visible defective pixels, it should not be considered faulty. However, if the LCD has three or more visible defective pixels, it will be deemed as defective by Lenovo and it should be replaced.
Page 45: Undetermined Problems
Undetermined problems If the diagnostic tests did not identify the adapter or device that has failed, if wrong devices are installed, or if the system simply is not operating, follow these procedures to isolate the failing FRU (do not isolate FRUs that have no defects).
Page 46 Hardware Maintenance Manual...
Page 47: Chapter 5. Status Indicators
Wireless status: Power status Green: © Copyright Lenovo 2009, 2011 Caps Lock mode is enabled. You can enter all alphabetic characters (A-Z) in uppercase without pressing the Shift key. Press F9 to enable or disable the wireless features. You can quickly change the power state of each feature in the list.
Page 48 Table 6. Status indicators (continued) Indicator Meaning Off: Sleep (standby) The illumination dot in the ThinkPad logo on the outer lid of the computer and on the status palm rest works as a system-status indicator: it shows whether the computer is in sleep (standby), hibernation, or normal mode.
Page 49: Chapter 6. Special Keys
(F7) The purpose of this method is to change the brightness level temporarily. To change the default brightness level, change the settings of the Power Option in the Control Panel or use the Power Manager. © Copyright Lenovo 2009, 2011...
Page 50 Table 7. Fn key combinations (continued) Description Special key Display brightness up The computer display becomes brighter. (F8) The purpose of this method is to change the brightness level temporarily. To change the default brightness level, change the settings of the Power Option in the Control Panel or use the Power Manager.
Page 51: Chapter 7. Fru Replacement Notices
CRU; and (2) you may be charged for the replacement CRU if Lenovo does not receive the defective part within thirty (30) days of your receipt of the replacement CRU. See your Lenovo Limited Warranty documentation for full details.
Page 52: Retaining Serial Numbers
If you replace the system board, you must restore the serial number of the system unit to its original value. Before replacing the system board, save the original serial number by doing the following: 1. Install the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later, and restart the computer.
Page 53: Retaining The Uuid
When you replace the system board, you must set the UUID on the new system board as follows: 1. Install the LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later, and restart the computer. 2. From the main menu, select 4. Assign UUID. A new UUID is created and written. If a valid UUID already exists, it is not overwritten.
Page 54 Hardware Maintenance Manual...
Page 55: Chapter 8. Removing And Replacing A Fru
CRU; and (2) you may be charged for the replacement CRU if Lenovo does not receive the defective part within thirty (30) days of your receipt of the replacement CRU. See your Lenovo Limited Warranty documentation for full details.
Page 56: 1010 Battery Pack
1010 Battery pack Important notice for replacing a battery pack: ThinkVantage Toolbox has an automatic battery diagnostic that determines if the battery pack is defective. A battery pack FRU should not be replaced unless this diagnostic shows that the battery is defective. The only exception to this is if the battery pack is physically damaged or a customer is reporting a possible safety issue.
