Page 1
6/12V Battery charger/ starter 67855 set up and Operating instructiOns Visit our website at: http://www.harborfreight.com read this material before using this product. Failure to do so can result in serious injury. saVe this manual. Copyright 2010 by Harbor Freight Tools .
5 < I < 6 6 < I < 8 8 < I < 10 10 < I < 12 12 < I < 14 14 < I < 16 Page 2 For technical questions, please call 1-800-444-3353. SKU 67855...
Page 3
Warning - risK OF eXplOsiVe gases. Working in the vicinity of a lead-acid battery is dangerous. Batteries generate explosive gases during normal battery operation. For this reason, it is of utmost SKU 67855 For technical questions, please call 1-800-444-3353. Page 3...
Determine voltage of battery by enough to weld a ring or a similar referring to car owner’s manual metal object, causing a severe burn. Page 4 For technical questions, please call 1-800-444-3353. SKU 67855...
Stay clear of fan blades, belts, pulleys, and other parts that can cause injury to persons. Check polarity of battery posts. POSITIVE (POS, P, +) battery post SKU 67855 For technical questions, please call 1-800-444-3353. Page 5...
Page 6
2-1/2 hour timer. check battery and time manually; do nOt depend solely on timer. leaving charger/starter unattended can result in property damage. Page 6 For technical questions, please call 1-800-444-3353. SKU 67855...
Page 7
Warning: People with pacemakers should consult their physician(s) before using this product. Electromagnetic fields in close proximity to a heart pacemaker could cause interference to or failure of the pacemaker. SKU 67855 For technical questions, please call 1-800-444-3353. Page 7...
Page 8
Set the Axle along the bottom of the Charger/Starter and Align the Axle Brackets (7) with the mounting holes. Once aligned, fasten the Wheel Axle into place. See Figure 1, above. Page 8 For technical questions, please call 1-800-444-3353. SKU 67855...
Page 9
Warning! Use this charger only on flooded lead-acid batteries. Other batteries may be damaged or may overheat, leak, or catch fire. dO nOt plug this charger in until directed tO dO sO in the FOllOWing pages OF this manual. SKU 67855 For technical questions, please call 1-800-444-3353. Page 9...
Page 10
Turn off vehicle’s engine that is drawn from battery. For example, before removing, replacing, or in 40 amp charge rate a typical discharged charging a battery. battery will initially draw approximately 40 Page 10 For technical questions, please call 1-800-444-3353. SKU 67855...
RC = Reserve Capacity Warning! This Charger/Starter is not automatic and can overcharge and dry up a battery if allowed to operate for extended periods of time. Monitor charging during use. SKU 67855 For technical questions, please call 1-800-444-3353. Page 11...
(short-circuited) and the Engine Starter will power off. Check that cables are connected properly and push the green Start/Reset button to start. Page 12 For technical questions, please call 1-800-444-3353. SKU 67855...
May be the wrong switch position. Reverse connections at Shut off charger and correct cable lead battery. connections. Follow all safety precautions whenever diagnosing or servicing the tool. disconnect power supply before service. SKU 67855 For technical questions, please call 1-800-444-3353. Page 13...
ORIGINAL PRODUCT OR REPLACEMENT PARTS THERETO, OR ARISING OUT OF HIS OR HER INSTALLATION OF REPLACEMENT PARTS THERETO. note: Some parts are listed and shown for illustration purposes only and are not available individually as replacement parts. Page 14 For technical questions, please call 1-800-444-3353. SKU 67855...