PIONEER Service Manual. A subscription to, or additional copies of, Also test with plug reversed Earth PIONEER Service Manual may be obtained at a nominal (Using AC adapter ground charge from PIONEER. plug as required)
Page 3
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. VSX-1016V-K...
1. SPECIFICATIONS For VSX-1016V-K and VSX-1016V-S Specifications Stereo Separation ..... 40 dB (1 kHz) Frequency Response ... 30 Hz to 15 kHz ± 1dB Continuous Power Output –...
Page 8
AA/IED R6P Dry Cell Batteries (for Auto MCACC setup) (VEM1031: Other models) (APM7008) Remote Control Unit (AXD7436: VSX-1016V-K, S) (AXD7435: VSX-1016TXV-K) (AXD7434: VSX-80TXV, VSX-80TXV-S) Windows Media® and the Windows logo are trademarks or registered trademarks of Microsoft Corporation in the United States and/or other countries.
For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 2.1 PACKING SECTION VSX-80TXV, -S VSX-1016TXV-K ONLY Polyethlene Bag 15 (VSX-1016V-K, -S ONLY) VSX-1016V-K, S ONLY VSX-1016V-K...
Page 11
Label (WEEE) See Contrast table (2) Operating Instructions (Italian) See Contrast table (2) Operating Instructions (Spanish)See Contrast table (2) (2) CONTRAST TABLE VSX-1016V-K/HYXJ5, VSX-1016V-S/HYXJ5, VSX-1016TXV-K/KUXJ, VSX-80TXV/KUXJCA and VSX-80TXV-S/ KUXJCA are constructed the same except for the following: VSX-1016V-K VSX-1016V-S VSX-1016TXV-K...
2.2 EXTERIOR SECTION Refer to "2.3 CHASSIS SECTION". 10 (VSX-1016V-K, -S ONLY) Refer to "2.6 FRONT PANEL SECTION". VSX-1016V-K...
Page 13
See Contrast table (2) Screw BBZ30P080FCC Screw IBP30P090FCC 4P shield cable See Contrast table (2) (2) CONTRAST TABLE VSX-1016V-K/HYXJ5, VSX-1016V-S/HYXJ5, VSX-1016TXV-K/KUXJ, VSX-80TXV/KUXJCA and VSX-80TXV-S/ KUXJCA are constructed the same except for the following: VSX-1016V-K VSX-1016V-S VSX-1016TXV-K VSX-80TXV VSX-80TXV-S Mark No.
2.3 CHASSIS SECTION VSX-1016TXV-K, AC OUTLET VSX-80TXV, -S ONLY VSX-1016V-K,S /HYXJ5 ONLY Sub Trans VSX-1016V-K,S /HYXJ5 ONLY Refer to "2.5 POWER AMP SECTION". Refer to "2.4 REAR SECTION". Refer 2.6 FRONT PANEL SECTION (∗b) VSX-1016V-K...
Page 15
SP Sheet 2016 AEC7560 NSP 55 Fuse Card See Contrast table (2) Nyron Rivet AEC7408 (2) CONTRAST TABLE VSX-1016V-K/HYXJ5, VSX-1016V-S/HYXJ5, VSX-1016TXV-K/KUXJ, VSX-80TXV/KUXJCA and VSX-80TXV-S/ KUXJCA are constructed the same except for the following: VSX-1016V-K VSX-1016V-S VSX-1016TXV-K VSX-80TXV VSX-80TXV-S Mark No.
2.4 REAR SECTION VSX-1016V-K, S, VSX-1016TXV-K POWER AMP IN CN5603 LOCAL P-SUPPLY CNJ3505 FRONT-IN CN2651 POWER PROTECT CN5703 DISPLAY CN2301 Contact side LOCAL P-SUPPLY 3502 VSX-1016V-K, S ONLY VSX-1016V-K, VSX-80TXV-S ONLY FRONT-IN CN2652 12V-REG LOCAL P-SUPPLY J3504 VSX-1016V-K...
Page 18
VSX-80TXV, -S POWER AMP IN CN5603 LOCAL P-SUPPLY CNJ3505 FRONT-IN CN2651 VSX-1016TXV-K, VSX-80TXV, -S ONLY POWER PROTECT CN5703 DISPLAY CN2301 Contact side LOCAL P-SUPPLY 3502 VSX-1016V-K, VSX-80TXV-S ONLY 12V-REG LOCAL P-SUPPLY J3504 VSX-1016V-K...
Page 19
12 FM/AM Tuner Unit AXX7172 AXX7172 AXX7172 13 Rear Panel 1016KKU ANC8386 Not used Not used 13 Rear Panel 80KKU Not used ANC8384 Not used 13 Rear Panel 80SKU Not used Not used ANC8385 19 12P FFC/60V (J52) ADD7529 ADD7529 ADD7529 VSX-1016V-K...
2.5 POWER AMP SECTION COMPONENT CN1406 VSX-1016V-K, S ONLY to/from PS/SP TRANS 2-1 CN3252 TRANS SIDE CN3202 MAIN CONTROL CN103 LOCAL P-SUPPLY J3503 VSX-1016V-K, S ONLY VSX-1016V-K...
Page 21
ANH7152 PCB Angle 45 ANG7406 Mica Sheet 45 AEE7047 H.S. Angle 2016 ANG7547 (2) CONTRAST TABLE VSX-1016V-K/HYXJ5, VSX-1016V-S/HYXJ5, VSX-1016TXV-K/KUXJ, VSX-80TXV/KUXJCA and VSX-80TXV-S/ KUXJCA are constructed the same except for the following: VSX-1016V-K VSX-1016V-S VSX-1016TXV-K VSX-80TXV VSX-80TXV-S Mark No. Symbol and Description...
2.6 FRONT PANEL SECTION TRANS SIDE 3201 MAIN CONTROL CN101 VSX-1016V-K, S ∗a ONLY USB CN701 MAIN CONTROL CN113 ∗a ∗b VSX-1016V-K...
Page 23
See Contrast table (2) NSP 25 Energy Star Label See Contrast table (2) Ring ABH7213 (2) CONTRAST TABLE VSX-1016V-K/HYXJ5, VSX-1016V-S/HYXJ5, VSX-1016TXV-K/KUXJ, VSX-80TXV/KUXJCA and VSX-80TXV-S/ KUXJCA are constructed the same except for the following: VSX-1016V-K VSX-1016V-S VSX-1016TXV-K VSX-80TXV VSX-80TXV-S Mark No.
