Upflow / horizontal two-stage
gas furnace (48 pages)
Summary of Contents for Goodman GKS9
Page 1
• Model numbers listed on page 3. ® This manual is to be used by qualified, professionally trained HVAC technicians only. Goodman RT6612017 Rev. 3 does not assume any responsibility for property damage or personal injury due to improper February 2010 service procedures or services performed by an unqualified person.
Disconnect ALL power before servicing or installing this unit. Multiple power sources may be present. Failure to do so may cause property damage, personal injury or death. Installation and repair of this unit Goodman will not be responsible WARNING WARNING should be performed ONLY by...
Page 3
WARNING that is not design certified by damage, personal injury, or death, Goodman for use with this unit. do not store combustible materials or use gasoline or Serious property damage, personal injury, reduced unit other flammable liquids or vapors in the vicinity of this performance and/or hazardous conditions may result appliance.
3. Conversion kits for high altitude natural or propane gas General Operation operation are available. See High Altitude Derate chart The GKS9 furnaces are equipped with an electronic ignition for details. device used to light the burners and an induced draft blower 4.
COMPONENT IDENTIFICATION Upflow/Horizontal 1 Gas Valve 16 Electrical Connection Inlets (Alternate) 2 Gas Line Entrance (Alternate) 17 Coil Front Cover Drain Port 3 Combustion Air Intake Connection / “Coupling” 18 Drain Line Penetrations 4 Hot Surface Igniter 19 Blower Door Interlock Switch 5 Burners 20 24-Volt Thermostat Connections 6 Rollout Limit...
Page 6
COMPONENT IDENTIFICATION GKS9 DISCHARGE DISCHARGE (DISCHARGE) 20 13/16 STANDARD GAS INTAKE SUPPLY HOLE PIPE CONDENSATE 2" PVC DRAIN TRAP w/ 3/4" PVC HIGH VOLTAGE DISCHARGE ELECTRICAL HOLE (RIGHT OR LEFT SIDE) HIGH VOLTAGE LEFT SIDE ELECTRICAL HOLE DRAIN LINE HOLES...
Page 7
Note: All negative pressure readings are in inches of water column (" w.c.). * GKS9 furnaces are shipped without coil cover pressure switches. All GKS9 models are shipped from the factory as Dedicated Upflow but can be installed as a Horizontal Left or a Horizontal Right, ONLY after installing GKS9 Horizontal Installation Kit 0270K00012, which contains...
PRODUCT DESIGN T.O.D. PRIMARY LIMIT Part Number 20162903 20162904 20162906 Open Setting (°F) GKS90453BX* GKS90703BX* GKS90704CX* GKS90904CX* GKS90905DX* GKS91155DX* ROLLOUT LIMIT SWITCHES 10123514 Part Number 10123533 Open Setting (°F) GKS90453BX* GKS90703BX* GKS90704CX* GKS90904CX* GKS90905DX* GKS91155DX* AUXILIARY LIMIT SWITCHES Part Number 10123519 10123535 Open Setting (°F)
Page 9
A large array of Amana ® brand coils are available for use with the GKS9 furnaces, in either upflow or horizontal (with appropriate pressure switch kit) applications. These coils are available in both cased and uncased models (with the option ®...
PRODUCT DESIGN Thermostats: NOTE: Complete lineup of thermostats can be found in the Thermostat Specification Sheets. Filters: Filters are required with this furnace and must be provided by the installer. The filters used must comply with UL900 or CAN/ULCS111 standards. Installing this furnace without filters will void the unit warranty. Upflow Filters This furnace has provisions for the installation of return air filters at the side and/or bottom return.