Page 1 CCD-TRV15/TRV15PK/TRV15E/ System CCD-TRV15/TRV15PK/TRV25/ Filter diameter 17/16 in. (37 mm) Video recording system TRV25PK/TRV35/TRV65/TRV65PK/ TRV15EP/TRV25/TRV25PK/TRV215 : CCD-TRV15 (US,CND)/TRV15E CCD-TRV65/TRV65PK/TRV85/TRV93/ TRV85/TRV93/TRV215/TRV615/ 3/16 - 2 5/8 in. (4.1 - 65.6 mm) TRV615/TRV815 : 4 rotary heads (SP/ (AEP,UK)/TRV25 (AEP,UK)/TRV215 : CCD-TRV35/TRV35E/TRV65/ TRV815 :...
Page 2: Camera Recording
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU PUBLISHED BY SONY.
Page 3 – 3 –...
Page 4 CCD-TRV15E only !¡ 2 pin conversion adaptor (1) 4 CR2025 Lithium Battery (1) CCD-TRV15 : E, HK/TRV15PK/TRV25PK/TRV35 : E, HK/ The lithium battery is already installed in your camcorder. TRV35E : E, HK 5 Size AA (R6) battery for Remote Commander !™...
Page 5: Service Note
SERVICE NOTE 1. POWER SUPPLY DURING REPAIRS In this unit, about 10 seconds after power is supplied (8.4V) to the battery terminal using the service power cord (J-6082-223-A), the power is shut off so that the unit cannot operate. Battery switch This following two methods are available to prevent this.
Page 6: Self-Diagnosis Function
SELF-DIAGNOSIS FUNCTION 1. Self-diagnosis Function 2. Self-diagnosis display When problems occur while the unit is operating, the self-diagnosis When problems occur while the unit is operating, the counter of the function starts working, and displays on the viewfinder or Display viewfinder or Display window shows a 4-digit display consisting window what to do.
Page 7: Self-Diagnosis Code Table
4. Self-diagnosis Code Table Self-diagnosis Code Symptom/State Correction Block Detailed Function Code Condensation. Remove the cassette, and insert it again after one hour. Clean with the optional cleaning cassette. Video head is dirty. Non-standard battery is used. Use the InfoLITHIUM battery. LOAD direction.
Page 8: Table Of Contents
TABLE OF CONTENTS SERVICE NOTE 2. DISASSEMBLY Power Supply During Repairs ......... 5 2-1. Removal of Front Panel Block and Video Light Block ..2-1 To Take out a Cassette when not Eject (Force Eject) ..5 2-2. Removal of Cabinet (R) Block ......... 2-2 2-3.
Page 9 • PD-93 (LCD) Board ............ 4-100 1-5. Monochrome Electronic Viewfinder System Adjustments • VF-120 (Color EVF (Color EVF Model)) Board ..4-107 (CCD-TRV15/TRV15E/TRV15EP/TRV15PK/ • LB-54 (Back Light) Board .......... 4-107 TRV25/TRV25PK/TRV35/TRV35E/TRV65/ • VF-99 (B/W EVF (B/W EVF Model)) Board .....4-115 TRV65PK/TRV85/TRV215/TRV615/TRV815) .....
Page 10 RP Filter f0 Adjustment (VC-195 board) ....5-50 Hi8 REC Y Current Adjustment (VC-195 board) (CCD-TRV85/TRV93/TRV615/ TRV815) ..............5-50 Standerd8 REC Y Current Adjustment (VC-195 board) (CCD-TRV15/TRV15E/ TRV15EP/TRV15PK/TRV25/TRV25PK/ TRV35/TRV35E/TRV215) ........5-51 Hi8 REC L Level Adjustment (VC-195 board) (CCD-TRV65/TRV65PK/ TRV85/TRV93/TRV615/TRV815) ......5-52...
Page 31: Disassembly
CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 SECTION 2 DISASSEMBLY The eqipment can be removed using the following procedure. VIDEO CAMERA RECORDER 2-1. FRONT PANEL BLOCK 2-8. EVF BLOCK-2(COLOR) 2-9. EVF BLOCK-2(B/W) 2-11. CASSETTE LID ASSEMBLY VIDEO LIGHT BLOCK (LB-5/VF-119/VF-120 BOARDS) (VF-99 BOARD) 2-2. CABINET (R) BLOCK 2-6.
Page 32: Removal Of Cabinet (R) Block
2-2. REMOVAL OF CABINET (R) BLOCK 2-4. REMOVAL OF LCD BLOCK (3/3.5 INCH) 7 LCD block 6 Four tapping screws 5 Connector 8 Hinge ground plate CN005,12P 6 Connector CN933,11P 2 Two screws (M2x4) 4 Connector 3 Three screws CN006,6P (M2x4) 3 IR knob 1 Five tapping screws...
Page 33: Removal Of Cf-51 Board And Control Switch Block (Mr-8500) (Color)
2-6. REMOVAL OF CF-51 BOARD AND CONTOROL 2-7. REMOVAL OF CF-50 BOARD AND CONTOROL SWITCH BLOCK (MR-8500) (COLOR) SWITCH BLOCK (MF-8500) (B/W) 7 FP-638 flexible board CN007, 20P 8 Flat cable (FFC-236) (COLOR EVF MODEL) 8 Flat cable (FFC-236) CN001, 50P 7 Flate cable(FCC-235) CN001, 50P CN008,4P...
Page 34: Removal Of Evf Block-2 (B/W)
2-9. REMOVAL OF EVF BLOCK-2 (B/W) 6 CRT holder assmebly 7 CRT assembly 3 Remove the EVF rear cabinet assembly 4 VF electrostatic sheet to the direction of arrow B . 2 Three screws (M2x3) 8 VF-99 board 5 Flexible flat cable(FCC-235) CN901,4P 1 Tilt-up the EVF block to the direction of arrow A .
Page 35: Removal Of Cassette Lid Assembly
2-11. REMOVAL OF CASSETTE LID ASSEMBLY 2-13. REMOVAL OF ZOOM LENS BLOCK AND VL-19 BOARD 1 Two screws (M2x4) CCD-TRV93 7 Two screws (M2x3) 8 Shoe bracket 2 Cassette lid assembly 3 Screw (M2x3) 5 FP-623 flexible board CN501, 16P 4 Zoom lens block 6 Lens flexible board CN551, 23P...
Page 36: Removal Of Vc-195 And Se-67 (Se-66) Board
2-15. REMOVAL OF VC-195 AND SE-67 (SE-66) BOARD 1 FP-220 flexible board 7 FP-629 flexible board 2 Flexible board CN105, 8P from loading motor CN101, 16P !¡ Screw (M2x3) from video head 3 Flexible board 8 FP-621 flexible board CN104, 10P CN902,12P from drum motor 9 FP-620 flexible board...
Page 37: Circuit Board Location
2-17. CIRCUIT BOARDS LOCATION 2.5 INCH LCD MODEL : CCD-TRV15/TRV15E/TRV15EP/ TRV15PK/TRV25/TRV25PK/ VF-99 T R V 3 5 / T R V 3 5 E / T R V 6 5 / (B/W EVF) TRV65PK/TRV215/TRV615 3 INCH LCD MODEL : CCD-TRV93 3.5 INCH LCD MODEL : CCD-TRV85/TRV815...
Page 38: Block Diagrams
CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 SECTION 3 BLOCK DIAGRAMS 3-1. OVERALL BLOCK DIAGRAM...
Page 39: Camera/Video 1 Block Diagram
CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 3-2. CAMERA/VIDEO 1 BLOCK DIAGRAM CAMERA REC 0.3Vp-p CAMERA REC IC001 TRIG : IC001 0.4Vp-p CAMERA REC CAMERA REC CAMERA REC 0.3Vp-p IC202 3Vp-p 1.3Vp-p CAMERA REC 0.5Vp-p IC001 1.3Vp-p IC001 IC401 IC202 IC502 CAMERA REC 3.2Vp-p 0.4Vp-p 0.4Vp-p...
Page 40 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 3-3. VTR/CAMEARA CONTROL BLOCK DIAGRAM 1.7Vp-p 20 MHz IC402 3Vp-p 13usec IC402 3Vp-p IC402 3Vp-p IC402 3Vp-p IC402 3-11 3-10...
Page 41: Servo Block Diagram
CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 3-4. SERVO BLOCK DIAGRAM 3Vp-p 13usec 3Vp-p IC402 0.76Vp-p 2.8msec 506 kHz IC402 IC801 1.2Vp-p 5.6msec IC451 3Vp-p 3Vp-p 1.2msec 0.76Vp-p IC402 IC402 507 kHz IC801 3Vp-p 13usec IC402 3-12 3-13 3-14...
Page 42: Mode Control Block Diagram
CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 3-5. MODE CONTROL BLOCK DIAGRAM 1.5Vp-p 20 MHz IC604 2.6Vp-p 32 kHz IC604 3-15 3-16 3-17 3-18...
Page 43: Audio Block Diagram
CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 3-6. AUDIO BLOCK DIAGRAM 0.5Vp-p 0.7Vp-p 0.09usec IC751 IC751 0.4Vp-p 0.34Vp-p IC301 0.09usec IC751 0.5Vp-p 2usec IC751 0.25Vp-p 3.58 MHz IC751 CAMERA REC 0.36Vp-p IC301 CAMERA REC 0.26Vp-p 3.58 MHz IC301 CAMERA REC 2.9Vp-p IC301 3-19 3-20 3-21...