Page 29
(VSX-1016TXV, VSX-80TXV : AWX9054) XKP%%-A 1.25mm BOARD to BOARD XKP%%-A 1.25mm BOARD to BOARD KP250NA POWER CORD 2.5mm BOARD to BOARD VSX-1016V : VDG1080 VSX-1016TXV, VSX-80TXV : VDG1075 2.5mm BOARD to BOARD ANOTHER TYPE BtoB SOCKET ANOTHER TYPE BtoB CONNECTOR VSX-1016V-K...
Page 37
XKP3066 STBY VEF1040-A : Audio Signal Route (Mic ch) GUARD-R ASSY : Audio Data Route (AWX9025) : Video Signal Route (SY) : S-Video Signal Route (Y ch) (SC) D A E F : S-Video Signal Route (C ch) VEF1040-A VSX-1016V-K...
Page 47
No marked Capacitors are CEAT or CKSRYB. Unit: p-pF or µF unless otherwise noted. XKP3076 Rated Voltage: shown as "Capacity(µF)/Voltage(V)", or 50V unless otherwise noted. 3.DIODES No marked Diodes are 1SS355. * Parts or parts block marked by "STBY" are standby. CN111 CN110 VSX-1016V-K...
No marked Capacitors are CEAT or CKSRYB. V+5_6U Unit: p-pF or µF unless otherwise noted. Rated Voltage: shown as "Capacity(µF)/Voltage(V)", or 50V unless otherwise noted. 3.DIODES No marked Diodes are 1SS355. * Parts or parts block marked by "STBY" are standby. GNDU GNDVC CN108 CN109 VSX-1016V-K...
: Audio Signal Route (Surround Back L ch) (SW) STBY : Audio Signal Route (SubWoofer ch) GNDU GNDVC GNDU (CHASSIS) : Video Signal Route (Component Y ch) (Cb) : Video Signal Route (Component Cb ch) (Cr) CN107 : Video Signal Route (Component Cr ch) VSX-1016V-K...
Page 51
Unit: p-pF or µF unless otherwise noted. Rated power: 1/16W unless otherwise noted. Tolerance: ±5%(J) unless otherwise noted. Rated Voltage: shown as "Capacity(µF)/Voltage(V)", or 50V unless otherwise noted. 2.DIODES No marked Diodes are 1SS355. * Parts or parts block marked by "STBY" are standby. VSX-1016V-K...
2SA1514K(RS) Q3354 2SC3906K(RS) Q3352 2SB1186A(DE) D3351 1SR154-400 CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH VH TR ASSY SAME TYPE NO. ICP-N15, MFD BY ROHM (AWX9061) CO., LTD. FOR IC3351 and IC3352. S T U VSX-1016V-K...
Page 57
Unit: p-pF or µF unless otherwise noted. (SL) Ratings: Capacity(µF)/Voltage(V) unless otherwise noted. : Audio Signal Route (Surround L ch) Rated Voltage: 50V except for electrolytic capacitors. MBA:CQMBA, LA:CFTLA : Audio Signal Route (Center ch) (SBL) : Audio Signal Route (Surround Back L ch) VSX-1016V-K...
CHASSIS STBY R3210 GNDST L3210 V+5.6ST R3211 V+5.6ST L3211 RY AC VEF1040-A STBY RY AC R3212 W UP W UP L3212 HPDET R3213 CN3203 CN3202 L3213 B13B-PH-K-S CKS3382 R3202 - R3214,L3202 - L3214:STBY DC/DC ASSY (AWX9098) X Y Z VSX-1016V-K...
Page 59
OSDRT GAV(SUPERG2) GAV(SUPERG2) V+5.6V V+5.6V V-5.6V V-5.6V V+iPOD V+iPOD 3801 V-5_6V (SUPERG2) STBY CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH VIDEO CONNECT SAME TYPE NO. 49101.6 MFD, BY LITTELFUSE INK. FOR IC3510. ASSY (AWX9069) VSX-1016V-K...
OL DET RT1P241M (22k) DC DET POSI_2 VSX-1016TXV, POSI_1 VSX-80TXV Q5701 Q5705 (22k) GNDU ONLY R5747 OL DET RT1N241M Q5703 RT1N241M R5715 (22k) (22k) RT1N241M (22k) Q5704 2SC4081(QR) OL DET DC DET POSI_2 POSI_2 GNDU POSI_1 CN5702 XKP3065 AI AJ VSX-1016V-K...
Page 65
HPD1 HPD1 LOCKDET V-FAN PROTECTION DETECT V-FAN NORMAL DETECT VCS DA VCS DA V+FAN LOCK DET VCS CLK VCS CLK OL DET V+FAN XVC RST XVC RST DC DET CN5705 GNDD GNDD TEMP1,2 52044-1745 CN5704 S5B-PH-K-S AI AJ J3503 VSX-1016V-K...
Symbol In PCB Symbol In Schematic Part Name Diagrams Diagrams C E B Capacitor Connector Transistor B C E SIDE A Transistor with resistor B C E Field effect SIDE B P.C.Board Chip Part transistor Resistor array 3-terminal regulator VSX-1016V-K...
4.2 12V-REG ASSY SIDE A SIDE A 12V-REG ASSY IC661 IC662 NJM79M12 NJM78M12 PRINTED SIDE PRINTED SIDE J663 12V REG ASSY AWX9014 (ANP7560-C) SIDE B SIDE B (ANP7560-C) 12V-REG ASSY VSX-1016V-K...
Page 80
EX CK EX ST EX OE EX DT0 EX DT1 V+5.6ST V+5.6U MAIN CONTROL Ass'y GNDU 9.-VF GNDU FLAC2 MIC DET FLAC1 SRIN FANSTOP SROUT FANDRIVE FLAC1 V+5.6U FLAC2 GNDU 29.-VF 1.GNDU AWX9019 AWX9016 AWX9020 AWX9017 AWX9018 CN302 CN301 VSX-1016V-K...