Page 57 Removal steps of bottom slot cover Note: Loosen the screws , but do not remove them. When installing: Make sure that all the projections of the cover are attached firmly to the frame. Then secure the screws. Applying label to the bottom slot cover When you replace the cover, following label needs to be peeled off from the old cover, and needs to be put on the new cover: Asset tag label...
Page 58: 1030 Dimm
1030 DIMM For access, remove these FRUs in order: • “1010 Battery pack” on page 50 • “1020 Bottom slot cover” on page 50 Removal steps of DIMM Note: If only one DIMM is used on the computer you are servicing, the card must be installed in SLOT-0 ( but not in SLOT-1 ( When installing: Insert the notched end of the DIMM into the socket.
Page 59: 1040 Hard Disk Drive (Hdd)
1040 Hard disk drive (HDD) For access, remove these FRUs in order: • “1010 Battery pack” on page 50 • “1020 Bottom slot cover” on page 50 Attention: • Do not drop the drive or apply any physical shock to it. The drive is sensitive to physical shock. Improper handling can cause damage and permanent loss of data.
Page 60: 1050 Pci Express Mini Card For Wireless Lan
When installing: Make sure that the HDD connector is attached firmly. 1050 PCI Express Mini Card for wireless LAN For access, remove these FRUs in order: • “1010 Battery pack” on page 50 • “1020 Bottom slot cover” on page 50 Removal steps of PCI Express Mini Card for wireless LAN In step , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick the...
Page 61: 1060 Pci Express Mini Card For Wireless Wan
Step Screw (quantity) M2 × 3 mm, flat-head, nylon-coated (2) When installing: Plug the gray cable into the jack marked MAIN or M, and the black cable into the jack marked AUX or A on the card. 1060 PCI Express Mini Card for wireless WAN For access, remove these FRUs in order: Chapter 8 Torque...
Page 62 • “1010 Battery pack” on page 50 • “1020 Bottom slot cover” on page 50 Removal steps of PCI Express Mini Card for wireless WAN In step , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick the connectors with your fingers and gently unplug them in direction of the arrow.
Page 63: 1070 Keyboard
When installing: Plug the red cable into the jack marked MAIN, and the blue cable into the jack marked AUX on the card. 1070 Keyboard For access, remove these FRUs in order: • “1010 Battery pack” on page 50 • “1020 Bottom slot cover”...
Page 64 Installation steps of keyboard When installing the keyboard, do as follows: 1. Attach the keyboard connectors. 2. Attach the keyboard so that the keyboard front edges are under the frame as shown in this figure. Hardware Maintenance Manual...
Page 65: 1080 Top Case Assembly And Microphone Module
3. Secure the keyboard by tightening the screws from the bottom side of the computer. 1080 Top case assembly and microphone module For access, remove these FRUs in order: • “1010 Battery pack” on page 50 • “1020 Bottom slot cover” on page 50 •...
Page 66 Removal steps of top case assembly and microphone module Step Screw (quantity) M2 × 3 mm, flat-head, nylon-coated (6) Step Screw (quantity) M2 × 3 mm, flat-head, nylon-coated (3) Hardware Maintenance Manual Color Torque Black 0.181 Nm (1.85 kgfcm) Torque Color Black 0.181 Nm...
Page 67 When installing: Make sure that the connectors are attached firmly. In step , push the top case assembly out from the frame by using a plastic pry tool as shown in this figure. Chapter 8 Removing and replacing a FRU...
Page 68: 1090 Backup Battery