Page 44 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 3-7. LCD (CCD-TRV35/TRV65/TRV65PK/TRV93/TRV615) BLOCK DIAGRAM IC4502/5502 4.7Vp-p IC4502 2.2Vp-p IC5502 4.2Vp-p 0.7Vp-p IC4502/5502 IC4502 2.3Vp-p IC5502 4.2Vp-p IC4502 2.3Vp-p IC5502 4.2Vp-p 0.44Vp-p 0.2Vp-p IC4502/5502 IC4502/5502 0.2Vp-p IC4502/5502 IC4601/5601 4.7Vp-p IC4601 Approx.7.5MHz : 4.7Vp-p IC5601 Approx.5.8MHz : 4.1Vp-p IC4601 4.7Vp-p...
Page 45 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 3-8. LCD (CCD-TRV15/TRV15PK/TRV15E/TRV15EP/TRV25/TRV25PK/TRV85/TRV215/TRV815) BLOCK DIAGRAM IC4502/5502 3Vp-p IC4502 3.3Vp-p IC5502 3.6Vp-p 0.7Vp-p IC4502/5502 IC4502 3.3Vp-p IC5502 3.6Vp-p IC5502 IC4502 3.3Vp-p 3.6Vp-p 0.44Vp-p 0.2Vp-p IC4502/5502 IC4502/5502 0.2Vp-p IC4502/5502 IC4601/5601 3Vp-p IC4601 Approx. 9.5MHz : 3.3Vp-p IC5601 Approx. 5.8MHz : 3.2Vp-p...
Page 46: Color Evf Block Diagram
CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 3-9. COLOR EVF BLOCK DIAGRAM 7.5Vp-p IC5401 7.2Vp-p IC5401 7.6Vp-p IC5401 3Vp-p IC5401 3Vp-p 12Vp-p IC5404 IC5301 3Vp-p IC5404 3.4Vp-p 1.84 MHz IC5404 23 24 3Vp-p 7.852 kHz IC5404 20 21 2.7Vp-p 3Vp-p 11.06 MHz IC5404 IC5404 2.4Vp-p...
Page 47: B/W Evf Block Diagram
CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 3-10. B/W EVF BLOCK DIAGRAM 2.2Vp-p IC901 1Vp-p IC901 3-32 3-33 3-34...
Page 48: Power Block Diagram
CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 3-11. POWER BLOCK DIAGRAM 3-35 3-36 3-37 3-38 E...
Page 49: Frame Schematic Diagram (1)
CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ SECTION 4 TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS 4-1. FRAME SCHEMATIC DIAGRAM (1) FRAME...
Page 50 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 FRAME SCHEMATIC DIAGRAM (2) FRAME...
Page 51: Cd-197/198 (Ccd Imager)
CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 CD-197/198 (CCD IMAGER) (2.5 INCH LCD, 3 INCH/3.5 INCH LCD MODEL) PRINTED 4-2. PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS WIRING BOARD – Ref No. CD-197 BOARD: 4,000 series, CD-198 BOARD: 9,000 series – THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS.
Page 52 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 VC-195 (CAMERA, Y/C PROCESSOR, IN/OUT, REC/PB HEAD AMP, SERVO/SYSTEM CONTROL, SERVO, AUDIO, IR TRANSMITTER, MODE CONTROL) PRINTED WIRING BOARD VC-195 BOARD (SIDE B) – Ref No. VC-195 BOARD: 1,000 series – R773 VC-195 BOARD (SIDE B)
Page 53 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 VC-195 BOARD (SIDE A) VC-195 BOARD (SIDE A) R527 B-17 C001 A-13 C328 C-11 CN908 A-17 R074 C-12 C004 A-14 C330 C-11 CN909 G-11 R075 C-13 R529 E-12 C004 B-13 C331 C-11 CN911 D-17 R081 D-13...
Page 54: (2.5 Inch Lcd, 3 Inch/3.5 Inch Lcd Model) Board
CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 VC-195 BOARD (1/10) CAMERA REC 2.3Vp-p NTSC : 28.636 MHz : 28.375 MHz IC501 CAMERA REC 2.3Vp-p NTSC : 14.32 MHz : 14.18 MHz IC501 11 12 CAMERA REC 7Vp-p IC501 CAMERA REC 7Vp-p IC501 CAMERA REC...
Page 55 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 • For schematic diagrams. • Refer to page 4–11 for Printed Wiring Board. 4-19 4-20 4-21 4-22 CAMERA (2) VC-195 (2/10)
Page 56 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 • For schematic diagrams. • Refer to page 4–11 for Printed Wiring Board. VC-195 BOARD (3/10) CAMERA REC CAMERA REC 0.34Vp-p 3.1Vp-p 3.58 MHz IC202 IC202 CAMERA REC CAMERA REC 0.84Vp-p 3Vp-p IC202 IC202 CAMERA REC CAMERA REC 0.5Vp-p...
Page 57 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 • For schematic diagrams. • Refer to page 4–11 for Printed Wiring Board. VC-195 BOARD (4/10) CAMERA REC 0.46Vp-p IC151 0.32Vp-p IC151 1.4Vp-p IC151 17 64 1.8Vp-p IC151 25 60 IC151 (2.1Vp-p) IC151 (1.6Vp-p) 4-29 4-30...
Page 58 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 • For schematic diagrams. • Refer to page 4–11 for Printed Wiring Board. VC-195 BOARD (5/10) CAMERA REC 0.3Vp-p IC001 CAMERA REC 0.3Vp-p IC001 TRIG : IC001 0.4Vp-p IC001 0.4Vp-p IC001 0.4Vp-p IC001 CAMERA REC 2.9Vp-p IC001 CAMERA REC...
Page 59 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 • For schematic diagrams. • Refer to page 4–11 for Printed Wiring Board. VC-195 BOARD (6/10) CAMERA REC 1.7Vp-p 20 MHz IC402 3Vp-p IC402 3Vp-p IC402 3Vp-p IC402 3Vp-p 13usec IC402 3Vp-p 13usec IC402 3Vp-p 13usec IC402 3Vp-p 1.2msec...
Page 60 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 • For schematic diagrams. • Refer to page 4–11 for Printed Wiring Board. VC-195 BOARD (7/10) CAMERA REC 1.2Vp-p 5.6msec IC451 3Vp-p IC451 3Vp-p 2.8msec IC451 4-38 4-39 4-40 SERVO VC-195 (7/10)
Page 61 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 • For schematic diagrams. • Refer to page 4–11 for Printed Wiring Board. VC-195 BOARD (8/10) CAMERA REC 2.9Vp-p IC301 0.4Vp-p IC301 CAMERA REC 0.36Vp-p IC301 CAMERA REC 0.26Vp-p 3.58 MHz IC301 4-41 4-42 4-43 4-44...
Page 62 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 • For schematic diagrams. • Refer to page 4–11 for Printed Wiring Board. VC-195 BOARD (9/10) VC-195 BOARD (10/10) 1.5Vp-p 0.25Vp-p 20 MHz IC604 3.58 MHz IC751 2.6Vp-p 0.5Vp-p 32 kHz IC604 2usec IC751 0.34Vp-p 0.09usec IC751 0.7Vp-p...
Page 63 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 • For schematic diagrams. • Refer to page 4–11 for Printed Wiring Board. • Refer to page 4–48 for Waveforms. 4-51 4-49 4-50 MODE CONTROL VC-195 (10/10)
Page 64 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 SE-66/67 (STEADY SHOT) (2.5 INCH LCD, 3 INCH/3.5 INCH LCD MODEL) PRINTED WIRING BOARD – Ref No. SE-66 BOARD: 4,000 series, SE-67 BOARD: 9,000 series – SE-66 SE-67 BOARD C451 SE-67 BOARD (SIDE B) SE-67 BOARD (SIDE A)
Page 65 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 PJ-83/84 (AV IN/OUT) (2.5 INCH LCD, 3 INCH/3.5 INCH LCD MODEL) PRINTED WIRING BOARD – Ref No. PJ-83 BOARD: 4,000 series, PJ-84 BOARD: 9,000 series – PJ-83 PJ-84 BOARD (SIDE B) PJ-84 BOARD PJ-83 BOARD (SIDE B) C101...
Page 66 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 MA-311/331 (STEREO MIC, LASER LINK) (2.5 INCH LCD MODEL) MA-312 (STEREO MIC, LASER LINK) (3 INCH/3.5 INCH LCD MODEL) PRINTED WIRING BOARDS PRINTED – Ref No. MA-311 BOARD: 3,000 series, MA-331 BOARD: 4,000 series – WIRING BOARD – Ref No. MA-312 BOARD: 9,000 series –...
Page 67 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 VL-19 (VIDEO LIGHT) PRINTED WIRING BOARD – Ref No. VL-19 BOARD: 9,000 series – VL-19 BOARD • For Printed Wiring Boards. C151 There are few cases that the part isn't mounted in this model is VL-19 BOARD (SIDE B)
Page 68 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 CF-50 (CONTROL (2.5 INCH LCD MODEL)) PRINTED WIRING BOARD – Ref No. CF-50 BOARD: 4,000 series – CF-50 BOARD (SIDE A) CF-50 BOARD BH001 B-10 CF-50 BOARD (SIDE B) C001 C002 CN001 CN002 CN003 CN005 CN006 CN007 CN008...
Page 69 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 4-67 4-68 4-69 CONTROL CF-50 (2.5 INCH LCD MODEL)
Page 70 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 4-71 4-72 4-70 CONTROL CF-51 (3 INCH/3.5 INCH LCD MODEL)
Page 71 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 CF-51 (CONTROL (3 INCH/3.5 INCH LCD MODEL) PRINTED WIRING BOARD – Ref No. CF-51 BOARD: 9,000 series – CF-51 BOARD (SIDE B) CF-51 BOARD (SIDE A) CF-51 BOARD BH001 R031 D-10 R038 C001 B-16 R038 D-10...