4.11 VOLUME ASSY SIDE A SIDE A VOLUME ASSY VOLUME ASSY AWX9044 AWX9111 SIGNAL SELECT S2451 S2452 S2453 Multi ch IN (Sound Retriver) SBch PROCESSING PNE-1B1 W2491 VENCB S2454 (ANP7562-B) SIDE B SIDE B VOLUME ASSY (ANP7562-B) VSX-1016V-K...
4.12 HEADPHONE ASSY SIDE A SIDE A HEADPHONE ASSY CN2851 1.HPDET 2.HPR 3201 3.GNDHP 4.HPL KN2851 (ANP7562-B) SIDE B SIDE B HEADPHONE ASSY C2854 C2855 (ANP7562-B) VSX-1016V-K...
SIDE B MULTI JOG ASSY HDMI iPod TUNER VIDEO/GAME DVR/VCR2 (VIDEO SELECT) (Multi CH IN) CD-R/TAPE V+5UH EXQS TUNING/ TUNER EDIT SPEAKERS STATION VSX-1016V-K...
Page 111
(Phase Control) DVD/LD Listening Mode DVR/VCR1 TV/SAT MR CONTROL KEY1 DVR/VCR2 (Acoustic EQ) V+5UH GNDU V+5UH V+5UH V+5U GNDU GNDU MULTIJOG ASSY AWX9045 AWX9112 EXQS AWX9046 AWX9113 ENTER EXOE PNE-1B1 EXQS (ANP7562-B) TONE RETURN SYSTEM TUNING/ R EDIT SETUP STATION VSX-1016V-K...
4.16 TRANS 1 ASSY SIDE A SIDE A TRANS 1 ASSY AWX9038 TRANS1 ASS'Y PNE-1B1 Y15A Y14A Y14B Y15B PRIMARY SIDE (ANP7562-B) T1501 MAIN TRANS. SIDE B SIDE B TRANS 1 ASSY Y14B Y15B (ANP7562-B) VSX-1016V-K...
SIDE A TRANS 2-2 ASSY CN3501 (ANP7563-B) SIDE B SIDE B 12.AREG 11.AREGG 10.AREG 6.DREG 9.DREG 5.VREG 8.DREG 4.VREGG 7.DREG 3.VREG 2.AC2 1.AC1 PNE-1B1 RISK OF FIRE - REPLACE FUSE AS MARKED. TRANS2-2 ASS'Y AWX9062 (ANP7563-B) TRANS 2-2 ASSY VSX-1016V-K...
4.23 TRANS SIDE ASSY SIDE A TRANS SIDE ASSY CN5705 CN2851 CN3202 3201 3201 1.HPSW 2.HPR 3.HPG PRODUCTION CODE 4.HPL CN3202 SIDE B TRANS SIDE ASSY 0 1 2 3 CN3202 3201 VSX-1016V-K...
Page 131
SIDE A J3009 CN3203 13,WUP 12,RYAC 11,V+5.6ST 10,GNDST 9,RYB 8,RYCS 7,RYHP 6,RYA 5,V+12V 4,V-12V 3,HPR 2,HPG 1,HPL AWX9056- 1,+FAN TRANS SIDE ASSY 2,-FAN AWX9057- 3,LOCK DET PNE-1B1 (ANP7563-B) SIDE B (ANP7563-B) CN3203 VSX-1016V-K...
Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V 7 7 7 7 LIST OF WHOLE PCB ASSEMBLIES VSX-1016V-K VSX-1016V-S VSX-1016TXV-K...
Page 159
CEAT101M10 C1023 Not used CCSRCH181J50 C1151-C1154 Not used CEAT2R2M50 C1155, C1156, C1161, C1162 Not used CCSRCH101J50 C1157, C1158 Not used CCSRCH331J50 C1159, C1163 Not used CKSRYB104K50 C1160 Not used CEAT100M50 R1005 Not used RS1/16S750J R1151, R1152 Not used RS1/16S104J VSX-1016V-K...
Page 160
Not used CKSRYB153K50 C2412 Not used Not used CKSRYB103K50 R2407 Not used Not used RS1/16S223J R2408, R2410 Not used Not used RS1/16S103J R2409 Not used Not used RS1/16S392J R2414 RS1/16S0R0J RS1/16S0R0J Not used R2423 Not used RS1/16S221J Not used VSX-1016V-K...
AWX9068 and AWX9065 are constructed the same except for the following : Mark Symbol and Description AWX9068 AWX9065 > IC3502 (1.6A) AEK7012 Not used > Q3501 UMD2N Not used > Q3502 2SD1763A(DE) Not used Q3503 DTC124EUA Not used > D3509, D3510 1SR154-400 Not used VSX-1016V-K...
Page 162
AWX9073 and AWX9106 are constructed the same except for the following : Mark Symbol and Description AWX9073 AWX9106 5002 PCB BINDER VEF1040 Not used POSI 1-R ASSY AWX9084 and AWX9083 are constructed the same except for the following : Mark Symbol and Description AWX9084 AWX9083 TH4503 POSISTOR PTFM04BH222Q2N34B0 PTFM04BC222Q2N34B0 VSX-1016V-K...
Page 163
Not used R5718 RS1/16S104J Not used CN5706 3 PIN CONNECTOR S3B-EH Not used 7 7 7 7 PCB PARTS LIST FOR VSX-1016V-K/HYXJ5 UNLESS OTHER WISE NOTED Mark No. Description Part No. Mark No. Description Part No. CN526 (A,317,214) PIN JACK (4P)
Page 164
R 724 (A,213,70) RS1/16S472J R 807 (A,269,168) RS1/16S271J R 725 (A,226,74) RS1/16S122J R 808 (A,269,173) RS1/16S271J R 726 (A,213,74) RS1/16S122J R 811 (A,263,165) RS1/16S153J R 727 (B,223,73) RS1/16S392J R 812 (A,263,175) RS1/16S153J R 728 (B,216,73) RS1/16S392J R 815 (B,262,194) RS1/16S104J VSX-1016V-K...
Page 165
C 521 (B,307,167) CCSRCH101J50 C 587 (A,247,84) CKSRYB473K50 C 522 (B,307,162) CCSRCH101J50 C 588 (A,246,84) CKSRYB154K10 C 523 (B,307,182) CCSRCH101J50 C 589 (A,244,84) CKSRYB223K50 C 524 (B,307,177) CCSRCH101J50 C 590 (A,247,76) CKSRYB473K50 C 525 (B,307,195) CCSRCH101J50 C 591 (A,247,74) CKSRYB154K10 VSX-1016V-K...
