Related Manuals for GE PTV15SAMR
Summary of Contents for GE PTV15SAMR
- Page 1 GE Appliances Service Training _____________________________...
- Page 5 Ö Ö Ö Ö Ö Ö Ö Ö Ö Ö Ö Ö Ö Ö Ö Ö Ö Ö...
- Page 6 Ö Ö Ö Ö Ö Ö Ö Ö Ö Ö Ö Ö...
- Page 7 SAMR SAMR SAMR SAMR SAMR SAMR SAMR SAMR...
- Page 8 PTV15 / PTU427 / PTQ440 / PTG440 has 2 Transparent Plastic Shelves & 3 Door Racks PTV16 / PTU463 / PTQ470 / PTG470 has 3 Transparent Plastic Shelves & 4 Door Racks...
- Page 15 BLACK BLUE GRAY GRAY BLUE YELLOW BROWN GREEN BROWN ORANGE GREEN WHITE BLACK WHITE...
- Page 18 5.1.1 No Defrosting Operation Is Necessary 5.1.2 Where is melted ice brought?
- Page 19 5.1.3 The following circuit diagrams in the table show automatic defrosting function of the refrigerator with timer and defrost thermostat. · · · · · · · ·...
- Page 20 · · · · · · · ·...
- Page 21 5.1.4 As a reference to determine the causes of trouble, malfunction and phenomena are described. Refer to the following when repairing...
- Page 23 5.3.2 Inspection of defrost device 5.3.1 Inspection of cooling unit...
- Page 24 Mark: Refrigerant flow Mark: Brazing portion Hot pipe (Side condenser) (DP-condenser) (Side condenser) Back condenser Evaporator Suction pipe Bottom condenser Compressor Capillary tube Dryer...
- Page 25 7.1.3 Note to Use 7.1.1 Role 7.1.2 Composition...
- Page 26 7.2.4 Relation of PTC-Starter and OLP 7.2.1 Composition of PTC-Starter 7.2.2 Role of PTC-Starter 7.2.5 Note to Use PTC-Starter 7.2.3 Motor Restarting and PTC Cooling...
- Page 27 7.3.1 Definition of OLP 7.3.2 Role of OLP...
- Page 28 A ir flow in fr eezer Quar tz E lectr ic tube tube P latinum deodor ant A ir flow in D iagr am of defr os t ing heat er P latin um r efr iger ator deodor ant A ir flow in fr eez er A ir flow in r efr iger ator...
- Page 29 1. Not cold at all (freezing storage and cooling chamber are not cold) Is the plug being inserted? Insert the power plug. Any shutdown? Is the plug being inserted? Check the abnormal power cord or switch Is a special socket used by the Is the socket affected by other Is the voltage over 99V? refrigerator?
- Page 30 The contacting point being poor? Repair the contacting point. * Remove the pin from the connecting point and check if it has turned into black. Abnormal Is the circuit of compressor coil Replace the compressor and normal? drying filter Ice beads or serious frost formed in the * Check the circuit of main coil, auxiliary coil and cooler chamber resistance value.
- Page 31 2. Not Cold Enough Is the turn button set at "Strong" Is the turn button set at position? "Strong" position? Only freezing room (including 0°C room) Setting the temperature of each Confirm the bumper cohesion Fully closed Replace bumper thermostat chamber in the storage.
- Page 32 3. Fail to defrost Lesser frost Clearance of door knob and forget Confirm the frosting of the cooler to close the freezing chamber door more frost Is the coil circuit of D meter Replace D meter (broken coil) working? Green & black circuit of D meter Turn the pin of D meter to defrost Replace D meter (poor operation of...
- Page 33 4. Too cold Is the turn button set at "Strong" Turn the button at "Weak" position. position? * If setting the button of the freezing chamber at "Strong" while the cooling chamber is at "Medium", then the cooling chamber and freshness-keep chamber will become too cold.
- Page 34 5. Unusual Noise Unusual noise during the compressor running in the Is the ground horizontally flat? Adjust by the adjusting foot. mechanical room. If the mechanical piping being Be properly adjusted. slanted or contacted. If all the piping in the Adjust the location of counter- mechanical room are weight...
- Page 35 · · · · · · · · · · · · · · · · ·...
- Page 36 · · · · · · · · · · · · · ·...
- Page 37 · · · · · · · · · · · · · · ·...
- Page 38 · · · · · · · · · · · ·...
- Page 39 · · · · · · · · · · · · · · · ·...
- Page 40 · · · · · · · · ·...
- Page 41 G. Containing air G. Containing air E. Clogged by dusts E. Clogged by dusts C. Slight air C. Slight air A. Too much A. Too much that cannot be that cannot be I. Air leakage (suction tube) (suction tube) leakage leakage freon freon...
- Page 42 → → → → →...
- Page 44 Compound Pressure Gauge Vacuum pump Freon filling tank...
- Page 45 Additional valve Compound Pressure Gauge Vacuum pump H pressure tube L pressure tube Freon tank Freon filling tank...
- Page 46 • Compressor • Cautions in case of freon leakage of the freezing system: Capillary tube Suction tube Dryer Discharge tube Base board...
- Page 47 Internal heat dissipater Dryer side Back side heat dissipater Blow nitrogen from the cooling tube of compressor oil Bottom side heat dissipater Blow nitrogen from back side heat dissipater Blow nitrogen from the filling tube of compressor Compressor Blow nitrogen from the cooling tube of compressor...