Page 72 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 PD-92 (RGB DECODER, LCD DRIVE, BACK LIGHT, LCD (2.5 INCH LCD MODEL)) PRINTED WIRING BOARD – Ref No. PD-92 BOARD: 10,000 series – PD-92 BOARD C5501 B-10 D5604 C-10 R5542 R5673 PD-92 BOARD (SIDE B) PD-92 BOARD (SIDE A)
Page 73 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 PD-92 BOARD (1/4) CAMERA REC 0.44Vp-p IC5502 0.2Vp-p IC5502 0.2Vp-p IC5502 0.7Vp-p IC5502 IC5502 (C-61K MODEL : 3Vp-p) IC5502 (S-61K MODEL : 4.7Vp-p) IC5502 (C-61K MODEL : 3.6Vp-p) IC5502 (S-61K MODEL : 4.2Vp-p) IC5502 (C-61K MODEL : 3.6Vp-p) IC5502 (S-61K MODEL : 4.2Vp-p)
Page 74 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 • For schematic diagrams. • Refer to page 4–79 for Printed Wiring Board. PD-92 BOARD (2/4) CAMERA REC IC5601 (C-61K : 3Vp-p) IC5601 (S-61K : 4.7Vp-p) IC5601 (C-61K : 3Vp-p) 20msec IC5601 (S-61K : 4.7Vp-p) Approx. 2.9MHz IC5601 (C-61K : 3.4Vp-p)
Page 75 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 • For schematic diagrams. • For schematic diagrams. • Refer to page 4–79 for Printed Wiring Board. • Refer to page 4–79 for Printed Wiring Board. ND801 PD-92 BOARD (4/4) CAMERA REC 2.9Vp-p 24.17 kHz IC5801 4-87 4-88...
Page 76 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 PD-93 (RGB DECODER, LCD DRIVE, BACK LIGHT, LCD (3 INCH/3.5 INCH LCD MODEL) PRINTED WIRING BOARD – Ref No. PD-93 BOARD: 10,000 series – PD-93 BOARD (SIDE B) PD-93 BOARD (SIDE A) PD-93 BOARD C4501 D4702 R4546 R4680...
Page 77 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 PD-93 BOARD (1/4) CAMERA REC 0.44Vp-p IC4502 0.2Vp-p IC4502 0.2Vp-p IC4502 0.7Vp-p IC4502 IC4502 (3.5 INCH LCD : 3Vp-p) IC4502 (3 INCH LCD : 4.7Vp-p) IC4502 (3.5 INCH LCD : 3.3Vp-p) IC4502 (3 INCH LCD : 2.2Vp-p) IC4502 (3.5 INCH LCD : 3.3Vp-p)
Page 78 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 • For schematic diagrams. • Refer to page 4–90 for Printed Wiring Board. PD-93 BOARD (2/4) CAMERA REC IC4601 (3.5 INCH LCD : 3Vp-p) IC4601 (3 INCH LCD : 4.7Vp-p) IC4601 (3.5 INCH LCD : 3Vp-p) IC4601 (3 INCH LCD : 4.7Vp-p) Approx.3.7 MHz...
Page 79 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 • For schematic diagrams. • For schematic diagrams. • Refer to page 4–90 for Printed Wiring Board. • Refer to page 4–90 for Printed Wiring Board. ND802 PD-93 BOARD (4/4) CAMERA REC 2.9Vp-p 24.48 kHz IC4801 4-99 4-100...
Page 80 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 VF-119 BOARD CAMERA REC 3Vp-p IC5401 7.2Vp-p IC5401 7.5Vp-p IC5401 7.6Vp-p IC5401 3Vp-p IC5404 3Vp-p 7.852 kHz IC5404 20 21 3Vp-p IC5404 3.4Vp-p 1.84 MHz IC5404 23 24 2.7Vp-p 11.06 MHz IC5404 3Vp-p IC5404 4-103 4-104 4-102 COLOR EVF...
Page 81 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 VF-119 (COLOR EVF (COLOR EVF MODEL) PRINTED WIRING BOARD – Ref No. VF-119 BOARD: 10,000 series – VC-119 BOARD VF-119 BOARD (SIDE B) VF-119 BOARD (SIDE A) C5401 R5410 C5402 R5411 C5403 R5412 C5404 R5414 C5405 R5414 C5406...
Page 82: Rec/Pb Head Amp, Servo/System Control, Servo
CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 VF-120 (COLOR EVF (COLOR EVF MODEL)), LB-54 (BACK LIGHT) PRINTED WIRING BOARDS – Ref No. VF-120 BOARD: 10,000 series, LB-54 BOARD: 10,000 series – VF-120 BOARD VF-120 BOARD (SIDE B) VF-120 BOARD (SIDE A) C5301 R5304 C5302 R5305...
Page 83 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 VF-120 BOARD CAMERA REC 2.4Vp-p IC5301 12Vp-p IC5301 4-109 4-110 4-111 COLOR EVF, BACK LIGHT VF-120, LB-54 (COLOR EVF MODEL)
Page 84 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 VF-99 BOARD CAMERA REC 1Vp-p IC901 2.2Vp-p IC901 4-112 4-113 4-114 B/W EVF VF-99 (B/W EVF MODEL)
Page 85: (3 Inch/3.5 Inch Lcd Model) Board
CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 VF-99 (B/W EVF (B/W EVF MODEL)) PRINTED WIRING BOARD – Ref No. VF-99 BOARD: 10,000 series – VF-99 BOARD (SIDE B) VF-99 BOARD (SIDE A) VF-99 BOARD C901 R919 C902 R920 C903 R921 C904 R922 C905...
Page 86: Power) Board
CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 DD-105 (POWER) PRINTED WIRING BOARD – Ref No. DD-105 BOARD: 2,000 series – DD-105 BOARD (SIDE B) DD-105 BOARD (SIDE A) DD-105 BOARD L801 R823 C801 C802 L802 R824 C803 L803 R825 C804 L804 R826 C805...
Page 87 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 DD-105 BOARD CAMERA REC 0.76Vp-p 507 kHz IC801 0.76Vp-p 506 kHz IC801 4-121 4-122 4-123 4-124E POWER DD-105...
Page 88: Adjustments
CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 SECTION 5 ADJUSTMENTS Refer to page 3 as Table for distinction functions of models and classification 5-1. CAMERA SECTION ADJUSTMENTS 1-1. PREPARATIONS BEFORE ADJUSTMENT (CAMERA SECTION) 1-1-1. List of Service Tools • Oscilloscope • Color monitor • Vectorscope •...
Page 89: Preparations
1-1-2. Preparations Note 1: For details of how remove the cabinet and boards, refer to “2. DISASSEMBLY”. Note 2: When performing only the adjustments, the lens block and boards need not be disassembled. 1) Connect the equipment for adjustments according to Fig. 5-1-3, 2) By setting the “Forced Camera Power ON mode”, the camera power can be turned ON even if the front panel block (MA-311/ Pattern box...
Page 90 2.5 INCH LCD MODEL Note 1 : 2.5” LCD model : CCD-TRV15/TRV15E/TRV15EP/ TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ Color monitor Vector scope TRV65/TRV65PK/TRV215/TRV615 Terminated at 75 Ω Lens block CD-197 board Regulaterd power supply CN401 (8.4 ± 0.1 Vdc) Battery terminal (Note 2) Extension cable(16P)
Page 91 3/3.5 INCH LCD MODEL Note 1 : 3” LCD model : CCD-TRV93 Color monitor Vector scope 3.5”LCD MODEL ; CCD-TRV85/TRV815 Terminated at 75 Ω Lens block CD-198 board Regulaterd power supply CN401 (8.4 ± 0.1 Vdc) Battery terminal (Note 2) Extension cable(16P) (J-6082-357-A) Adjusting...
Page 92: Setting The Switch
1-1-3.Precaution 1. Setting the Switch Unless otherwise specified, set the switches as follows and perform adjustments without loading cassette. 1. POWER switch (MA-311/312/331 board) ..... CAMERA 7. DISPLAY (Menu display) ......... V-OUT/LCD 2. NIGHT SHOT switch (Lens Block) ........ OFF 8.
Page 93: Adjusting Remote Commander
1-1-4. Adjusting Remote Commander • Changing the address The adjusting remote commander is used for changing the The address increases when the FF ()) button is pressed, calculation coefficient in signal processing, EVR data, etc. The and decreases when the REW (0) button is pressed. There adjusting remote commander performs bi-directional are altogether 256 addresses, from 00 to FF.
Page 94: Data Processing
1-1-5. Data Processing The calculation of the DDS display and the adjusting remote calculate and convert the result to hexadecimal notation, and use it commander display data (hexadecimal notation) are required for as the adjustment data. Table 5-1-2. indicates the hexadecimal obtaining the adjustment data of some adjustment items.
Page 95: Initialization Of D, E, F
When changing the data, copy the performed again. data built in the same model. Note 3: < > : NTSC model (CCD-TRV15/TRV15PK/TRV25/ Note : If copy the data built in the different model, the camcorder TRV25PK/TRV35/TRV65/TRV65PK/ may not operate.
Page 96 3. D Page Table Note1 : Fixed data-1 : Initialized data. (Refer to “1. Initializing the D,E,F Page Data”.) Fixed data-2 : Modified data. (Refer to “2. Modification of D, E, F Page Data”). Address Initial Value Remark Address Initial Value Remark NTSC PAL NTSC PAL 00 to 0F...