Page 166
NJM79M12FA C 766 (A,194,64) CCSRCH331J50 D 665 (B,28,90) CHIP DIODE RB501V-40 C 767 (B,188,68) CCSRCH331J50 D 666 (B,56,88) CHIP DIODE RB501V-40 C 768 (B,195,68) CCSRCH331J50 663 (A,46,77) 6P CABLE HOLDER 51048-0600 C 769 (A,188,76) CEAT100M50 C 770 (A,195,76) CEAT100M50 VSX-1016V-K...
Page 167
R 143 (A,142,178) RS1/16S0R0J JA 291 (A,9,131) MINI JACK (4P) /W SW XKN3015 R 144 (A,141,177) RS1/16S0R0J JA 292 (A,11,143) JACK RKN1004 KN281 (A,13,153) SCREW PLATE VNE1948 X 101 (A,159,157) CERAMIC RESONATOR XSS3004 X 251 (A,138,207) CRYSTAL RESONATOR ASS7004 VSX-1016V-K...
Page 168
IC 871 (B,63,53) IC TC7WH125FU R 281 (B,21,168) RS1/16S101J > IC 901 (B,120,30) IC NJM2391DL1-33 R 282 (B,21,184) RS1/16S101J > IC 902 (B,94,36) REGULATOR IC LM1117DT-ADJ R 283 (B,21,198) RS1/16S101J IC 952 (B,19,48) OCTAL BUS BUFFER IC TC74VHCT244AFTS1 R 385 (B,97,102) RS1/16S0R0J VSX-1016V-K...
Page 169
R 809 (B,40,56) RS1/16S472J R 572 (A,90,54) RS1/16S0R0J R 810 (A,31,52) RS1/16S473J R 573 (B,90,54) RS1/16S0R0J R 574 (B,76,56) RS1/16S0R0J R 811 (B,30,51) RS1/16S472J R 812 (B,32,51) RS1/16S101J R 813 (A,27,49) RS1/16S103J R 815 (A,38,40) RS1/16S105J R 816 (A,35,40) RS1/16S471J VSX-1016V-K...
Page 170
C 503 (B,125,29) CKSRYB103K50 C 825 (B,38,52) CKSRYB103K50 C 504 (B,125,42) CKSRYB103K50 C 826 (A,44,44) CCSRCH471J50 C 505 (B,125,38) CCSRCH470J50 C 827 (A,41,44) CKSRYB104K16 C 506 (A,121,62) CCSRCH470J50 C 828 (A,53,48) CCSRCH471J50 C 511 (B,125,52) CCSRCH471J50 C 829 (A,54,48) CKSRYB104K16 VSX-1016V-K...
Page 171
R 570 (A,75,41) RS1/16S101J L 803 (A,53,38) CHIP SOLID INDUCTOR ATL7002 R 571 (A,75,39) RS1/16S470J L 804 (B,30,34) CHIP SOLID INDUCTOR QTL1013 R 604 (B,111,49) RS1/16S104J L 851 (A,45,23) CHIP SOLID INDUCTOR QTL1013 L 871 (B,67,45) CHIP SOLID INDUCTOR QTL1013 VSX-1016V-K...
Page 172
C 413 (A,115,56) CKSQYB105K16 R 830 (B,47,32) RS1/16S470J C 503 (B,125,16) CKSRYB103K50 R 832 (A,48,41) RS1/16S470J C 504 (B,130,30) CKSRYB103K50 R 833 (A,50,45) RS1/16S470J C 551 (A,85,47) CKSRYB104K16 R 834 (A,54,46) RS1/16S470J C 552 (A,85,45) CCSRCH471J50 R 835 (A,50,47) RS1/16S470J VSX-1016V-K...
Page 173
C 824 (A,32,28) CKSRYB104K16 R 1002(B,125,221) RS1/16S750J C 825 (B,33,39) CKSRYB103K50 R 1003(B,97,220) RS1/16S750J R 1004(B,69,220) RS1/16S750J C 826 (A,38,30) CCSRCH471J50 R 1007(B,81,220) RS1/16S750J C 827 (A,38,29) CKSRYB104K16 C 828 (A,48,35) CCSRCH471J50 C 829 (A,49,35) CKSRYB104K16 C 830 (A,48,38) CCSRCH471J50 VSX-1016V-K...
Page 174
C 1027(A,45,180) CEAT101M10 R 1205(B,89,152) RS1/16S750J C 1028(A,45,187) CEAT101M10 R 1206(B,91,152) RS1/16S750J C 1029(A,45,177) CKSRYB473K25 R 1207(B,61,151) RS1/16S750J C 1030(A,27,185) CKSRYB473K25 R 1208(B,63,151) RS1/16S750J C 1031(A,39,177) CCSRCH101J50 R 1209(B,47,148) RS1/16S750J C 1032(A,35,177) CKSRYB122K50 R 1210(B,49,148) RS1/16S750J C 1033(A,31,177) CKSRYB122K50 VSX-1016V-K...
Page 175
CKSRYB104K16 CN1402(A,175,30) 11P SOCKET XKP3076 C 1229(A,55,118) CEAT101M10 C 1230(A,87,130) CKSRYB104K16 CN1403(A,68,39) 13P SOCKET XKP3077 C 1231(A,62,118) CEAT101M10 CN1405(A,19,59) 17P SOCKET XKP3079 CN1406(A,53,41) CONNECTOR CKS3384 CN1501(A,58,94) PIN JACK (4P) AKB7172 CN1502(A,30,94) PIN JACK (4P) AKB7172 1401(A,166,28) PCB BINDER VEF1040 VSX-1016V-K...
Page 176
C 1420(A,95,61) CEAT101M10 R 1507(B,63,86) RS1/16S474J C 1421(A,97,53) CEAT101M10 R 1508(B,67,87) RS1/16S474J C 1425(A,83,67) CEAT101M10 R 1509(A,62,60) RS1/16S103J R 1510(A,68,60) RS1/16S103J C 1426(A,83,73) CEAT101M10 R 1511(A,60,69) RS1/16S103J C 1427(B,86,67) CKSRYB104K25 C 1428(B,86,72) CKSRYB104K25 C 1431(B,82,60) CKSRYB224K10 C 1432(B,78,60) CKSRYB224K10 VSX-1016V-K...
