Routine Inspection; Engine Oil Inspection And Change; Inspection And Maintenance Before Riding - Sym Scooter User Manual

(Please refer to the components location diagram for the following components.)

ROUTINE INSPECTION

Check Items
Engine Oil
Fuel
Front
Brake
Rear
Front
tires
Rear
Steering Handle
Speedometer, lights,
and rearview mirror
Tightness of Main
Components
Abnormal Points
CAUTION:
• If any problem founded during routine inspection, correct the problem before using the scooter again,
have your scooter checked and repaired by the "SYM dealer or authorized service personnel" if
necessary.

ENGINE OIL INSPECTION AND CHANGE

INSPECTION:
1. Use the main parking stand to support the scooter on a level ground, remove the dipstick after engine
stopped for 3~5 minutes. Wipe oil off the dipstick and then insert it into the guide tube again (Do not
rotate it.)
2. Remove the dipstick and check whether oil level is in between the upper and lower marks.
Add oil to upper limit if oil is under the lower limit. (Check cylinder, crankcase...etc for leakage.)
OIL CHANGE:
• Change engine oil after the first 300km, and change the engine oil
every 3,000km thereafter. Clean oil filter after the first 300km, and
clean oil filter every 6,000km.
• In order to maintain the engine's maximum performance, check
whether the engine oil is enough every 1,000km. Add oil to upper
limit if the engine oil has been found to be inadequate.
• Engine Oil : Use API SH, SAE 10w-40 grade or better engine oil.
Otherwise, damage will not be covered by warranty.
※ Recommended Oil: SYM Genuine EXTRA 4X OIL.
• Oil Capacity :
GTS 300/250：1.4 Liter (1.2 liters for routine change),
oil filter change: 1.2 liters.
GTS 125：1.0 Liter (0.8 liters for routine change),
oil filter change: 0.8
Is there enough engine oil?
Is it enough? Is it Octane 90 or above
Braking condition?
(Brake lever free play: 10~20mm)
Braking condition?
(Brake lever free play: 10~20mm)
Is tire pressure normal?
(Standard: 1.5kg/cm
Is tire pressure normal?
(Standard: 2.25 kg/cm
Does the handle vibrate abnormally or is difficult to turn?
Is it operated properly?
Do lights come on? Can it be seen clearly from behind?
Are screws, nuts loosen?
Do the previous troubles still exist?
liters.
Check Key Points
2
)
2
for 1 person, 2.5 kg/cm

10. Inspection and maintenance before riding

2
for 2 persons)
Upper
Lower
17