Page 97 Note 2: There are four models classified by CCD imager types as Flange back adj. shown below, and the initial value of adjustment is different according to the model. NTSC 510H model : CCD-TRV15/TRV15PK NTSC 760H model : CCD-TRV25/TRV25PK/TRV35/TRV65/ TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 Angular velocity sensor PAL 510H model : CCD-TRV15E/TRV15EP sensitivity adj.
Page 98 Address Initial Value Remark Address Initial Value Remark NTSC PAL NTSC PAL Fixed data-2 Switching position adj. Fixed data-1 Fixed data-2 Fixed data-1 Fixed data-2 Fixed data-1 Fixed data-2 Fixed data-1 Fixed data-2 Fixed data-2 Fixed data-1 Fixed data-1 Fixed data-2 Fixed data-1 Fixed data-2 Fixed data-1...
Page 99 5. E Page Table Address Initial Value Remark Note 1: NTSC PAL Fixed data-1 : Initialized data. Fixed data-2 ( Refer to “1. Initializing the D,E,F Page Data”.) Fixed data-2 : Modified data. (Refer to “2. Modification of D, E, F Page Data”). Fixed data-1 Note 2: See “1-7.
Page 100 Address Initial Value Remark Address Initial Value Remark NTSC PAL NTSC PAL Note 2 Note2 Fixed data (NTSC model) Fixed data-2 Color adj. (LCD) (PAL model) Fixed data-1 Fixed data-1 Fixed data-2 Fixed data-2 Fixed data-1 Fixed data-1 Fixed data-2 Fixed data-1 Fixed data-2 Fixed data-1...
Page 101: Camera System Adjustments
1-3. CAMERA SYSTEM ADJUSTMENTS Before perform the camera system adjustments, Check that the specified value of “28MHz Origin Oscillation Adjustment”, “Y OUT level Adjustment” and “C OUT level Adjustment” of “VIDEO SYSTEM ADJUSTMENT” are satisfied. 1. G-CAM flip Adjustment Set the color reproduction conditions to optimum. Subject Color bar chart standard picture frame Measurement Point...
Page 102: Hall Adjustment
2. HALL Adjustment For detecting the position of the lens iris, adjust the hall AMP gain and offset. Subject Not required Measurement Point DDS display data of LCD or TV monitor (Note 3) Measuring Instrument Adjustment Page Adjustment Address 2F, 30 Specified Value 90 to 94 during IRIS OPEN (Note 1) 19 to 1D during IRIS CLOSE (Note 2)
Page 103: Flange Back Adjustment
3. Flange Back Adjustment 3-2. Flange Back Adjustment (2) The inner focus lens flange back adjustment is carried out Perform this adjustment after performing “Flange Back Adjustment automatically. In whichever case, the focus will be deviated during (1)”. auto focusing/manual focusing. Subject Subject more than 500m away 3-1.
Page 104: Flange Back Check
4. Flange Back Check 5. Picture Frame Setting Subject Siemens star Subject Color bar chart standard picture frame (2.0 m from the front of the lens) (1.5m from the front of the lens) (Luminance: approx. 200 lux) Measurement Point Video output terminal Measurement Point Check operation on TV monitor Measuring Instrument...
Page 105: Color Reproduction Adjustment
34, 36, F5, F6 Specified Value All color luminance points should settle within each color reproduction frame. Note1: NTSC 510H model (CCD-TRV15/ TRV15PK) NTSC 760H model (CCD-TRV25/ TRV25PK/ TRV35/ TRV65/ TRV65PK/ TRV85/ TRV93/ TRV215/ TRV615/ TRV815) PAL 510H model (CCD-TRV15E/ TRV15EP)
Page 106: Iris In/Out Adjustment
00 00 XX 00 XX XX n Object data n Lower two digits Note 2: NTSC 510H model (CCD-TRV15/TRV15PK) n Upper two digits NTSC760H model (CCD-TRV25/TRV25PK/TRV35/ Switch setting: T RV 6 5 / T RV 6 5 P K / T RV 8 5 / T RV 9 3 / 1) STEADY SHOT (Menu display) ........
Page 107: Auto White Balance Standard Data Input
9. Auto White Balance Standard Data Input 10. White Balance Adjustment Adjust to the proper auto white balance output data. Subject Clear chart If it is not correct, auto white balance and color reproducibility will (Color bar standard picture frame) be poor.
Page 108: White Balance Check
11. White Balance Check Subject Clear chart (Color bar standard picture frame) Filter Filter C14 for color temperature correction ND filter 1.0 and 0.3 2 mm Measurement Point video output terminal Measuring Instrument Vectorscope Specified Value Fig. 5-1-11. A to C Switch setting: 1) NIGHT SHOT switch ............
Page 109: Angular Velocity Sensor Sensitivity Adjustment
S 4) Calculate D ' and D ' using the following equation (decimal calculation). NTSC model(CCD-TRV15/ TRV15PK/ TRV25/ TRV25PK/ TRV215/TRV35/ TRV65/ TRV65PK/ TRV85/ TRV93/ TRV615/ TRV815) ' = 85 / S ' = 90 / S...
Page 110: Color Electronic Viewfinder System Adjustments (Ccd-Trv93)
1-4. COLOR ELECTRONIC VIEWFINDER SYSTEM 1. EVF Initial Data Input ADJUSTMENT Mode VTR stop (CCD-TRV93) Signal No signal Note 1: The back light (fluorescent tube) is driven by a high voltage Adjustment Page AC power supply. Therefore, do not touch the back light Adjusting Address C2 to CD holder to avoid electrical shock.
Page 111: Vco Adjustment (Vf-119 Board)
2. VCO Adjustment (VF-119 board) 3. Bright Adjustment (VF-119 board) Set the VCO free-run frequency. If deviated, the EVF screen will be Set the level of the VIDEO signal for driving the LCD to the specified blurred. value. If deviated, the screen image will be blackish or saturated (whitish).
Page 112: Contrast Adjustment (Vf-119 Board)
4. Contrast Adjustment (VF-119 board) 5. Backlight Consumption Current Adjustment (VF-120 board) Set the level of the VIDEO signal for driving the LCD to the specified value. If deviated, the screen image will be blackish or saturated Set the backlight luminance and color temperature. (whitish).
Page 113: Monochrome Electronic Viewfinder System Adjustments
1-5. MONOCHROME ELECTRONIC VIEWFINDER SYSTEM ADJUSTMENTS (CCD-TRV15/ TRV15PK/ TRV15E/ TRV15EP/ TRV25/ TRV25PK/ TRV35/ TRV35E/ TRV65/ TRV65PK/ TRV85/ TRV215/ TRV615/ TRV815) Note: NTSC model: CCD-TRV15/ TRV15PK/ TRV25/ TRV25PK/ TRV35/ TRV65/ TRV65PK/ TRV85/ TRV93/ TRV215/ TRV615/ TRV815 PAL model : CCD-TRV15E/ TRV15EP/ TRV35E 1-5-1.
Page 114: Aberration Adjustment
1-5-4. Aberration Adjustment 1-5-5. Horizontal Amplitude Adjustment (VF-99 board) Mode VTR stop Signal Dot pattern Mode Playback Specified Value b1 2 • a1 Signal Alighment tape : b2 0.8 • a2 For checking operations (WR5-5NSP (NTSC)) Adjusting method: (WR5-5CSP (PAL)) 1) Adjust the aberration adjustment ring so that the tracing of the Monoscope section dot satisfies the specified value.
Page 115: Vertical Amplitude Adjustment (Vf-99 Board)
1-5-6. Vertical Amplitude Adjustment (VF-99 board) 1-5-7. Brightness Adjustments (VF-99 board) Mode Playback Mode Playback Signal Alighment tape : Signal Alighment tape : For checking operations For checking operations (WR5-5NSP (NTSC)) (WR5-5NSP (NTSC)) (WR5-5CSP (PAL)) (WR5-5CSP (PAL)) Monoscope section Monoscope section Adjusting Element RV903 Specified Value...
Page 116: Lcd System Adjustment
TRV65PK/ TRV615 Fixed value 8.2kΩ 2.5" TYPE S PAL CCD-TRV35E Fixed value 1.5kΩ 2.5" TYPE C NTSC CCD-TRV15/ TRV15PK/ < > : NTSC model only TRV25/ TRV25PK/TRV215 ] : PAL model only 3.9kΩ 2.5" TYPE C PAL CCD-TRV15E/ TRV15EP Note1: B0: NTSC model...
Page 117: Vco Adjustment (Pd-92/93 Board)
Note2 : LCD TYPE S model : CCD-TRV35/ TRV35E/ TRV65/ LCD TYPE C model :CCD-TRV15/ TRV15PK/ TRV15E/ TRV65PK/ TRV93/ TRV615 TRV15EP/ TRV25/ TRV25PK/ LCD TYPE C model : CCD-TRV15/ TRV15PK/ TRV15E/ TRV85/ TRV215/ TRV815 TRV15EP/ TRV25/ TRV25PK/ TRV85/ TRV215/ TRV815 Adjusting method: 1) Select page: 0, address: 01, and set data: 01.
Page 118: Bright Adjustment (Pd-92/93 Board)
Note1 : LCD TYPE S model : CCD-TRV35/ TRV35E/ TRV65/ Note1 : LCD TYPE S model : CCD-TRV35/ TRV35E/ TRV65/ TRV65PK/ TRV93/ TRV615 TRV65PK/ TRV93/ TRV615 LCD TYPE C model : CCD-TRV15/ TRV15PK/ TRV15E/ LCD TYPE C model : CCD-TRV15/ TRV15PK/ TRV15E/ TRV15EP/ TRV25/ TRV25PK/ TRV15EP/ TRV25/ TRV25PK/...