Page 177
RS1/16S104J C 1593(B,30,86) CKSRYB103K50 R 2330(B,162,240) RS1/16S104J R 2331(B,164,240) RS1/16S104J COMPLEX ASSY R 2332(B,166,240) RS1/16S104J MISCELLANEOUS R 2333(B,168,240) RS1/16S104J R 2334(B,170,240) RS1/16S104J > Y 15 AWG18 BOARD IN ADX7501 R 2335(B,172,240) RS1/16S104J > Y 14 AWG18 BOARD IN ADX7500 VSX-1016V-K...
Page 178
R 2420(B,233,220) RS1/16S331J MISCELLANEOUS R 2422(B,64,219) RS1/16S331J IC 2501(B,157,111) LOGIC IC CD4094BNS R 2424(B,135,193) RS1/16S472J Q 2501(B,162,146) DIGITAL TR (SC-70) RT1N431M Q 2502(B,174,146) DIGITAL TR (SC-70) RT1N431M Q 2503(B,195,146) DIGITAL TR (SC-70) RT1N431M Q 2504(B,217,146) DIGITAL TR (SC-70) RT1N431M VSX-1016V-K...
R 2506(B,259,152) RS1/16S331J R 2507(B,280,152) RS1/16S331J FRONT-IN ASSY R 2508(B,302,152) RS1/16S331J MISCELLANEOUS R 2509(B,142,152) RS1/16S331J IC 2701(B,36,55) OP-AMP IC BA4560RF R 2510(B,9,186) RS1/16S391J Q 2651(B,116,47) CHIP TRANSISTOR HN1C01FU D 2701(B,29,62) DIODE DAN217 D 2702(B,33,32) DIODE UDZS5R1(B) D 2703(B,31,29) DIODE UDZS5R1(B) VSX-1016V-K...
Page 180
H 2002(A,223,46) FUSE CLIP AKR7001 R 2751(B,65,60) RS1/16S0R0J R 2752(B,63,60) RS1/16S0R0J KN2001(A,194,19) SCREW PLATE VNE1948 > RY2001(A,251,58) JOE LOW POWER RELAY ASR7013 > T 2001(A,273,84) STANDBY TRANSFORMER ATT7040 CN2001(A,301,115) 9P SOCKET KP200TA9L CN2002(A,246,115) 5P SOCKET KP200TA5L > CN2003(A,225,25) AC CORD SOCKET RKP1751 VSX-1016V-K...
R 3254(A,263,212) METAL OXIDE RESISTOR RS1LMF472J D 3006(B,244,82) DIODE 1SS355 > R 3255(A,245,195) CARBON FILM RESISTOR RD1/2LMF332J D 3007(B,291,79) DIODE 1SS355 > R 3256(A,259,215) CARBON FILM RESISTOR RD1/2LMF332J D 3008(B,289,79) DIODE 1SS355 D 3009(B,217,99) DIODE 1SS355 D 3010(B,215,99) DIODE 1SS355 VSX-1016V-K...
C 3043(A,253,42) FILM CAPACITOR CQMBA103J50 D 3508(B,142,180) DIODE UDZS6R2(B) C 3051(A,224,70) CFTLA104J50 C 3052(A,230,70) CFTLA104J50 > D 3509(B,108,160) DIODE 1SR154-400 > D 3510(B,113,160) DIODE 1SR154-400 D 3511(B,112,132) DIODE UDZS27(B) > D 3512(A,117,196) DIODE D3SBA20(B) D 3513(B,86,180) CHIP DIODE RB501V-40 VSX-1016V-K...
Page 183
KN651 (A,40,181) SCREW PLATE VNE1948 CN651 (A,70,221) 3P TOP POST B3B-EH C 5608(B,36,42) CERAMIC 4P/200 V ACG7057 CN652 (A,70,166) 4P JUMPER CONNECTOR 52147-0410 C 5609(A,27,51) ELECT. CAPACITOR CEAT100M2A 651 (A,52,146) PCB BINDER VEF1040 C 5615(B,45,47) CCSRCH220J50 C 5616(B,42,49) CCSRCH220J50 C 5617(A,47,52) CEAT331M10 VSX-1016V-K...
Page 184
R 5046(B,154,179) RS1/16S472J D 5101(B,137,188) CHIP ZENER DIODE UDZS3R6(B) R 5047(B,150,187) RS1/16S122J D 5102(B,135,188) DIODE 1SS355 R 5048(B,151,183) RS1/16S154J D 5103(B,126,184) DIODE 1SS355 R 5049(B,154,183) RS1/16S103J D 5104(B,119,184) DIODE 1SS355 R 5050(B,152,187) RS1/16S103J D 5105(B,124,184) DIODE UDZS4R7(B) R 5101(B,139,202) RS1/16S102J VSX-1016V-K...
Page 185
R 5230(B,261,202) RN1/16SE1001D C 5217(A,261,206) CEAT331M10 C 5223(A,287,181) CEAT100M63 R 5231(B,261,204) RN1/16SE1500D C 5224(A,255,184) CEAT100M63 R 5232(B,248,195) RS1/16S151J R 5241(B,237,169) RS1/16S473J C 5232(B,250,199) CKSRYB224K16 R 5242(B,239,169) RS1/16S223J C 5241(A,237,192) CEANP2R2M50 R 5243(B,235,169) RS1/16S471J C 5611(B,307,142) CERAMIC 100P/200 V ACG7056 VSX-1016V-K...
Page 186
D 5403(B,126,62) DIODE 1SS355 R 5402(B,126,42) RS1/16S221J D 5404(B,119,62) DIODE 1SS355 R 5403(B,123,41) RS1/16S333J D 5405(B,124,62) DIODE UDZS4R7(B) R 5404(B,139,40) RS1/16S103J D 5406(B,122,62) DIODE UDZS4R7(B) R 5405(B,116,55) RS1/16S152J D 5441(B,95,58) DIODE 1SS355 R 5406(B,114,47) RS1/16S821J D 5442(B,92,58) DIODE 1SS355 VSX-1016V-K...