1090 Backup battery For access, remove these FRUs in order: • “1010 Battery pack” on page 50 • “1020 Bottom slot cover” on page 50 • “1070 Keyboard” on page 57 • “1080 Top case assembly and microphone module” on page 59 Hardware Maintenance Manual...
Page 69: 1100 Bluetooth Daughter Card (Bdc-2)
Removal steps of backup battery DANGER Use only the battery specified in the parts list for your computer. Any other battery could ignite or explode. When installing: Make sure that the connector is attached firmly. 1100 Bluetooth daughter card (BDC-2) For access, remove these FRUs in order: •...
Page 70: 1110 Speaker Assembly
Removal steps of BDC-2 Step Screw (quantity) M2 × 3 mm, flat-head, nylon-coated (1) When installing: Make sure that the connector is attached firmly. 1110 Speaker assembly For access, remove these FRUs in order: • “1010 Battery pack” on page 50 •...
Page 71 Removal steps of speaker assembly Step Screw (quantity) M2 × 3 mm, flat-head, nylon-coated (4) Cable routing: Make sure that the connector is attached firmly and you route the cable as shown in this figure. Color Torque Black 0.181 Nm (1.85 kgfcm) Chapter 8 Removing and replacing a FRU...
Page 72: 1120 System Board And Fan Assembly
1120 System board and fan assembly Important notices for handling the system board: When handling the system board, bear the following in mind. • The system board has an accelerometer, which can be broken by applying several thousands of G-forces. Note: Dropping a system board from a height of as little as 6 inches so that it falls flat on a hard bench can subject the accelerometer to as much as 6,000 G's of shock.
Page 73 For CULV (Customer Ultra-Low Voltage) models (MT0196 and MT0492): Accelerometer chip for the HDD Active Protection System™ GMCH (Graphics Memory Controller Hub) ICH (I/O Controller Hub) Chapter 8 Removing and replacing a FRU...
Page 74 For CULV models (MT0217 and MT0250): Accelerometer chip for the HDD Active Protection System Hardware Maintenance Manual PCH (Peripheral Control Hub)
Page 75 ® For AMD models (MT0197): North Bridge For AMD models (MT0221): Accelerometer chip for the HDD Active Protection System South Bridge Accelerometer chip for the HDD Active Protection System North Bridge South Bridge Chapter 8 Removing and replacing a FRU...
Page 76 Step Screw (quantity) M2 × 3 mm, flat-head, nylon-coated (3) Note: Loosen the screws , but do not remove them. Hardware Maintenance Manual Color Torque Black 0.181 Nm (1.85 kgfcm)
Page 77 When installing: Make sure that the connectors are attached firmly. Chapter 8 Removing and replacing a FRU...
Page 78 When installing: Attach the system board so that the battery pins of the system board are attached firmly to the guide hole of the base cover as shown in Make sure that the connectors are attached firmly. Note: Loosen the screws , but do not remove them.
Page 79: 1130 I/O Card Assembly, Audio Cable, And I/O Cable
For MT0197: For MT0217 and MT0250: For MT0221: When installing: Make sure that the fan connector is attached firmly. 1130 I/O card assembly, audio cable, and I/O cable For access, remove these FRUs in order: • “1010 Battery pack” on page 50 •...
Page 80 • “1110 Speaker assembly” on page 64 • “1120 System board and fan assembly” on page 66 Removal steps of I/O card assembly, audio cable, and I/O cable Step Screw (quantity) M2 × 3 mm, flat-head, nylon-coated (1) Hardware Maintenance Manual Color Torque Black...
Page 81: 1140 Lcd Unit