Page 119: V-Com Level Adjustment (Pd-92/93 Board)
Note2 : LCD TYPE S model : CCD-TRV35/ TRV35E/ TRV65/ 3" LCD TYPE S model : TRV65PK/ TRV93/ TRV615 A = 0.05 ± 0.05V (NTSC) LCD TYPE C model : CCD-TRV15/ TRV15PK/ TRV15E/ 3.5" LCD TYPE C model : TRV15EP/ TRV25/ TRV25PK/ A = 0.07 ± 0.05V (NTSC) TRV85/ TRV215/ TRV815 Note1: 2.5"...
Page 120: V-Com Adjustment (Pd-92/93 Board)
Note2 : LCD TYPE S model : CCD-TRV35/ TRV35E/ TRV65/ TRV65PK/ TRV93/ TRV615 Adjusting method: LCD TYPE C model : CCD-TRV15/ TRV15E/ TRV15EP/ 1) Select page: 0, address: 01, and set data: 01. TRV15PK/ TRV25/ TRV25PK/ 2) Select page: 3, address: 01, set data: 51, and press the PAUSE TRV85/ TRV215/ TRV815 button of the adjusting remote commander.
Page 121: Mechanical Section Adjustment
7) Playback the alignment tape for tracking. and replacements of mechanism parts, refer to the separate volume- “8 mm Video Mechanism Adjustment Manual VII B Mechanism ”. WR5-1NP: For NTSC model: CCD-TRV15/ TRV15PK/ TRV25/ TRV25PK/ TRV35/ TRV65/ TRV65PK/ TRV85/ 2-1.
Page 122: Video Section Adjustments
5-3. VIDEO SECTION ADJUSTMENTS When performing adjustments, refer to the layout diagrams for adjustment related parts beginning from page 5-62. 3-1. PREPARATIONS BEFORE ADJUSTMENT The following adjusting instruments are used for adjusting the video section. 3-1-1. Equipments to be Used 1) TV monitor [For PAL model] 2) Oscilloscope: 2 phenomena, band 30 MHz or wider, with delay...
Page 123: Precautions On Adjusting
3-1-2. Precautions on Adjusting 3-1-3. Adjusting Connectors 1) The adjustments of this unit are performed in the VTR mode or Some of the adjusting points of the video section are concentrated camera mode. at VC-195 board CN910. Connect the measuring instruments via To set to the VTR mode, set the power switch to “VTR”...
Page 124: Connecting The Equipments
3-1-4. Connecting the Equipments Connect the measuring instruments as shown in Fig. 5-3-2 and perform the adjustments. Connecting the TV Monitor and Regulated Power Supply Battery terminal Main Unit TV monitor Regulated power supply 8.4 ± 0.1Vdc VIDEO Connect when using the camera mode or playing back.
Page 125 Note: Measure using the VIDEO terminal (Terminated at 75 Ω). Fig. 5-3-3. shows the 75% color bar signals recorded on the alignment tape. Fig. 5-3-3. Color Bar Signals of the Alignment Tape 5-38...
Page 126: Input/Output Level And Impedance
3-1-6. Input/Output Level and Impedance 3-1-8. Service Mode Video input/output Additional note on adjustment Phono jack, 1 Vp-p, 75Ω, Note: After the completion of the all adjustments, cancell the unbalanced, sync negative service mode by either of the following ways. S video input/output (Hi8 model) 4-pin mini DIN 1) Unplug the main power supply and remove the lithium battery.
Page 127: Emergency Memory Address
2. Emergency Memory Address 2-1. EMG CODE (Emergency Code) The codes shown in the following table which correspond to errors Page F Address 10 to 1B that occur are recorded in addresses 10, 14, and 18. Address Contents Code Type of Emergency 1st EMG code No error Upper: MSW code when the mechanism starts shifting...
Page 128: Msw Codes
2-2. MSW Codes • The lower parts of the data of addresses 12, 16 and 1A represent the MSW codes (mode switch, mechanism position) when errors occurs. • The upper parts of the data of addresses 12, 16 and 1A represent, when the mechanism position is to be moved, the MSW codes at the start of movement (when moving the loading motor).
Page 129: Bit Value Discrimination
3. Bit value discrimination 4. Switch check (1) Bit values must be discriminated using the display data of the Page 3 Address 43 adjusting remote commander for the following items. Use the table below to discriminate if the bit value is “1” or “0”. Function When bit value=1 When bit value=0 0 VTR MODE SW...
Page 130: Switch Check (2)
5. Switch check (2) Page 3 Address 60 to 66 Using method: 1) Select page: 3, address: 60 to66. 2) By discriminating the display data, the pressed key can be discriminated. Data Address 00 to 0D 0E to 29 2A to 46 47 to 68 69 to 90 91 to BE...
Page 131: Led, Lcd (Display Window) Check
8. LED, LCD (display window) check 9. Record of Use Check Page 3 Address 05 Bit5 Page 3 Address A2 to AA Address Using method: Function Remarks 1) Select page: 3, address: 05, and set the bit value of Bit5 to “1”. 1000th place digit and 2) Check that all LED are lit and all segments of LCD (display 100th place digit of...
Page 132: System Control System Adjustment
3-2. SYSTEM CONTROL SYSTEM ADJUSTMENT 12) Select page: 0, address: 01, and set data: 00. 1. Initialization of D, E, F Page Data If the D, E, F page data is erased due to some reason, perform “1-2. INITIALIZATION OF D, E, F PAGE DATA”, of “5-1. CAMERA SECTION ADJUSTMENT”.
Page 133: Servo System Adjustments
= 0±10µsec Adjusting method: 1) Select page: 0, address: 01, and set data: 01. Note 1: NTSC MODEL: CCD-TRV15/ TRV15PK/ TRV25/ 2) Select page: 2, address: 01, and set data: 81, and press the PAUSE TRV25PK/ TRV35/ TRV65/ button of the adjustment remote commander. (to start up automatic CAP FG offset adjustment.)
Page 134: Ntsc Lp Mode Switching Position Adjustment (Vc-195 Board) (Ccd-Trv65/Trv65Pk/ Trv85/Trv93/Trv615/Trv815)
7) Select page: 0, address: 01, and set data: 00. f=4433618.75±17Hz (PAL) Pin !™ of IC501 : f=14318181±68Hz (NTSC) f=14187500±55Hz (PAL) Note 1: NTSC MODEL: CCD-TRV15/ TRV15PK/ TRV25/ TRV25PK/ TRV35/ TRV65/ TRV65PK/ TRV85/ TRV93/ TRV215/ TRV615/ TRV815 PAL MODEL: CCD-TRV15E/ TRV15EP/ TRV35E Adjusting method: 1) Select page: 0, address: 01, and set data: 01.
Page 135: Afc F0 Adjustment (Vc-195 Board)
2. AFC f0 Adjustment (VC-195 board) 3. Filter f0 Adjustment (VC-195 board) Adjust the pull-in range of the A/D converted clock generator during Minimize the chroma signal residual components during composite playback. video signal input. Mode VTR stop Mode VTR stop Signal No signal Signal...
Page 136: Y Out Level Adjustment (Vc-195 Board)
4. Y OUT Level Adjustment (VC-195 board) 5. C OUT Level Adjustment (VC-195 board) Set the Y signal output level. Set the chroma signal output level. Mode VTR stop Mode VTR stop Signal No signal Signal No signal Measurement Point Hi8 model : Measurement Point Hi8 model :...
Page 137: Rp Filter F0 Adjustment (Vc-195 Board)
6. RP Filter f0 Adjustment (VC-195 board) 7. Hi8 REC Y Current Adjustment (VC-195 board) (CCD-TRV85/ TRV93/ TRV615/ TRV815) Adjust the LPF of the playback RF amplifier. Adjust the Y FM signal recording current. Mode VTR stop Signal No signal Mode VTR recording (SP mode) Pin 9 of CN910 (RF AGC OUT)
Page 138 PAUSE button of the adjusting remote commander. 12) Select page: F, address: 65, set the data noted down at step 4), Note 1: NTSC MODEL: CCD-TRV15/ TRV15PK/ TRV25/ press the PAUSE button of the adjusting remote commander. TRV25PK/ TRV35/ TRV215...
Page 139: Hi8 Rec L Level Adjustment (Vc-195 Board) (Ccd-Trv65/Trv65Pk/ Trv85/Trv93/Trv615/Trv815)
9) Write the following data in page: F, address: 63 to 64. 9. Hi8 REC L Level Adjustment (VC-195 board) (CCD-TRV65/TRV65PK/TRV85/ TRV93/ TRV615/ TRV815) Address Data Set the recording levels of the REC AFM signal and REC ATF signal. If the level is too low, the audio S/N will deteriorated, tracking will not be stable, or SP/LP will not be discriminated properly.
Page 140: Standerd8 Rec L Level Adjustment
3) of “Preparations only for the model without REC switch”. 3) Press the PAUSE button of the adjusting remote commander. Note 1: NTSC MODEL: CCD-TRV15/ TRV15PK/ TRV25/ 4) Select page: D, address: 15, and set the data memorized at step TRV25PK/ TRV35/ TRV215 4) of “Preparations only for the model without REC switch”.
Page 141: Rec C Current Adjustment (Vc-195 Board)
Standard8 model : A = 30.9±1.1mV (NTSC) A = 30.0±1.1mV (PAL) Note 1: NTSC HI8 model: CCD-TRV65/ TRV65PK/ TRV85/ TRV93/ TRV615/ TRV815 1.35 µ sec NTSC Standard8 model: CCD-TRV15/ TRV15PK/ TRV25/ TRV25PK/ TRV35/ TRV215 Fig. 5-3-17. PAL Standard8 model: CCD-TRV15E/ TRV15EP/ TRV35E Connection: 1) Remove C085 (0.01µF, Pin !§...
