Volvo S40 Owner's Manual page 136

2007 Volvo S40
Refueling
The fuel tank is designed to hold approximately 15.9 US gallons (60 liters)
over to accommodate possible expansion of the fuel in hot weather. Be aware that the "usable" tank
capacity will be somewhat less than the specified maximum. When the fuel level is low, such factors as
ambient temperature, the fuel's "Reid vapor pressure" characteristics, and terrain can affect the fuel
pump's ability to supply the engine with an adequate supply of fuel.
Therefore, it is advisable to refuel as soon as possible when the needle nears the red zone, or when the
fuel warning light comes on.
1
Models with All Wheel Drive have a tank volume of 15 US gallons (57 liters).
Models with engine code 39 have a fuel tank capacity of 14 US gallons (53 liters). This code is the 6th and 7th
digits from the left in your vehicle's VIN number. See
CAUTION
Do not refuel with the engine running
incorrect reading could occur in the fuel gauge
After refueling, close the fuel filler cap by turning it clockwise until it clicks into place.
Avoid overfilling the fuel tank. Do not press the handle on the filler nozzle more than one extra time.
Too much fuel in the tank in hot weather conditions can cause the fuel to overflow. Overfilling could
also cause damage to the emission control systems.
Avoid spilling gasoline during refueling. In addition to causing damage to the environment, gasolines
containing alcohol can cause damage to painted surfaces, which may not be covered under the New
Vehicle Limited Warranty.
Do not use gasolines containing methanol (methyl alcohol, wood alcohol). This practice can result in
vehicle performance deterioration and can damage critical parts in the fuel system. Such damage may
not be covered under the New Vehicle Limited Warranty.
1
If the fuel filler cap is not closed tightly or if the engine is running when the vehicle is refueled, the Check Engine
Light (malfunction indicator lamp) may indicate a fault. However, your vehicle's performance will not be affected.
Use only Volvo original or approved fuel filler caps.
128 06 Starting and driving
Ignition switch/Steering wheel lock
Ignition switch and steering wheel lock
file:///K|/ownersdocs/2007/2007_S40/07s40_06.htm (10 of 40)12/30/2006 5:44:47 PM
page 227 for the location of the VIN plate.
1
. Turn the ignition off or to position I. If the ignition is on, an
1
with sufficient volume left