Cable routing: Make sure that the connectors are attached firmly and you route the cables as shown in this figure. 1140 LCD unit For access, remove these FRUs in order: • “1010 Battery pack” on page 50 • “1020 Bottom slot cover” on page 50 •...
Page 82 Removal steps of LCD unit Step Screw (quantity) M2.5 × 5 mm, flat-head, nylon-coated (4) Hardware Maintenance Manual Color Torque Black 0.392Nm (4 kgfcm)
Page 83 Cable routing: Make sure that the cables are attached to the cable guides as shown in this figure. When you route the cables, make sure that they are not subjected to any tension. Tension could cause the cables to be damaged by the cable guides, or a wire to be broken. Chapter 8 Removing and replacing a FRU...
Page 84: 1150 Base Cover Assembly And Dc-In Cable
1150 Base cover assembly and DC-in cable For access, remove these FRUs in order: • “1010 Battery pack” on page 50 • “1020 Bottom slot cover” on page 50 • “1040 Hard disk drive (HDD)” on page 53 • “1050 PCI Express Mini Card for wireless LAN” on page 54 •...
Page 85 Applying labels to the base cover The new base cover FRU is shipped with a kit containing labels of several kinds. When you replace the base cover, you need to apply the following labels: If the Windows Certificate of Authentication label (COA) old part with the label attached to the customer, or provide a letter to the customer stating what the label was originally on the system and what the label part number, serial number, and product key were.
Page 86: 2010 Lcd Bezel Assembly
For the location of each label, refer to the following figure: 2010 LCD bezel assembly For access, remove this FRU: • “1010 Battery pack” on page 50 Removal steps of LCD bezel assembly Step Screw cap Screw (quantity) M2 × 4 mm, flat-head, nylon-coated (4) Hardware Maintenance Manual Torque Color...
Page 87: 2020 Integrated Camera
2020 Integrated camera For access, remove these FRUs in order: • “1010 Battery pack” on page 50 • “2010 LCD bezel assembly” on page 80 Removal steps of integrated camera When installing: Make sure that the connector of the integrated camera is attached firmly. Chapter 8 Removing and replacing a FRU...
Page 88: 2030 Lcd Panel And Lcd Cable
2030 LCD panel and LCD cable For access, remove these FRUs in order: • “1010 Battery pack” on page 50 • “1020 Bottom slot cover” on page 50 • “1040 Hard disk drive (HDD)” on page 53 • “1050 PCI Express Mini Card for wireless LAN” on page 54 •...
Page 89 Chapter 8 Removing and replacing a FRU...
Page 90: 2040 Hinge Kit
2040 Hinge kit For access, remove these FRUs in order: • “1010 Battery pack” on page 50 • “1020 Bottom slot cover” on page 50 • “1040 Hard disk drive (HDD)” on page 53 • “1050 PCI Express Mini Card for wireless LAN” on page 54 •...
Page 91: 2050 Wireless Lan Antenna Assembly, Wireless Wan Antenna Assembly, And Lcd Rear Cover Assembly
Removal steps of hinge kit Step Screw (quantity) M2 × 3 mm, flat-head, nylon-coated (2) 2050 Wireless LAN antenna assembly, wireless WAN antenna assembly, and LCD rear cover assembly For access, remove these FRUs in order: • “1010 Battery pack” on page 50 Torque Color Black...
Page 92 • “1020 Bottom slot cover” on page 50 • “1040 Hard disk drive (HDD)” on page 53 • “1050 PCI Express Mini Card for wireless LAN” on page 54 • “1060 PCI Express Mini Card for wireless WAN” on page 55 •...
Page 93 Cable routing: When you install the antenna assembly, route the cables as shown in the figures below. As you route the cables, make sure that they are not subjected to any tension. Tension could cause the cables to be damaged by the cable guides, or a wire to be broken. : Wireless LAN MAIN antenna (gray) : Wireless WAN MAIN antenna (red) : Wireless WAN AUX antenna (blue)
