Fuses; Exchanging The Headlight Lamp; Replacing The Parking Light Bulb - KTM 640 LC4 Owner's Manual

A
1
3

Fuses

A
Fuse box
See "Removing the seat" to remove and mount the seat.
The fuses are numbered on the inside of the fuse box.
The fuses marked "RES" are spare fuses.
Main fuse
circuits.
2
Fuse (10 Ampere) protects the following power-consuming units:
– electronic speedometer
– capacitor
3
Fuse (10 Ampere) protects the following power-consuming units:
– ignition
– starter system
4
Fuse (10 Ampere) protects the following power-consuming units:
– flasher lights
– brake light
– horn
5
Fuse (10 Ampere) protects the following power-consuming units:
– headlight
– parking light
Replace a blown fuse only with an equivalent one. If a new fuse that has
just been set in gets blown again, you are strongly advised to have it
inspected by a KTM dealer.
U
NDER NO CIRCUMSTANCES IS A STRONGER FUSE ALLOWED TO BE SET IN OR A FUSE
ALLOWED TO BE
ELECTRICAL INSTALLATION

Exchanging the headlight lamp

Replacing the headlight bulb
Remove the headlight mask:
Remove screw
Tilt the headlight mask to the front and detach from the lower fender.
Exchanging the headlight lamp:
Disconnect plug
Remove the rubber cap
Unhook the retaining bracket, then remove the bulb.
When inserting the new bulb make sure that the wider of the 3 tongues
is located in the corresponding groove in the socket.
N
EVER TOUCH THE GLASS OF THE BULB WITH YOUR FINGERS
MUST REMAIN ABSOLUTELY FREE FROM GREASE
GREASE TO EVAPORATE AND SETTLE DOWN ON THE REFLECTOR
2
Hook in the retaining bracket, mount the rubber cap and connect the plug
to the bulb.
Mount the headlight mask:
Position the headlight mask such that the headlight is located under the
cockpit.
Fit the headlight mask into the fender and mount screws
5
Replacing the parking-light bulb
Disassemble the headlight as described above and simply pull the bulb
socket 5 out of the reflector.
4
is located under the seat.
1
(20 amperes) protects all power consumers against short
!
CAUTION
" ". A
REPAIRED N INEXPERT TREATMENT COULD DAMAGE THE WHOLE
!
1
on the left and right.
2 from the bulb.
3
!
CAUTION
!
!
. T
HE GLASS OF THE BULB
. H
EAT WILL OTHERWISE CAUSE THE
.
1
.
33
4