Page 187
R 5541(B,241,77) RS1/16S473J C 5532(B,252,47) CKSRYB224K16 R 5542(B,235,77) RS1/16S223J C 5541(A,238,54) CEANP2R2M50 R 5543(B,239,77) RS1/16S471J C 5571(A,229,35) CEAT331M10 C 5612(B,307,104) CERAMIC (100P, 200 V) ACG7056 R 5544(B,237,77) RS1/16S471J R 5545(B,240,64) RS1/16S472J R 5546(B,238,64) RS1/16S472J R 5547(B,238,57) RS1/16S122J R 5548(B,235,68) RS1/16S154J VSX-1016V-K...
R 5641(B,14,43) RS1/16S473J R 5751(B,26,131) RS1/16S0R0J R 5752(B,25,101) RS1/16S0R0J R 5642(B,17,33) RS1/16S223J R 5643(B,14,33) RS1/16S471J R 5644(B,15,38) RS1/16S471J CAPACITORS R 5645(B,18,28) RS1/16S472J C 5701(B,13,181) CKSRYB104K50 R 5646(B,20,28) RS1/16S472J C 5702(B,15,181) CKSRYB104K50 C 5703(B,23,110) CKSRYB103K50 C 5704(B,23,114) CKSRYB103K50 C 5705(B,31,101) CKSRYB223K50 VSX-1016V-K...
Page 189
R 716 (A,77,37) RS1/16S103J CN1001(A,103,64) 9P SOCKET XKP3075 CN1002(A,69,64) 23P SOCKET XKP3082 R 718 (A,76,37) RS1/16S103J R 719 (A,75,34) RS1/16S332J CN1003(A,110,21) 9P CONNECTOR 52044-0945 R 720 (A,76,34) RS1/16S682J R 721 (A,80,31) RS1/16S470J R 731 (A,79,48) RS1/16S1500F RESISTORS R 101 (A,28,44) RS1/16S102J VSX-1016V-K...
Page 190
S29AL016D70TFI010 C 425 (A,64,50) CKSRYB104K16 IC 771 (A,58,59) LOAD SWITCHING AAT4618IGV-0.5-1 C 426 (A,65,52) DCH1201 IC 781 (A,37,16) AUDIO DAC AK4387ET C 427 (A,62,50) CKSRYB104K16 IC 951 (A,67,28) IC TC74VHCT08AFTS1 C 428 (A,61,48) CKSRYB104K16 IC 953 (A,52,25) IC TC74VHC08FTS1 VSX-1016V-K...
Page 191
C 734 (B,41,32) CKSRYB103K50 R 771 (A,61,56) RS1/16S221J C 735 (B,37,33) CKSRYB103K50 R 772 (A,58,56) RS1/16S104J C 741 (A,92,19) CEJQ101M16 R 773 (A,71,59) RS1/16S0R0J C 742 (B,96,20) CKSRYB104K16 R 784 (A,30,21) RS1/16S470J C 743 (A,96,32) CKSRYB105K6R3 R 786 (A,41,21) RS1/16S470J VSX-1016V-K...
C 786 (A,55,16) CEJQ100M16 C 788 (A,42,18) CKSRYB104K16 C 789 (A,77,26) CKSRYB102K50 C 790 (A,79,25) CKSRYB102K50 C 791 (A,75,31) CEJQ100M16 C 792 (A,81,31) CEJQ100M16 C 951 (A,58,27) CCSRCH471J50 C 952 (A,59,27) CKSRYB105K10 C 956 (A,70,34) CKSQYB105K10 C 957 (A,70,33) CCSRCH471J50 VSX-1016V-K...
3. If the USB firmware version indication becomes "**," return the unit to Normal mode, switch Function to USB, then reenter Test mode and check the USB firmware version. If the indication becomes "**" again, communication between the main microcomputer and the USB firmware is in failure. VSX-1016V-K...
Page 194
When the keys are pressed, the numbers of DC detections, overload detections, detections of connectors disconnection inside unit (It is detected by both DC and OVERLOAD detections.), detections of fan abnormalities, and detections of abnormal temperature are displayed for 3 seconds each, in that order. The maximum value of each detections is 255. VSX-1016V-K...
Page 195
XM ANT ERR : Thepower supply of the XM antenna is abnormally. (KUXJ and KUXJCA types only) [How to enter release mode] Press and hold DVR/VCR2 and ENTER keys on the front panel simultaneously for 5 seconds in standby mode. VSX-1016V-K...
→ Collector of Q5571 and Q5572 are "L". C ch L ch SL ch SBL ch -DC detection: Q5572 emitter is minus to the base. → Collector of Q5571 and Q5572 are "L". POWER AMP-L ASSY POWER AMP IN ASSY VSX-1016V-K...
Page 197
R5043 Q5704 GNDU OUTPUT L ch GNDU GAMP IC5002 R5044 CN5702 D5343 R ch D5143 SL ch CN5302 D5443 SR ch POWER D5243 SBL ch D5543 AMP-R ASSY SBR ch CN5301 C ch CN5602 D5143 POWER AMP IN ASSY VSX-1016V-K...
Replace IC952. 5 V for pin 13 voltage of 5 V Regulator assy. input? input? IC952 (Pin 9) convert 3 V into Replace IC952. 5 V for pin 11 input? Part shape and Pin arrangement of IC901 and IC902 VSX-1016V-K...
Page 199
Check the IR I/O Assy, and observer the parts and patterns in the path. digital signal IC601 (Pin 26) BCK (Bit clock) (0 V ⇔ 4 V) Is there Replace IC601. a bit clock output? To Step 6 VSX-1016V-K...
Page 200
Replace IC701. a data output? Is the output Replace IC801. 0 V fixing? Surround L out IC701 (Pin 25) Center/LFE data IC801 (Pin 5) Is there Replace IC701. a data output? Is the output Replace IC801. 0 V fixing? VSX-1016V-K...
Page 201
Center out IC701 (Pin 23) Is the output Replace IC701. 2.5 V fixing? IC701 (Pin 24) LFE out Is the output Replace IC701. 2.5 V fixing? Surround L out IC701 (Pin 25) Is the output Replace IC701. 2.5 V fixing? VSX-1016V-K...