Page 94 Hardware Maintenance Manual...
Page 95: Chapter 9. Locations
Media Card Reader slot Status indicators Note: For the description of each indicator, see Chapter 5 “Status indicators” on page 41. TrackPoint pointing stick TrackPoint buttons Touch pad buttons Touch pad ® UltraNav Built-in microphone © Copyright Lenovo 2009, 2011...
Page 96: Bottom View
Bottom view Battery pack latch Battery pack Security keyhole External monitor connector HDMI port RJ-45 (Ethernet) connector Power USB connector (MT0196, MT0197, and MT0492) eSATA/USB connector (MT0217, MT0221, and MT0250) Built-in stereo speakers HDD slot door Hardware Maintenance Manual...
Page 97: Chapter 10. Parts List
CRU, Lenovo will ship the CRU to you. CRU information and replacement instructions are shipped with your product and are available from Lenovo at any time upon request. You may find a list of CRUs in the publications that ship with your product or at http://www.lenovo.com/CRUs. You may be required to return the defective part that is replaced by the CRU.
Page 98: Overall
• FRUs marked with are available as options. Overall Hardware Maintenance Manual...
Page 99 Table 8. Parts list—Overall No. FRU (Overall) LCD unit (see “LCD FRUs” on page 101.) Keyboard (see “Keyboard” on page 104.) Top case assembly for 0196, 0197, and 0429 Top case assembly for 0217, 0221, and 0250 Qualcom Gobi-2000 WWAN, WW SKU •...
Page 100 Table 8. Parts list—Overall (continued) No. FRU (Overall) ThinkPad 1x1 11b/g/n Wireless LAN PCI Express Half Mini Card Adapter • 0217-CTO, 22x, 23x, 25x, 2Zx, 3Ax, 3Bx, 3Ex • 0221-CTO, 22x, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x, 36x, 37x, 39x, 3Ax, 3Bx, 3Cx, 3Dx •...
Page 101 Table 8. Parts list—Overall (continued) No. FRU (Overall) 2-GB DDR2-667 SDRAM SO-DIMM (PC2-5300) card • 0196-CTO • 0197-all • 0492-CTO 2-GB DDR3-1067 SDRAM SO-DIMM (PC2-8500) card • 0196-all • 0197-CTO • 0492-all 2-GB DDR3-1333 SDRAM SO-DIMM (PC3-10600) card • 0196-all •...
Page 102 Table 8. Parts list—Overall (continued) No. FRU (Overall) Battery pack, Li-ion (6 cell) 73+ • 0196-CTO, 22x, 24x, 25x, 26x, 28x, 29x, 2Bx, 2Cx, 2Dx, 2Ex, 2Gx, 2Jx, 2Lx, 2Qx, 2Wx, 2Xx, 2Yx, 37x, 38x, 39x, 3Ax, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 55x, 56x, 3Kx, 3Lx, 3Mx, 3Nx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 58x, 59x, 5Ax, 5Bx, 5Cx, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Rx, 4Sx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 5Dx, 5Ex, 5Fx, 5Gx, 5Hx, 5Jx, 5Kx, 5Lx, 5Mx, 5Nx, 5Px, 5Qx...
Page 103 Table 8. Parts list—Overall (continued) No. FRU (Overall) SATA hard disk drive, 250 GB, 5,400 rpm • 0196-CTO, 23x, 27x, 2Ax, 2Cx, 3Bx, 3Rx, 3Yx, 44x, 48x, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Wx, 54x, 5Dx, 5Ex, 5Fx, 5Gx, 5Hx, 5Nx, 5Px •...
Page 104 Table 8. Parts list—Overall (continued) No. FRU (Overall) SATA hard disk drive, 500 GB, 5,400 rpm • 0196-CTO, 2Gx, 2Jx, 2Lx, 2Qx, 37x, 38x, 39x, 3Ax, 3Cx, 55x, 56x, 3Lx, 3Mx, 3Nx, 59x, 42x, 43x, 46x, 47x, 4Ax, 4Bx, 5Jx, 5Kx •...
Page 105 Table 8. Parts list—Overall (continued) No. FRU (Overall) System board assembly, AMD Turion Neo X2 Dual-Core L625 • 0197-CTO, 22x 23x 24x 73x, 2Fx, 2Nx, 2Qx, 2Rx, 2Tx, 2Ux, 2Wx, 2Zx, 33x, 34x, 36x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px, 3Qx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 48x, 49x, 4Ax, 4Bx, 4Cx, 4Jx, 4Kx, 4Lx, 4Mx, 4Nx, 4Qx, 4Sx, 4Ux, 4Vx, 4Wx, 4Xx, 4Yx, 4Zx, 52x, 53x, 54x, 5Dx, 5Ex, 5Fx, 5Gx, 5Hx, 5Jx, 5Kx, 5Lx, 5Wx, 5Xx, 5Yx, 63x, 66x, 6Nx, 6Px, 6Tx, 6Ux, 6Vx, 6Wx, 75x, 78x, 7Cx, 7Ex, 7Fx, 7Gx, 7Hx, 7Jx, 7Kx, 7Lx, 7Mx, 7Nx,...