Page 142: Ir Transmitter Adjustments (Ccd-Trv35/Trv65/Trv65Pk/Trv85/ Trv93/Trv615/Trv815)
3-5. IR TRANSMITTER ADJUSTMENTS 2. IR Video Deviation Adjustment (VC-195 board) (CCD-TRV35/ TRV65/ TRV65PK/ TRV85/ TRV93/ Mode Camera standby TRV615/ TRV815) Subject Arbitrary Measurement Point VIDEO OUT terminal of IR receiver jig Adjust using a IR receiver jig (J-6082-383-A). (Terminated at 75Ω) Measuring Instrument Oscilloscope Switch setting:...
Page 143: Ir Audio Deviation Adjustment (Vc-195 Board)
3. IR Audio Deviation Adjustment (VC-195 board) Adjusting method: 1) Select page: 0, address: 01, and set data: 01. Mode VTR recording 2) Connect the audio level meter to the AUDIO L terminal of the Signal Audio signal : IR receiver jig. 400Hz, –7.5dBs : L or R of AUDIO 3) Select page: F, address: 67, change the data and set the 400Hz terminal...
Page 144: Stereo Audio System Adjustment
3-6. STEREO AUDIO SYSTEM ADJUSTMENT [Connecting the measuring instruments for the audio] (CCD-TRV65/ TRV65PK/ TRV85/ TRV93/ TRV615/ Connect the audio system measuring instruments in addition to the TRV815) video system measuring instruments as shown in Fig. 5-3-22, and perform adjustments at the power switch [VTR] or [PLAYER] •...
Page 145: Mhz Deviation Adjustment (Vc-195 Board)
1. 1.5 MHz Deviation Adjustment (VC-195 board) 2. 1.7 MHz Deviation Adjustment (VC-195 board) Sets the spectrum of the L-ch ((L+R)/2 signal) level modulated Sets the spectrum of the R-ch ((L-R)/2 signal) level modulated during during recording. If deviated, the crosstalk signal of the audio signal recording.
Page 146: Bpf F0 Adjustment (Vc-195 Board)
Sets the BPF passing frequency so that the AFM signal can separate from the playback RF signal properly. If deviated. the mono/stereo (CCD-TRV15/ TRV15E/ TRV15EP/ TRV15PK/ TRV25/ mode will be differentiated incorrectly, and noises and distortions TRV25PK/ TRV35/ TRV35E/ TRV215) will increase during high volume playback.
Page 147: Mhz Deviation Adjustment (Vc-195 Board)
Specified Value The distortion rate should be and Specified Value –7.5±0.5dBs minimum. Note 1: NTSC model: CCD-TRV15/ TRV15PK/ TRV25/ Adjusting method : TRV25PK/ TRV35/ TRV215 1) Select page: 0, address: 01, and set data: 01. PAL model: CCD-TRV15E/ TRV15EP/ TRV35E 2) Select page: F, address: 47, change the data and minimize the distortion rate.
Page 148: Arrangement Diagram For Adjustment Parts
3-8. ARRANGEMENT DIAGRAM FOR ADJUSTMENT PARTS VC-195 BOARD (SIDE A) CN909 CN551 CN501 IC604 IC202 CN911 C085 IC001 IC301 VC-195 BOARD (SIDE B) IC501 CN910 IC751 5-62E...
Page 149: Repair Parts List
CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 SECTION 6 REPAIR PARTS LIST 6-1. EXPLODED VIEWS NOTE: The components identified by • Abbreviation • Items marked “*” are not stocked since they are mark ! or dotted line with mark Canadian model is abbreviated as CND.
Page 150: Front Panel Block Assembly (Trv93)
6-1-2. FRONT PANEL BLOCK ASSEMBLY (TRV93) not supplied not supplied not supplied not supplied MIC901 MIC902 LAMP,HALOEEN XB-3D(DC6V/3W) VL001 Les composants identifiés par une The components identified by marque ! sont critiques pour la mark ! or dotted line with mark ! are critical for safety.
Page 151: Front Panel Block Assembly (Except Trv93)
6-1-3. FRONT PANEL BLOCK ASSEMBLY (EXCEPT TRV93) not supplied not supplied not supplied not supplied MIC901 MIC902 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark X-3948-170-1 GRILLE (870) ASSY, MICROPHONE 3-987-633-01 BUTTON, LOCK X-3948-194-1 PANEL (870) ASSY, FRONT 3-987-631-01 KNOB, P (TRV15/TRV15PK/TRV15E/TRV15EP) 3-987-642-01 SPRING, CLICK...
Page 152: Cabinet (R) Block Assembly (Trv85/Trv815/Trv93)
6-1-4. CABINET (R) BLOCK ASSEMBLY (TRV85/TRV815/TRV93) supplied SP901 supplied not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-948-339-61 TAPPING 3-987-739-01 SPRING, LINK PLATE 3-965-367-01 SPACER, SP 3-987-744-01 KNOB, IR 3-987-769-01 PLATE, HINGE GROUND 3-987-764-01 COVER, IR 1-475-621-11 SWITCH BLOCK, CONTROL(MR-8500) 1-783-240-11 CABLE, FLEXIBLE FLAT (FFC-236)
Page 153: Cabinet (R) Block Assembly (Except Trv85/Trv815/Trv93)
6-1-5. CABINET (R) BLOCK ASSEMBLY (EXCEPT TRV85/TRV815/TRV93) supplied not supplied not supplied SP901 not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-948-339-61 TAPPING 3-987-744-01 KNOB, IR 3-965-367-01 SPACER, SP (TRV35/TRV65/TRV65PK/TRV615/TRV35E) 3-987-742-01 PLATE(878), GROUND 3-987-730-01 COVER, IR(TRV65/TRV65PK) 1-475-620-11 SWITCH BLOCK, CONTROL(MF-8500) 3-987-730-11 COVER, IR * 205...
Page 154: Lcd Block Assembly(3/3.5Inch) (Trv85/Trv815/Trv93)
6-1-6. LCD BLOCK ASSEMBLY(3/3.5INCH) (TRV85/TRV815/TRV93) not supplied ND801 not supplied not supplied LCD901 not supplied not supplied ND802 not supplied Les composants identifiés par une The components identified by marque ! sont critiques pour la mark ! or dotted line with mark ! are critical for safety.
Page 155: Lcd Block Assembly (2.5Inch)(Except Trv85/Trv815/Trv93)
6-1-7. LCD BLOCK ASSEMBLY (2.5INCH)(EXCEPT TRV85/TRV815/TRV93) ND801 LCD901 ND802 not supplied Les composants identifiés par une The components identified by mark ! or dotted line with mark marque ! sont critiques pour la ! are critical for safety. sécurité. Replace only with part number Ne les remplacer que par une specified.
Page 156: Evf Block Assembly (Color Evf) (Trv93)
6-1-8. EVF BLOCK ASSEMBLY (COLOR EVF) (TRV93) not supplied LCD902 not supplied ND5351 Les composants identifiés par une The components identified by marque ! sont critiques pour la mark ! or dotted line with mark ! are critical for safety. sécurité.
Page 157: Evf Block Assembly (B/W Evf) (Except Trv93)
6-1-9. EVF BLOCK ASSEMBLY (B/W EVF) (EXCEPT TRV93) not supplied not supplied V901 Les composants identifiés par une The components identified by marque ! sont critiques pour la mark ! or dotted line with mark ! are critical for safety. sécurité.
Page 158: Main Boards Assembly
6-1-10. MAIN BOARDS ASSEMBLY SE452 EXCEPT CCD-TRV85/ TRV815/TRV93 SE451 CCD-TRV85/TRV815/ TRV93 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-774-867-31 CONNECTOR,EXTERNAL(HOT SHOE)8P A-7073-404-A SE-66(V) BOARD, COMPLETE (TRV65/TRV65PK/TRV85/TRV615/TRV815) (TRV15/TRV15PK/TRV15E/TRV15EP) A-7073-409-A SE-66(VH) BOARD, COMPLETE X-3946-197-1 SHOE ASSY(TRV35/TRV35E) (TRV65/TRV65PK/TRV615) 1-668-978-11 FP-633 FLEXIBLE BOARD A-7073-434-A SE-67(VH) BOARD, COMPLETE (TRV65/TRV65PK/TRV85/TRV615/TRV815)
Page 159: Battery Panel And Ccd Block Assembly
6-1-11. BATTERY PANEL AND CCD BLOCK ASSEMBLY IC401 not supplied supplied not supplied not supplied Be sure to read “Note on the CCD Imager replacement” on page 4–9 when changing the CCD imager. Ref. No. Part No. Description Remark Ref. No. Part No.
Page 160: Device Lens (Lsv-600A/Lsv-601A)
6-1-12. DEVICE LENS (LSV-600A/LSV-601A) NIGHT SHOT Model CCD-TRV35/TRV35E/TRV65 /TRV65PK/TRV85/TRV815 /TRV93 M906 M905 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 8-848-722-01 DEVICE, LENS LSV-600A(SOC)(NIGHT SHOT) 2-327-405-01 WASHER (TRV35/TRV65/TRV65PK/TRV615/TRV85/TRV815/TRV93/TRV35E) 3-623-756-21 SCREW (B1.7x5), P 8-848-724-01 DEVICE, LENS LSV-601A(SOC) 3-979-037-11 SPRING, RETURN (TRV15/TRV15PK/TRV15E/TRV15EP/TRV25/TRV25PK/TRV215) M905...
