How To Order Repair Parts; Parts List - Empire DV-20E-5 Installation Instructions And Owner's Manual

Parts can be ordered only through your service person or dealer. For best results, the service person or dealer should order parts through
the distributor. Parts can be shipped directly to the service person/dealer.
All parts listed in the Parts List have a Part Number. When ordering parts, first obtain the Model Number from the name plate on your
equipment. Then determine the Part Number (not the Index Number) and the Description of each part from the following appropriate
illustration and list. Be sure to give all this information.
Furnace Model Number
Furnace Serial Number
Type of Gas (Propane or Natural)
Do not order bolts, screws, washers or nuts. They are standard hardware items and can be purchased at any local hardware store.
Shipments contingent upon strikes, fires and all causes beyond our control.
Empire Comfort Systems, Inc. Nine Eighteen Freeburg Ave. Belleville, IL 62222-0529
PLEASE NOTE: When ordering parts, it is very important that part number and description of part coincide.
INDEX PART
NO. NUMBER
1 DV-1378
2 DV-1376
3 R-2521
4 DV-1375
5 DV-1379
6 DV-1048
7 R-2586
8 19676
9 DV-1373
10 DV-1368
11 R-2584
12 R-2573
13 R-2598
14 R-1279
15 DV-1367
16 R-2546
17 R-2522
18 19561
19 DV-1370
20 R-1995
21 R-6989
22 R-8140
23 R-2577A
24 DV-1365
25 R-1468
26 R-2099
27 DV-1371
28 DV-1372
29 15790
29 15791
30 R-2519
31 DV-1169
32 R-2523
33 15783
33 15784
34 19565
37 R-2543
38 R-2541
19562-1-0606

HOW TO ORDER REPAIR PARTS

PARTS LIST

DESCRIPTION
SHROUD TOP
SHROUD SIDE RIGHT
AIR FILTER
FILTER RETAINER
WALL MOUNTING BRACKET
WALL BRACKET - 2 REQUIRED
CONTROL DOOR PIN - 2 REQUIRED
CONTROL DOOR ASSEMBLY
CASING TOP
BLOWER HOUSING - 2 REQUIRED
BLOWER WHEEL - 2 REQUIRED
BLOWER MOTOR
MOTOR BASE WASHER - 4 REQUIRED
LIMIT SWITCH
INNER TOP
CONTROL KNOB
ON/OFF SWITCH
JUNCTION BOX
JUNCTION BOX COVER
TRANSFORMER
PRESSURE SWITCH
CONTROL BOARD
TEMPERATURE CONTROL BOARD
CASING WELDED ASSEMBLY
STRAIN RELIEF BUSHING
CORD SET
INNER END
CASING SIDE - 2 REQUIRED
COLLECTOR BOX (DV-20E-5 ONLY)
COLLECTOR BOX (DV-40E-5 ONLY)
INDUCER WHEEL
INDUCER BLOWER HOUSING
INDUCER MOTOR
EXCHANGER ASSEMBLY (DV-20E)
EXCHANGER ASSEMBLY (DV-40E)
IGNITOR KIT
FLAME SENSOR
BURNER (2 REQUIRED ON DV-40E-5)
Part Description
Part Number
INDEX PART
NO. NUMBER
39 R-2575
40 DV-1038
41 DV-1039
42 R-3237
42 R-3238
43 DV-1366
44 DV-1016
44 DV-1013
45 P-88-44
45 P-88-55
45 P-88-44
45 P-88-55
46 M-148
47 DV-781
48 M-155
49 DV-1040
50 DV-1024
51 DV-1363
52 DV-1380
53 R-2539
54 R-3113
55 R-3111
56 DV-1192
57 R-3114
58 R-3115
59 R-2587
60 DV-1195
61 DV-1193
62 DV-1194
63 DV-1377
NS DV-1361
NS DV-1108
NS DV-1132
NS R-8142
DESCRIPTION
FLAME ROLLOUT SWITCH
BURNER COMPARTMENT ACCESS
PANEL
BURNER COMPARTMENT
GAS VALVE (NAT GAS)
GAS VALVE (LP GAS)
VALVE BRACKET ASSEMBLY
MANIFOLD ASSEMBLY (DV-20E-5 ONLY)
MANIFOLD ASSEMBLY (DV-40E-5 ONLY)
ORIFICE (NAT GAS) - 1 REQUIRED ON
DV-20E-5
ORIFICE (LPG GAS) - 1 REQUIRED ON
DV-20E-5
ORIFICE (NAT GAS) - 2 REQUIRED ON
DV-40E-5
ORIFICE (LPG GAS) - 2 REQUIRED ON
DV-40E-5
MANIFOLD GASKET
OBSERVATION HOLE COVER ASSEMBLY
OBSERVATION HOLE COVER GASKET
FRONT SHIELD ASSEMBLY
BOTTOM SHIELD
FRONT GRILL ASSEMBLY
CASING FRONT ASSEMBLY
HOSE CLAMP - 4 REQUIRED
INLET HOSE
OUTLET ELBOW
VENT PAN ASSEMBLY
INLET CAP
WALL PLATE GASKET - INSIDE
WALL PLATE GASKET - OUTSIDE
WALL PLATE - OUTSIDE
TUBE SPACER
END CAP ASSEMBLY
SHROUD SIDE LEFT
BAFFLE - 1 REQUIRED ON DV-20E-5
CONDENSATE KIT
ELBOW KIT
WIRE ASSEMBLY - CONTROL BOARD
Page 17