Storage; End Of Season Tractor Care; New Season Preparation - HUSTLER 4200 Owner's Manual

End of season tractor care

When storing tractor at end of mowing season, the
following steps should be taken to ensure readiness for the
next mowing season.
1. Remove all grass, dirt, and trash from tractor.
2. If touchup is required order Hustler spray paint (13 oz.
can) from your Hustler dealer.
3. Check thoroughly for any worn or damaged parts that
need replacing and order them from your dealer.
4. Thoroughly lubricate machine, according to
lubrication instructions.
5. Block tractor up so weight is off tires. NOTE: Do not
deflate tires.
6. Protect battery from freezing temperatures.
7. Perform separate engine preparation as listed in engine
owner's manual.
8. Store tractor in a dry place.
728444 Rev. 11/02

STORAGE

New season preparation

Before starting the tractor following post season storage,
the following servicing is required:
1. Clean tractor, removing trash and dirt accumulation.
Check that all worn or damaged parts were replaced.
2. Check engine oil, hydraulic oil and coolant levels.
3. Fill fuel tank with fresh fuel.
WARNING: At start of new season always
check that fresh oil and coolant have been added
to machine. If oil and coolant are drained at
season's end and not replaced, engine damage
will result.
4. Run machine at half-speed for 5 minutes, checking
operation of steering control levers and PTO shaft.
Stop machine and check for oil leaks, loose fittings
and so forth.
5. Tighten any bolts that have loosened and make sure all
hairpins, clevis pins and cotter pins are in place.
6. Install all safety shields and review safety precautions
listed in this manual.
7-1