Maintenance - Spirit XBR95 Owner's Manual

Maintenance:

1. Wipe down all areas in the sweat path with a damp cloth after each workout.
2. If a squeak, thump, clicking or rough feeling develops the main cause is most likely one of two
reasons:
1) The hardware was not sufficiently tightened during assembly. All bolts that were installed
during assembly need to be tightened as much as possible. It may be necessary to use
a larger wrench than the one provided if you cannot tighten the bolts sufficiently. I cannot
stress this point enough; 90% of calls to the service department for noise issues can be
traced to loose hardware.
2) The crank arm nut and/or the pedals need to be retightened.
3. If squeaks or other noises persist, check that the unit is properly leveled. There are 2 leveling
pads on the bottom of the rear stabilizer, use a 14mm wrench (or adjustable wrench) to adjust the
levelers.
Maintenance Menu in console software:
The console has built in maintenance/diagnostic software. The software will allow you to change the
console settings from English to Metric and turn off the beeping of the speaker when a key is pressed
for example. To enter the Maintenance menu (may be called Engineering mode, depending on
version) press and hold down the Start, Stop and Enter keys. Keep holding the keys down for about 5
seconds and the message window will display "ALTXXXX Engineering mode". Press the enter button
to access the menu below:
a. Key test (will allow you to test all the keys to make sure they are functioning)
b. Display test (tests all the display functions)
c. Functions (Press enter to access settings)
iii. ODO reset (reset the odometer)
iv. Units (Set to English or Metric display readings)
vi. D/A test (tests the brake resistance)
vii. Exit
d. Security (Allows you to lock the keypad so no unauthorized use is allowed)
e. Factory settings (Access only allowed by manufacturing)
i. Sleep mode (Turn on to have the console power down automatically after 20
minutes of inactivity)
ii. Pause Mode (Turn on allow 5 minutes of pause, turn off to have the console
pause indefinitely)
v. Beep (Turn on or off the beep when a key is pressed)
32
XBR95 & XBU75