Page 202
Step 3: Regulator IC IC952 (Pin 5) IC901 (Pin 1) (to chassis) convert 3 V into Is the Replace IC952. 5 V for pin 15 Check the CN901 and voltage of around input? 5 V to 5.3 V Regulator assy. input? VSX-1016V-K...
Page 203
IC951 (Pin 3) Replace IC953. 3 V for pin 12 input? convert 3 V into Replace IC951. 5 V for pin 2 To Step 6 input? IC951 (Pin 6) convert 3 V into Replace IC951. 5 V for pin 5 input? VSX-1016V-K...
Page 204
Front R out Is the voltage of IC551- Is there pin 1 3.3 V? a master clock output? Is the output Replace IC701. 2.5 V fixing? Replace IC551. Check the path between To Step 7 IC551-pin 1 and the microcomputer. VSX-1016V-K...
Page 205
Replace IC952. 5 V for pin 13 voltage of 5 V Regulator assy. input? input? IC952 (Pin 9) convert 3 V into Replace IC952. 5 V for pin 11 input? Part shape and Pin arrangement of IC901 and IC902 VSX-1016V-K...
Page 206
Is there output? Replace IC801. a data output? To Step 6 Surround L/R data IC801 (Pin 6) Is there Replace IC801. a data output? IC801 (Pin 7) Front L/R data Is there Replace IC801. a data output? To Step 8 VSX-1016V-K...
Page 207
IC701 (Pin 26) Surround R out Is there Replace IC701. a data output? Front L out IC701 (Pin 27) Is there Replace IC701. a data output? IC701 (Pin 28) Replace IC701. Is there Replace IC701. a data output? VSX-1016V-K...
Causes for no display or sound from the monitor Replace the HDMI cable. Replace the HDMI cable. Connect the source equipment (player) to the Sink equipment Repair the Receiver. (monitor) directly. Replace the Player. Repair the Player. Replace the Monitor. Repair the Monitor. VSX-1016V-K...
Page 210
Is the voltage If JA101 is failure, replace JA101. 5 V? * When connected the source equipment to IN2. +5 V (HDMI IN2) JA102 (Pin 18) Check the JA102. Is the voltage If JA102 is failure, replace JA102. 5 V? VSX-1016V-K...
Page 211
And is the voltage "L" JA301 (Pin 15) SCL (HDMI IN2) replace Q151 or JA101. when selecting IN2? Is there Check the IC102 and JA102. a same signal as If IC102 or JA102 is failure, D-2 ? replace IC102 or JA102. VSX-1016V-K...
Page 212
3.3V_EN1 Is there a Diagnose the MAIN CONTROL Check the L701. C signal? Assy or S-VIDEO Assy. Is the voltage If L701 is failure, replace L701. 3.3 V? Note: Check is unnecessary because component input does not convert it. VSX-1016V-K...
Page 213
If Q451 is failure, replace Q451. SY OUT Check the parts and patterns in Is there a the path. Y signal? If Q741 or R743 is failure, replace Q741 or R743. Diagnose the MAIN CONTROL Assy or S-VIDEO Assy. VSX-1016V-K...
Page 214
CN1002 (Pin 21) Pb OUT Check the parts and patterns in Is there a the path. Pb signal? If Q771 or R773 is failure, replace Q771 or R773. Diagnose the MAIN CONTROL Assy or COMPONENT Assy. VSX-1016V-K...
Page 215
HDMI & DVC Assy Check Points HDMI & DVC ASSY SIDE B HDMI section Video converter section Common section 3.3V_EQ 3.3V_DE2 3.3V_EN2 1.8V_DE2 3.3V_EN1 3.3V_OSC V+5A 3.3V_DE1 V+5D V+3R3 1.8V_DE1 V+1R8VC HDMI section VSX-1016V-K...
Page 216
Hot Plug1 IC102 IC103 SN74CBT3257CPW PCA9515ADP Main ucom I/F DDC SW I2C REPEATER HPD_IN CN1001 (9P) HPD0 HPD1 VC_SCL/VC_SDA Analog Video IN/OUT CVBS P[8-15] IC401 ADV7184BSTZ LLC1 VIDEO DECODER IC701 ADV7172KSTZ Power Supply CN1002 VIDEO ENCODER (23P) CVBS CN1003 (9P) VSX-1016V-K...
In this state, flashing of "USB ERROR1" stops, but playback will not start. To start playback, press the USB play key again. In the above case, if overcurrent is detected again, the above procedures 1 through 4 are repeated. VSX-1016V-K...
Page 218
: USB Host control decoder (MP3/WMA/MPEG-4AAC) 16M FLASH ROM : Firmware is stored 64M SDRAM : Temporary storage area of decoding music file LOAD SWITCH : Current limitation to USB device power 2ch DAC : D/A converter for analog output VSX-1016V-K...
Page 219
Is IC702 the voltage abnormally IC7814 (pins 14, 15) 1.8 V ? hot? Replace IC702. Check the parts and the voltage patterns in the path. The output and GND may be 5 V ? short-circuited. Check the path between them. VSX-1016V-K...
Page 221
L/R clock IC701 (pin 63). signal IC781 (pins 10,11) LOUT/ROUT IC781 (pin 3) DATA Are there Replace IC781. audio signal Is there Check the output from DATA signal IC701 (pin 67). Check the parts and pattern between IC781 and CN702. VSX-1016V-K...
• Never change the function setting or turn the power off during the process of Steps 3 through 5. If you do, loading of the firmware will fail, and updating procedures cannot be continued. In such a case, replacement of the flash memory is required. VSX-1016V-K...
ASSY TRANS 1 HDMI & DVC COMPONENT ASSY ASSY ASSY TRANS 2-1 S-VIDEO ASSY ASSY VH TR COMPOSITE ASSY ASSY DIODE 1 AUDIO IN BRIDGE 2 ASSY ASSY ASSY PRIMARY ASSY VSX-1016V USB ASSY DSP ASSY ONLY PS/SP ASSY VSX-1016V-K...
Page 225
Disconnect the one jumper wire. Disconnect the six connectors. Remove the power amp block. PS/SP Assy Rear view ×6 TRANS 2-1 Assy Remove the eight screws. Remove the bonnet. POWER AMP IN Assy Power Amp Bonnet Block ×2 POWER PROTECT Assy ×2 VSX-1016V-K...