Page 161: Cassette Compartment Assembly
6-1-13. CASSETTE COMPARTMENT ASSEMBLY LS CHASSIS BLOCK SECTION (See page 6-14) MECHANISM CHASSIS BLOCK SECTION (See page 6-15) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-7040-421-A DAMPER ASSY X-3945-399-1 GEAR ASSY, GOOSENECK 7-624-102-04 STOP RING 1.5, TYPE -E 3-947-503-01 SCREW (M1.4X2.5) X-3945-400-X CASSETTE COMPARTMENT ASSY 3-331-007-21 WASHER...
Page 162: Ls Chassis Assembly
6-1-14. LS CHASSIS ASSEMBLY S002 S001 D001 FP-249 (not supplied) Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-7040-419-A BASE (S) BLOCK ASSY, GUIDE 3-965-563-01 GEAR, T SOFT A-7040-418-B BASE (T) BLOCK ASSY, GUIDE 3-965-559-01 STOPPER (T) 3-965-565-01 CLAW, T SOFT 3-965-557-01 STOPPER (T), GB X-3945-397-1 DECK ASSY, REEL, S...
Page 163: Mechanism Chassis Assembly
6-1-15. MECHANISM CHASSIS ASSEMBLY M901 M903 M902 S901 not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark X-3947-343-1 GROUND (IM) ASSY, SHAFT 3-965-542-01 SHIELD, MOTOR 3-965-550-02 SCREW (M1.7X1.6) 3-965-539-01 GEAR (A) 1-657-785-11 FP-248 FLEXIBLE BOARD 3-965-538-01 SLEEVE, MOTOR HOLDER 3-965-545-01 SPACER, CAPSTAN 3-965-549-01 SCREW (M1.4 X 6.5)
Page 164: Electrical Parts List
CD-197/198 CF-50/51 6-2. ELECTRICAL PARTS LIST Note: • CAPACITORS • Due to standardization, replacements in the parts list The components identified by uF : µ F may be different from the parts specified in the mark ! or dotted line with mark diagrams or the components used on the set.
Page 165 CF-50/51 DD-105 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < TRANSISTOR > A-7073-408-A DD-105(VMMIF) BOARD, COMPLETE ***************************** Q001 8-729-402-42 TRANSISTOR UN5213-TX (EXCEPT TRV93) (TRV65/TRV65PK/TRV85/TRV615/TRV815) Q003 8-729-230-63 TRANSISTOR 2SD1819A-QRS-TX (EXCEPT TRV15/TRV15PK/TRV15E/TRV15EP/TRV25/TRV25PK/TRV215) A-7073-416-A DD-105(VMMI) BOARD, COMPLETE Q005 8-729-230-72 TRANSISTOR 2SA1362-YG-EL **************************** (EXCEPT TRV15/TRV15PK/TRV15E/TRV15EP/TRV25/TRV25PK/TRV215)
Page 166 DD-105 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C847 1-164-506-11 CERAMIC CHIP 4.7uF D818 8-719-027-76 DIODE 1SS357-TPH3 C848 1-164-506-11 CERAMIC CHIP 4.7uF D819 8-719-027-76 DIODE 1SS357-TPH3 C849 1-135-157-21 TANTALUM CHIP 10uF 6.3V (TRV65/TRV65PK/TRV85/TRV615/TRV815) C850 1-135-157-21 TANTALUM CHIP 10uF 6.3V D932 8-719-045-87 DIODE MA4Z082WA-(K8).SO...
Page 167 DD-105 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark ! PS803 1-533-761-21 LINK, IC (SMD) 1.4A Q848 8-729-037-52 TRANSISTOR 2SD2216J-QR(K8).SO (TRV15:E,HK,BR/TRV15PK/TRV25PK/TRV35/TRV15E/TRV15EP/TRV35E) Q849 8-729-037-53 TRANSISTOR 2SB1462J-QR(K8).SO ! PS804 1-533-760-21 FUSE (SMD) 1.4A Q850 8-729-037-52 TRANSISTOR 2SD2216J-QR(K8).SO (EXCEPT TRV15:E,HK,BR/TRV15PK/TRV25PK/TRV35/TRV15E/TRV15EP/ Q851 8-729-041-69 TRANSISTOR MMSF5P02HDR2 TRV35E)
Page 168 FP-355 FP-356 DD-105 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R850 1-216-857-11 METAL CHIP 1/16W R914 1-216-811-11 METAL CHIP 1/16W R915 1-216-853-11 METAL CHIP 470K 1/16W R852 1-216-823-11 METAL CHIP 1.5K 1/16W R916 1-216-864-11 METAL CHIP 1/16W R853 1-216-849-11 METAL CHIP...
Page 169 LB-54 MA-311/312/331 FP-433 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark FP-433 FLEXIBLE BOARD A-7073-445-A MA-311(VMMI) BOARD, COMPLETE (TRV35) ********************* ***************************** (Ref.No. 10,000 Series) (Ref.No. 3,000 Series) < CAPACITOR > A-7073-430-A MA-312(VHI) BOARD, COMPLETE *************************** C9001 1-164-004-11 CERAMIC CHIP 0.1uF (TRV85/TRV815)
Page 170 0.1uF (TRV35/TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) (TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) D302 8-749-060-65 DIODE DCC3810 C350 1-135-259-11 TANTAL. CHIP 10uF 6.3V (EXCEPT TRV15/TRV15PK/TRV15E/TRV15EP/TRV25/TRV25PK/TRV215) (TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) D303 8-719-061-82 DIODE TLSU1002(TPX1,SONY) D305 8-719-404-49 DIODE MA111-TX C351 1-164-227-11 CERAMIC CHIP 0.022uF D309 8-719-067-44 DIODE CL-310IRS-X-T (TRV35E) (TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) C352 1-162-964-11 CERAMIC CHIP 0.001uF...
Page 171 MA-311/312/331 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark Q302 8-729-122-63 TRANSISTOR 2SA1226-T1E4 R335 1-216-839-11 METAL CHIP 1/16W (TRV35/TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) (TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) Q303 8-729-140-75 TRANSISTOR 2SD999-T1-CLCK R336 1-216-836-11 METAL CHIP 1/16W (EXCEPT TRV15/TRV15PK/TRV15E/TRV15EP/TRV25/TRV25PK/TRV215) (TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) Q304 8-729-402-42 TRANSISTOR UN5213-TX R337 1-216-835-11 METAL CHIP 1/16W...
Page 172 MA-311/312/331 PD-92 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R367 1-216-818-11 METAL CHIP 1/16W C5603 1-164-004-11 CERAMIC CHIP 0.1uF (TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) (TRV35/TRV35E/TRV65/TRV65PK/TRV615) R368 1-216-864-11 METAL CHIP 1/16W C5604 1-107-826-11 CERAMIC CHIP 0.1uF (TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) C5605 1-107-826-11 CERAMIC CHIP 0.1uF C5607 1-164-004-11 CERAMIC CHIP...
Page 173 PD-92 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark IC5602 8-759-327-01 IC NJM062V(TE2) R5605 1-216-864-11 METAL CHIP 1/16W IC5701 8-759-075-70 IC TA75S393F-TE85R (TRV15/TRV15PK/TRV15E/TRV15EP/TRV25/TRV25PK/TRV215) IC5801 8-759-494-53 IC BU9729K-E2 R5607 1-216-864-11 METAL CHIP 1/16W (TRV35/TRV35E/TRV65/TRV65PK/TRV615) < COIL > R5608 1-216-864-11 METAL CHIP 1/16W...
Page 174 PD-93 PD-92 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R5653 1-218-883-11 RES,CHIP 0.50% 1/16W R5693 1-216-853-11 METAL CHIP 470K 1/16W (TRV35/TRV35E/TRV65/TRV65PK/TRV615) (TRV15/TRV15PK/TRV15E/TRV15EP/TRV25/TRV25PK/TRV215) R5654 1-218-879-11 RES,CHIP 0.50% 1/16W R5694 1-216-839-11 METAL CHIP 1/16W (TRV35/TRV35E/TRV65/TRV65PK/TRV615) R5695 1-216-833-11 METAL CHIP 1/16W R5696 1-216-864-11 METAL CHIP...
Page 175 PD-93 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C4512 1-104-851-11 TANTAL. CHIP 10uF < DIODE > C4513 1-107-826-11 CERAMIC CHIP 0.1uF C4514 1-164-004-11 CERAMIC CHIP 0.1uF D4603 8-713-102-80 DIODE 1T369-01-T8A C4515 1-164-004-11 CERAMIC CHIP 0.1uF D4604 8-719-976-96 DIODE MA8047-H-TX C4516...
Page 176 PD-93 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R4534 1-216-805-11 METAL CHIP 1/16W R4645 1-216-844-11 METAL CHIP 1/16W R4535 1-216-805-11 METAL CHIP 1/16W (TRV93) R4536 1-216-805-11 METAL CHIP 1/16W R4646 1-216-844-11 METAL CHIP 1/16W R4537 1-216-821-11 METAL CHIP 1/16W (TRV93)
Page 177 PD-93 PJ-83/84 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R4682 1-216-864-11 METAL CHIP 1/16W A-7073-405-A PJ-83(M) BOARD, COMPLETE (TRV85/TRV815) ************************ (EXCEPT TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) R4683 1-216-864-11 METAL CHIP 1/16W (TRV85/TRV815) A-7073-410-A PJ-83(H) BOARD, COMPLETE R4684 1-216-864-11 METAL CHIP 1/16W ************************ (TRV85/TRV815)
Page 178 VC-195 PJ-83/84 SE-66/67 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R107 1-216-864-11 METAL CHIP 1/16W < IC > (TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) R108 1-216-821-11 METAL CHIP 1/16W IC451 8-759-489-19 IC uPC6756GR-8JG-E2 (TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) (EXCEPT TRV15/TRV15PK/TRV15E/TRV15EP) R109 1-216-821-11 METAL CHIP 1/16W <...
