Hydraulic System; Fuel System - HUSTLER FASTRAK 60 Owner's Manual

Incorrect battery cable routing could cause damage to the
mower and battery cables. This can cause sparks which
can cause a battery gas explosion which will result in per-
sonal injury.
• Always disconnect the negative (black) battery
cable(s) before disconnecting the positive (red)
cable(s).
• Always connect the positive (red) battery cable(s)
before connecting the negative (black) cable(s).
Hustler FasTrak mowers have a master in-line fuse in the
electrical system. This is the main fuse to protect the complete
electrical system. It is located at the right front of the engine
close to the starter. Figure 4-1
Figure 4-1

Hydraulic system

IMPORTANT: Hustler FasTrak mowers are equipped with
two transaxles. Never use hydraulic or automatic transmission
fluid in this system; use only motor oil as specified. Remember,
dirt is the primary enemy of any hydraulic system.
The hydraulic expansion tank is located in front of the engine
and under the operator's platform. Check oil level in hydraulic
system after every 50 hours of operation or weekly, whichever
occurs first. Check more often if system appears to be leaking or
otherwise malfunctioning. Figure 4-2
Fluid level should be at the "Full Cold" line on the expansion
tank. Use only SAE 20W50 SL/SM service motor oil. Figure 4-
2
Initial system oil and filter change must be after the first 75
hours of use or 1 year whichever comes first. Thereafter, replace
filter and oil in each transaxle every 2 years or 200 hours,
whichever comes first. NOTE: The filter guard must be
removed to access filter.
Each transaxle's filter is located per Figure 4-3. A standard oil
filter wrench is used to change filter, threads are right handed.
Use a Hustler approved filter element only.
602900_0211
Master fuse
housing
Right front of engine
When washing the mower, direct the spray away
(especially if using a power washer) from the
transaxle's seals to prevent water intrusion and to
ensure component performance.
Expansion
Transaxle filter

Fuel system

The fuel system for the Hustler FasTrak is EPA compliant.
Use only Hustler approved replacment parts. Do not modify or
tamper with the fuel system. Do not overfill the fuel tanks.
To avoid personal injury or property damage, use
extreme care in handling fuel. Fuel is extremely flam-
mable and the vapors are explosive.
4-3
Transaxle
tank
Figure 4-2
Figure 4-3