Page 226
Remove the HS angle 2016. HS angle 2016 ×2 HS Angle 2016 Remove the four screws. Remove the HS angle 2016. ×2 HS angle 2016 ×2 Replacing the Power Transistor POWER AMP-L Assy POWER AMP-R Assy Power transistor Power transistor ×2 Replace VSX-1016V-K...
Page 227
Disconnect cables, connectors, as required. First remove the BRIDGE 2 Assy, then remove the COMPOSITE, S-VIDEO, COMPONENT and VIDEO CONNECT Assys. Remove the three screws. Remove the 32 screws. (VSX-80TXV(-S): Remove the 34 screws.) Remove the rear panel. ×32 Rear view VSX-1016V-K...
Page 228
Pin jack (L side GND) on the AUDIO IN Assy ↔ chassis c Pin jack (Yellow GND) on the COMPOSITE Assy ↔ chassis d Speaker terminal (L side black) ↔ chassis DSP Assy AUDIO IN Assy Speaker terminal AUDIO IN Assy VSX-1016V-K...
Ground − Non connection DATA Control data input Inputs data in synchronization with clock. Clock input pin for transferring serial data − Non connection − Power supply VOUT2 2-ch output VIN2 2-ch input − Non connection Cref Vref filter VSX-1016V-K...
Page 232
DR CTL2 Changeover pin of drive ability NFB5 Negative feedback pin of amp VOUT2 Output pin − − -VCC2 -VCC power supply Ground VIN6+ Input pin VOUT1 Output pin − NFB6 Negative feedback pin of amp +VCC1 +VCC power supply VSX-1016V-K...
Page 233
Inputs a vertical synchronization signal created by integrating the SEPOUT pin output signal CTRL2 NTSC/PAL-M switching input CTRL3 Control whether or not the VSYNC signal is input to the SEPIN input System reset input − VDD1 Power supply (+5 V: digital system power supply) VSX-1016V-K...
Page 234
O/L DSP Analog/Digital P51/WRH/BHE DIR DO Communication data-in signal with the DIR/DAC P50/WRL/WR DIR CS O/L Communication chip select signal with the DIR/DAC P47/CS3 LSSN O/L DSP SP= LSSN setting P46/CS2 DIR CDC RST O/L DIR CODEC reset signal VSX-1016V-K...
Page 235
P101/AN1 SIMUKE2 Destination reading 2 − AVSS AVSS Connect to VSS P100/AN0 XM ERR XM abnormal detection − VREF VREF Connect to VCC − AVcc AVCC Connect to VCC P97/ADTRG/SIN4 USB DO Communication data input with the USB module VSX-1016V-K...
Page 238
GPIO_D16 GPIO_D[16] GPIO_D17 GPIO_D[17] GPIO_D18 GPIO_D[18] GPIO_D19 GPIO_D[19] GPIO_D20 GPIO_D[20] GPIO_D21 GPIO_D[21] − VSSIO Digital ground for I/O MODE1 Mode select input 1, Pull-down for normal operation. JTAG serial data input for ARM940T JTAG test mode select for ARM940T VSX-1016V-K...
Page 239
Pin Function No. Pin Name Pin Function P-channel MOS FET drain OUT 1 − Ground FAULT Open-drain FAULT output GND 2 ON (ON) Enable input: 4618 active low, 4618- active high P-channel MOS FET source FAULT 3 ON (ON) VSX-1016V-K...
8. PANEL FACILITIES Front panel (VSX-1016V-K, VSX-1016V-S) AUDIO/VIDEO MULTI-CHANNEL RECEIVER VSX-1016V STANDBY / ON PHASE CONTROL MULTI CH VIDEO LISTENING SIGNAL SB ch SOUND DVD/LD TV/ SAT DVR / VCR1 DVR / VCR2 VIDEO/GAME CD-R / TAPE / MD FM/AM...
Page 241
Use to select an input signal. SBch PROCESSING - Selects the surround back channel mode or virtual surround back mode. SOUND RETRIEVER - Press to restore CD quality sound to compressed audio sources. 10 MASTER VOLUME dial 11 ENTER VSX-1016V-K...
Page 242
Use to select an input signal. SBch PROCESSING - Selects the surround back channel mode or virtual surround back mode. SOUND RETRIEVER - Press to restore CD quality sound to compressed audio sources. 10 MASTER VOLUME dial 11 ENTER 12 PHONES jack VSX-1016V-K...
Page 243
Control input/output 10 Composite and S-video monitor outputs Use to connect other Pioneer components so that you can Use to connect monitors and TVs. → Connecting your TV and DVD player. control all your equipment from a single IR remote sensor.
Page 244
13 Multichannel analog audio inputs 5 Control input/output 7.1 channel inputs for connection to a DVD player with Use to connect other Pioneer components so that you can multichannel analog outputs. → control all your equipment from a single IR remote sensor.
Page 245
Display (VSX-1016V-K, VSX-1016V-S) SIGNAL indicators EON / RDS indicators Light to indicate the currently selected input signal. EON - Lights when the EON mode is set (flashes during AUTO lights when the receiver is set to select the input EON reception). The ? indicator lights when the current signal automatically.
Page 246
TUNER indicators TUNED - Lights when a broadcast is being received. STEREO - Lights when a stereo FM broadcast is being received in auto stereo mode. MONO - Lights when the mono mode is set using the MPX button. VSX-1016V-K...
EFFECT/CH SEL SHIFT EFFECT/CH SEL RECEIVER RECEIVER VSX-1016TXV-K/KUXJ VSX-80TXV/KUXJCA VSX-1016V-K/HYXJ5 VSX-80TXV-S/KUXJCA VSX-1016V-S/HYXJ5 Number buttons and other receiver/component The remote has been conveniently color-coded according controls to component control using the following system (press the Use the number buttons to directly select a radio frequency corresponding input source button to access): or the tracks on a CD, DVD, etc.
Page 248
You can then use the +/– buttons to make STANDARD - Press for Standard decoding and to these adjustments. switch between the various 2 Pro Logic IIx and Neo: 6 options. ADV.SURR - Use to switch between the various VSX-1016V-K...
Diagonosis 21P board to board extension jig GGD1485 cable CLEANING Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools: Position to be cleaned Cleaning tools Fans Cleaning paper : GED-008 VSX-1016V-K...