Page 106 Table 8. Parts list—Overall (continued) No. FRU (Overall) • 0217-CTO, 22x, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x, 38x, 39x, 3Ax, 3Dx, 3Cx, 3Bx, 3Ex, 3Fx, 3Gx •...
Page 107: Lcd Frus
LCD FRUs Chapter 10 Parts list...
Page 108 Table 9. Parts list—13.3-inch HD LED-backlight LCD No. FRU (13.3-inch HD LED-backlight LCD) LCD bezel assembly for 0196, 0197, and 0492 LCD bezel assembly for 0217, 0221, and 0250 Hinges, black • 0196-CTO, 22x, 24x, 25x, 26x, 27x, 28x, 2Ax, 2Bx, 57x, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Xx, 2Yx, 2Zx, 35x, 36x, 39x, 3Ax, 3Bx, 3Cx, 3Ex, 3Fx, 3Hx, 3Jx, 56x, 3Lx, 3Mx, 3Qx, 3Sx, 3Ux, 58x, 59x, 5Ax, 5Bx, 3Yx, 3Zx, 42x, 43x, 44x, 45x, 46x, 47x, 4Dx, 4Ex, 4Gx, 4Jx, 4Lx, 4Mx, 4Qx, 4Rx, 4Sx, 4Ux, 4Vx, 4Wx, 4Yx, 53x, 54x, 5Ex, 5Fx, 5Gx, 5Hx,...
Page 109 Table 9. Parts list—13.3-inch HD LED-backlight LCD (continued) No. FRU (13.3-inch HD LED-backlight LCD) 7Ax, 7Bx, 7Cx, 7Dx, 7Ex, 7Fx, 7Gx, 7Hx, 7Jx, 7Kx, 7Lx, 7Mx, 7Nx, 7Px, 7Qx, 7Rx, 7Sx, 7Tx, 7Ux, 7Vx, 7Wx, 7Xx, 7Yx, 7Zx, 82x, 83x, 84x, 85x, 86x, 87x, 88x, 89x, 8Ax, 8Bx, 8Cx •...
Page 110: Keyboard
Table 9. Parts list—13.3-inch HD LED-backlight LCD (continued) No. FRU (13.3-inch HD LED-backlight LCD) LCD rear cover assembly (midnight black gloss) • 0217-CTO, 22x, 2Ax, 2Ex, 2Hx, 2Kx, 2Px, 2Qx, 2Sx, 2Ux, 3Bx • 0221-CTO, 22x, 27x, 2Bx, 2Ex, 2Hx, 2Lx, 2Nx, 2Qx, 2Sx, 3Ax, 3Cx, 3Fx •...
Page 111: Ac Adapters
Table 10. Parts list—Keyboard (continued) Language Danish Dutch Finnish, Swedish French German Greek (U.S. English and Greek layout) Hebrew Hungarian Icelandic Indian English Italian Japanese Kazakhstan Korean Latin American Spanish Norwegian Polish Portuguese Russian Slovak Slovenian Spanish Swiss Thai Traditional Chinese Turkish U.K.
Page 112: Miscellaneous Parts
Table 12. Parts list—3-pin AC adapters 3-pin (65 W, 20 V) adapter (models CTO, xxG, xxM, xxQ, xxA, xxT, xxK, xxC, xxB, xxH, xxV) 3-pin (65 W, 20 V) adapter (models CTO, xxG, xxM, xxQ, xxA, xxT, xxK, xxC, xxB, xxH, xxV) 3-pin (65 W, 20 V) adapter (models CTO, xxG, xxM, xxQ, xxA, xxT, xxK, xxC, xxB, xxH, xxV) Miscellaneous parts Table 13.
Page 113: Recovery Discs
Table 15. Parts list—3-pin power cords Country or region Australia, New Zealand • models -CTO, xxM Bangladesh, Sri Lanka, South Africa • models -CTO, xxG Canada, U.S. • models -CTO, xxG, xxT China (P.R.C.) (other than Hong Kong S.A.R.) • models -CTO, xxC Denmark •...
Page 114: Windows 7 Home Premium (32 Bit) Dvds
Table 16. Parts list—Windows 7 Home Basic (32 bit) recovery DVDs Language Brazilian Portuguese Indian English Russian Russian English Serbian-Latin Simplified Chinese Spanish Turkish US English • 0217-CTO, 2Zx, 32x, 3Ax, 3Fx, 3Gx • 0221-CTO, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Zx, 32x, 33x, 34x, 36x •...
Page 115: Windows 7 Home Premium (64 Bit) Dvds
Table 18. Parts list—Windows 7 Home Premium (32 bit) recovery DVDs Language Brazilian Portuguese C&L Hong Kong S.A.R. (Traditional Chinese/English/Simplified Chinese) Korean Indian English Norwegian Russian Russian English Simplified Chinese Spanish Traditional Chinese Traditional Chinese (Hong Kong S.A.R.) US English •...
