Page 1
ICE DISPENSER MODELS: TJ45 TJ90 Operator’ s Manual Distributed By: Commercial Refrigeration Service, Inc. WWW.CorneliusParts.COM WWW.IceCubes.NET (623) 869-8881 (866) 423-6253 Part No. 90614 Revision G THIS DOCUMENT CONTAINS IMPORTANT INFORMATION This Manual must be read and understood before installing or operating this equipment REMCOR INC: PRINTED IN U.S.A...
GENERAL DESCRIPTION The Remcor “ TJ”series of ice dispensers will solve ice and beverage service needs in the sanitary, space saving, economical way. Designed to be manually filled with ice from any remote ice making source, these dispensers will dispense cubes (up 1”in size), cubelets, hard-chipped or cracked ice.
INSTALLATION INSTRUCTIONS * Locate the dispenser indoors on a level counter top, unpack 4 legs and install them into the threaded holes provided in the bottom of the unit. 2. Connect 3/4”IPS (or equal) drain line to the 3/4”threaded drain connections at the lower rear of the unit. This line must pitch downward to an open drain, and must contain no traps, or improper drainage will result.
OPERATOR INSTRUCTION OPERATING INSTRUCTIONS Fill the hopper with ice and replace the lid. Pushing the dispense lever will cause ice to flow from the ice chute. Ice flow will continue until the lever is released. If ice does not dispense, see the “ Troubleshooting Guide”to find the cause CAUTION: Use caution to avoid spilling ice when filling dispenser.
MAINTENANCE The following dispenser maintenance should be performed at the intervals indicated: DAILY or as required Remove foreign material from the vending area sink to prevent drain blockage. WEEKLY or as required Clean vending area. Check for proper water drainage from the vending area sink. MONTHLY Clean and sanitize the hopper interior (see CLEANING INSTRUCTIONS).
TOUBLESHOOTING IMPORTANT: only qualified personnel should service internal components. Should your unit fail to operate properly, check that the electric plug is secure, and that the hopper contains ice. If the unit still does not dispense, check the following chare under the appropriate symptoms to aid in locating the defect.
CAPACITOR TJ-90 ONLY DISPENSE SWITCH (STANDARD) PORTION TIMER PORTION CONTROL DISPENSE (OPTIONAL) SWITCH TO TERMINAL BOARD 7/8-IN SOLENOID ADJUSTMENT WHEN REPLACING SOLENOID AD- JUST TO 7/8” AS SHOWN BEFORE TIGHTENING MOUNTING SCREWS FIGURE 2. WIRING DIAGRAM TJ45, 90 DISPENSER 90614...
REMCOR warrants that all equipment and parts are free from defects in material and workmanship under normal use and service. For a copy of the warranty applicable to your REMCOR product, in your country, please write, fax or telephone the IMI Cornelius office nearest you. Please provide the equipment model number and the date of purchase.
Page 16
Distributed By: Commercial Refrigeration Service, Inc. WWW.CorneliusParts.COM WWW.IceCubes.NET (623) 869-8881 (866) 423-6253 CORPORATE HEADQUARTERS: Remcor Incorporated 500 Regency Drive Glendale Heights, IL 60139 708. 980.6900...