Page 179 VC-195 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-7093-455-A VC-195(VMM0P) BOARD, COMPLETE (TRV35E) C048 1-162-970-11 CERAMIC CHIP 0.01uF C049 1-162-970-11 CERAMIC CHIP 0.01uF ***************************** C050 1-162-970-11 CERAMIC CHIP 0.01uF A-7093-456-A VC-195(VZ0P) BOARD, COMPLETE C052 1-162-970-11 CERAMIC CHIP 0.01uF C053 1-162-970-11 CERAMIC CHIP...
Page 180 VC-195 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C162 1-135-180-21 TANTALUM CHIP 3.3uF 6.3V C232 1-164-156-11 CERAMIC CHIP 0.1uF (TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) C233 1-135-201-11 TANTALUM CHIP 10uF C163 1-135-180-21 TANTALUM CHIP 3.3uF 6.3V C234 1-162-970-11 CERAMIC CHIP 0.01uF C164 1-162-970-11 CERAMIC CHIP...
Page 181 VC-195 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C344 1-162-970-11 CERAMIC CHIP 0.01uF C483 1-164-156-11 CERAMIC CHIP 0.1uF (TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) C484 1-164-156-11 CERAMIC CHIP 0.1uF C346 1-162-970-11 CERAMIC CHIP 0.01uF C485 1-164-505-11 CERAMIC CHIP 2.2uF C347 1-162-970-11 CERAMIC CHIP 0.01uF C349...
Page 182 VC-195 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C570 1-162-970-11 CERAMIC CHIP 0.01uF C767 1-107-826-11 CERAMIC CHIP 0.1uF C571 1-104-851-11 TANTAL. CHIP 10uF (TRV35/TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) C768 1-162-909-11 CERAMIC CHIP 0.25PF 50V C572 1-104-851-11 TANTAL. CHIP 10uF (TRV35/TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) C605 1-135-091-00 TANTALUM CHIP 1uF...
Page 183 VC-195 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark D551 8-719-404-49 DIODE MA111-TX IC602 8-759-424-79 IC S-8423YFS-T2 D601 8-719-421-27 DIODE MA728-TX D602 8-719-421-27 DIODE MA728-TX IC603 8-759-059-05 IC TL1596CPW-ELM1000 D604 8-719-404-49 DIODE MA111-TX IC604 8-759-494-75 IC S579C14PZ-8500-TEB D608 8-719-404-49 DIODE MA111-TX IC751...
Page 184 VC-195 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < TRANSISTOR > Q205 8-729-037-74 TRANSISTOR UN9213J-(K8).SO Q208 8-729-037-74 TRANSISTOR UN9213J-(K8).SO Q001 8-729-031-69 TRANSISTOR 2SA1965-TL (TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) Q002 8-729-037-53 TRANSISTOR 2SB1462J-QR(K8).SO Q003 8-729-037-53 TRANSISTOR 2SB1462J-QR(K8).SO Q213 8-729-037-52 TRANSISTOR 2SD2216J-QR(K8).SO Q004 8-729-031-69 TRANSISTOR 2SA1965-TL Q214...
Page 185 VC-195 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R012 1-216-828-11 METAL CHIP 3.9K 1/16W R064 1-216-864-11 METAL CHIP 1/16W (TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) (EXCEPT TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) R013 1-216-828-11 METAL CHIP 3.9K 1/16W R065 1-216-833-11 METAL CHIP 1/16W (TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) (TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) R014 1-216-837-11 METAL CHIP 1/16W...
Page 186 VC-195 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R152 1-216-822-11 METAL CHIP 1.2K 1/16W R237 1-216-825-11 METAL CHIP 2.2K 1/16W R154 1-216-822-11 METAL CHIP 1.2K 1/16W R238 1-216-832-11 METAL CHIP 8.2K 1/16W (TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) R239 1-216-827-11 METAL CHIP 3.3K 1/16W R157...
Page 187 VC-195 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R375 1-216-834-11 METAL CHIP 1/16W R468 1-216-833-11 METAL CHIP 1/16W R376 1-216-834-11 METAL CHIP 1/16W R469 1-216-841-11 METAL CHIP 1/16W R470 1-216-829-11 METAL CHIP 4.7K 1/16W R377 1-216-834-11 METAL CHIP 1/16W R471...
Page 188 VC-195 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R566 1-216-835-11 METAL CHIP 1/16W R654 1-216-817-11 METAL CHIP 1/16W R567 1-216-825-11 METAL CHIP 2.2K 1/16W R655 1-216-853-11 METAL CHIP 470K 1/16W R569 1-216-825-11 METAL CHIP 2.2K 1/16W R662 1-216-841-11 METAL CHIP...
Page 189 VC-195 VF-99 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R767 1-216-817-11 METAL CHIP 1/16W A-7066-792-A VF-99(VHL4) BOARD, COMPLETE (TRV35/TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) *************************** R768 1-216-847-11 METAL CHIP 150K 1/16W (EXCEPT TRV15E/TRV15EP/TRV35E/TRV93) (TRV35/TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) R770 1-216-847-11 METAL CHIP 150K 1/16W A-7056-774-A ED PWB, VF-99(HP) BOARD, COMPLETE (TRV35/TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) *********************************...
Page 190 VF-99 VF-119 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R906 1-216-813-11 METAL CHIP 1/16W C5406 1-164-156-11 CERAMIC CHIP 0.1uF R907 1-216-845-11 METAL CHIP 100K 1/16W C5407 1-135-181-21 TANTALUM CHIP 4.7uF 6.3V R908 1-216-852-11 METAL CHIP 390K 1/16W C5408...
Page 191 VF-120 VL-19 VF-119 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R5429 1-216-837-11 METAL CHIP 1/16W < COIL > R5431 1-216-809-11 METAL CHIP 1/16W R5432 1-216-809-11 METAL CHIP 1/16W L5301 1-412-031-11 INDUCTOR CHIP 47uH R5433 1-218-877-11 RES,CHIP 0.50% 1/16W R5434 1-218-873-11 RES,CHIP...
Page 192 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark MISCELLANEOUS IC401 A-7030-874-A CCD BLOCK ASSY (TRV15E/TRV15EP) J001 1-565-276-31 JACK, ULTRA SMALL 1P (LANC) ************* LCD901 1-803-032-21 INDICATOR MODULE, LIQUID CRYST 1-475-619-11 SWITCH BLOCK, CONTROL (SS-8500) (TRV85/TRV815) 1-475-617-11 SWITCH BLOCK, CONTROL (FK-8500) LCD901 1-803-035-21 INDICATOR MODULE, LIQUID CRYST (TRV15/TRV15PK/TRV15E/TRV15EP/TRV25/TRV25PK/TRV215) (TRV35/TRV65/TRV65PK/TRV615/TRV35E)
Page 193 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-575-131-11 CORD, POWER 3-988-654-01 INDIVID UAL CARTON (TRV65) (TRV15:E,HK/TRV15PK/TRV25PK/TRV35:E,HK/TRV15E:AEP,EE,NE,RU/ 3-988-654-21 INDIVIDUAL CARTON (TRV615) TRV35E:AEP,EE,NE,RU,E) 1-575-334-11 CORD, CONNECTION 3-988-654-81 INDIVIDUAL CARTON (TRV15:E,HK) (A/V connecting cable (Stereo), 1.5m) 3-988-654-91 INDIVIDUAL CARTON (TRV35) (TRV65/TRV65PK/TRV85/TRV93/TRV615/TRV815) 3-988-656-01 INDIVIDUAL CARTON (TRV85) 1-696-819-11 CORD, POWER (TRV35E:AUS)
Page 194 < PARTS REFERENCE SHEET > Take a copy CAMERA COLOR REPRODUCTION FRAME and Parts reference sheets with a clear sheet for use. You can find the parts position of mount locations applying to boards of a set. S I D E B CN909 CN551 I C 2 0 4...
Page 195 FOR CAMERA COLOR REPRODUCTION ADJUSTMENT Take a copy CAMERA COLOR REPRODUCTION FRAME and Parts reference sheets with a clear sheet for use. For PAL 510H, 760H model For NTSC 510H model CCD-TRV15/TRV15PK CCD-TRV15E/TRV15EP/TRV35E For NTSC 760H model CCD-TRV25/TRV25PK/TRV35/TRV65/TRV65PK/ TRV85/TRV93/TRV215/TRV615/TRV815...
Page 196 CCD-TRV15/TRV15E/TRV15EP/TRV15PK/TRV25/TRV25PK/TRV35/TRV35E/ TRV65/TRV65PK/TRV85/TRV93/TRV215/TRV615/TRV815 Sony Corporation 98A0990-1 Printed in Japan © 1998. 1 9-974-034-11 Personal A&V Products Company Published by Quality Engineering Dept. – 320 – (Osaki East)

Sony CCD-TRV15 Service Manual

Service Note

Self-Diagnosis Function

Disassembly

Block Diagrams

Adjustments

Repair Parts List

Quick Links

Related Manuals for Sony CCD-TRV15

Summary of Contents for Sony CCD-TRV15

This manual is also suitable for:

Table of Contents