Page 116 Table 20. Parts list—Windows 7 Home Premium (64 bit) recovery DVDs (continued) Language Czech Danish French Greek German Hebrew Hungarian Indian English Italian Japanese Polish Portuguese Romanian Slovak Slovenian Spanish Serbian-Latin Turkish US English Hardware Maintenance Manual P/N (with P/N (with MS 2010) MS 2007) 03W6720...
Page 117: Windows 7 Professional (32 Bit) Dvds
• 0217-CTO, 22x, 26x, 2Ex, 2Fx, 2Gx, 2Qx, 2Rx, 35x, 37x, 38x, 39x, 3Bx • 0221-CTO, 22x, 24x, 2Sx, 2Tx, 35x, 38x, 39x, 3Ax, 3Ex, 3Fx • 0250-CTO, 22x, 23x, 24x, 25x, 2Jx, 2Kx, 2Lx, 2Mx Table 21. Parts list—Windows 7 Home Premium (64 bit) recovery DVDs Language Arabic Brazilian Portuguese...
Page 118: Windows 7 Professional (64 Bit) Dvds
Table 22. Parts list—Windows 7 professional (32 bit) recovery DVDs Language Arabic Brazilian Portuguese C&L BelLux (English/French/German/Dutch) C&L Hong Kong (Hong Kong/English/Simplified Chinese) C&L Sweden (English/Finland/Swedish ) C&L Switzerland (English/French/German/Italian) Czech Danish French Greek German Hebrew Hungarian Indian English Italian Japanese Korean Norwegian...
Page 119 • 0197-CTO, 22x 23x 25x 73x, 2Dx, 2Nx, 2Ux, 3Mx, 3Nx, 3Qx, 4Qx, 4Sx, 4Ux, 6Nx, 6Px, 6Wx, 7Gx, 7Hx, 7Kx, 7Lx, 7Nx, 7Zx, 82x, 83x, 85x • 0492-CTO Table 23. Parts list—Windows 7 Professional (64 bit) recovery DVDs Language Arabic Brazilian Portuguese C&L BelLux (English/French/German/Dutch)
Page 120 • 0217-CTO, 23x, 24x, 25x, 27x, 2Bx, 2Cx, 2Dx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 33x, 34x, 36x, 3Dx, 3Cx • 0221-CTO, 23x, 25x, 28x, 29x, 2Lx, 2Mx, 2Nx, 2Px, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 37x •...
Page 121: Common Service Tools
USB cable USB floppy diskette drive for maintenance diskette USB floppy diskette drive tool kit Test card for integrated Smart Card LENOVO ThinkPad Hardware Maintenance Diskette Version 1.76 or later Note: Download the file from the following Web site: http://support.lenovo.com 95F3598...
Page 122 Hardware Maintenance Manual...
Page 123: Appendix A. Notices
Lenovo representative for information on the products and services currently available in your area. Any reference to a Lenovo product, program, or service is not intended to state or imply that only that Lenovo product, program, or service may be used. Any functionally equivalent product, program, or service that does not infringe any Lenovo intellectual property right may be used instead.
Page 124: Trademarks
Trademarks The following terms are trademarks of Lenovo in the United States, other countries or both: Active Protection System Lenovo ThinkPad ThinkVantage TrackPoint UltraNav Microsoft and Windows are trademarks or registered trademarks of the Microsoft group of companies. The following terms are trademarks of Intel Corporation or its subsidiaries in the United States, other countries, or both.
Page 126 Part Number: 63Y0744_03 (1P) P/N: 63Y0744_03 *63Y0744_03*...

This manual is also suitable for:

Thinkpad edge 13 Thinkpad e31

Lenovo THINKPAD E30 Hardware Maintenance Manual

About this Manual

Chapter 1. Safety Information

Chapter 2. Important Service Information

Chapter 3. General Checkout

Chapter 4. Related Service Information

Chapter 5. Status Indicators

Chapter 6. Special Keys

Chapter 7. FRU Replacement Notices

Chapter 8. Removing and Replacing a FRU

Chapter 9. Locations

Chapter 10. Parts List

Appendix A. Notices

Quick Links

Related Manuals for Lenovo THINKPAD E30

Summary of Contents for Lenovo THINKPAD E30

This manual is also suitable for:

Table of Contents