- Page 48 Œ Ž Œ Ž Freon tank Filling tank Vacuum pump To the filling tube Diversified tube at the of compressor dryer side CB (liquid side) Filling tank...
- Page 49 Valve Regulation...
- Page 50 Close the valve at pressure 1.0 kgf/cm G • Open the valves by 1 2 sequence Close the valve at pressure 1.0 kgf/cm...
- Page 51 Vacuum pump stops...
-
Page 56: Part List And Exploded View
XII. PART LIST AND EXPLODED VIEW PTV15SAMR / PTU427SAMR / PTQ440SAMR / PTG440SAMR PART NO. DESCRIPTION 73 LPIN-0053K2FS-- STOPPER 73 LPIN-0053K2FS-- STOPPER 78 LPLTM0811K2F0-- DRYER CLAMPER 49 LPLTP0176K2FS-- DRAIN HOLE COVER 49 LPLTP0176K2FS-- DRAIN HOLE COVER 51 LX-XZ0064K2E0-- FIX SCREW... - Page 66 XII. PART LIST AND EXPLODED VIEW PTV16SAMR / PTU463SAMR / PTQ470SAMR / PTG470SAMR PART NO. DESCRIPTION 57 USRA-0014K2FB-2 EVAPORATION PAN 15 USRA-0014K2FQ-2 EVAPORATION PAN * 51 06 UTNA-0018K2FA-- EGG STORAGE BUCKET * 51 06 UTNA-0018K2FA-- EGG STORAGE BUCKET 45 HDECQ0463K21S-- GLASS TRIM 45 HDECQ0463K21S-- GLASS TRIM...
- Page 67 XII. PART LIST AND EXPLODED VIEW PTV16SAMR / PTU463SAMR / PTQ470SAMR / PTG470SAMR PART NO. DESCRIPTION 89 PCOV-0592K2FS-- MULTI AIR LOUVER 89 PCOV-0592K2FS-- MULTI AIR LOUVER 45 PGID-0054K2F0-- MULTI AIR GUIDE * 72 27 RLMP-0035K2E0-- LAMP 46 QW-VZ0857K2E0-- LAMP HOLDER WIRING 01 QSOC-0065K2E0-- LAMP HOLDER 51 LHLD-0203K2FS--...
- Page 72 XII. PART LIST AND EXPLODED VIEW PTV19SAMR / PTU527SAMR / PTQ530SAMR / PTG530SAMR PART NO. DESCRIPTION 13 LHLD-0227K2FS-- DRAIN CONNECTOR 13 LHLD-0227K2FS-- DRAIN CONNECTOR 14 FEVA-0295K2K0-2 EVAPORATOR 49 LHLD-0208K2P0-- DEFROST HEATER SUPPORT 25 LHLD-0446K2P0-1 DEFROST HEATER COVER * 05 02 RHET-0184K2E0-- DEODER DEFROST HEATER 82 DCAB-0723K2KQ-- CABIENT ASS'Y...
- Page 77 XII. PART LIST AND EXPLODED VIEW PTV19SAMR / PTU527SAMR / PTQ530SAMR / PTG530SAMR PART NO. DESCRIPTION 15 PCOV-0155K2FS-- EV SCREW COVER 15 PCOV-0155K2FS-- EV SCREW COVER 56 PSEL-0213K2E0-- SEAL 26 GLIN-0414K2P0-- F DOOR LINER 41 JHNDM0012K2GA-1 F DOOR HANDLE – 22MM OLD 07 JHNDM0081K2GA-- F DOOR HANDLE –...
- Page 80 XII. PART LIST AND EXPLODED VIEW PTV20SAMR / PTU565SAMR / PTQ570SAMR / PTG570SANR PART NO. DESCRIPTION 13 LHLD-0227K2FS-- DRAIN CONNECTOR 13 LHLD-0227K2FS-- DRAIN CONNECTOR 14 FEVA-0295K2K0-2 EVAPORATOR 49 LHLD-0208K2P0-- DEFROST HEATER SUPPORT 25 LHLD-0446K2P0-1 DEFROST HEATER COVER * 05 02 RHET-0184K2E0-- DEODER DEFROST HEATER 64 DCAB-0724K2KQ-- CABIENT ASS'Y...
- Page 82 XII. PART LIST AND EXPLODED VIEW PTV20SAMR / PTU565SAMR / PTQ570SAMR / PTG570SANR PART NO. DESCRIPTION 14 UPAN-0097K2KS-1 GLASS SHELF 14 UPAN-0097K2KS-1 GLASS SHELF 84 UPAN-0055K2F0-- F TRANSPARENT SHELF SMALL 01 URCV-0068K2F0-- CHILL ROOM 56 URCV-0079K2F0-- ICE STORAGE BOX 78 URCV-0096K2F0-- VAGETABLE CRISPER 57 USRA-0014K2FB-2 2 EVAPORATION PAN...
- Page 85 XII. PART LIST AND EXPLODED VIEW PTV20SAMR / PTU565SAMR / PTQ570SAMR / PTG570SANR PART NO. DESCRIPTION 15 PCOV-0155K2FS-- EV SCREW COVER 15 PCOV-0155K2FS-- EV SCREW COVER 26 GLIN-0414K2P0-- F DOOR LINER 56 PSEL-0213K2E0-- SEAL 07 JHNDM0012K2GA-1 F DOOR WITH 22MM HANDLE 36 JHNDM0081K2GA-- F DOOR WITH 19MM HANDLE 78 JHNDM0013K2GA-1...