Service manual SC-140 Contents 1 - Main features ................................ 4 1-1 Specifications ..............................4 1-2 Channel table ..............................8 1-3 ATSS sorting method ............................11 2 - Safety instruction ..............................13 3 - Alignment instructions ............................14 3-1 Microcontroller configuration : Service mode ....................14 3-2 Service mode navigation ..........................
Page 3
Service manual SC-140 4-5-2 TDA8358J .............................. 33 4-6 TDA6107Q ................................35 4-7 24C16 - 16 Kb EEPROM ............................ 37 4-8 STR - F6654 ............................... 38 4-8-1 General description ..........................38 4-8-2 Features ..............................38 4-8-3 Block diagram ............................38 4-8-4 Pin description ............................39 4-8-5 Control part - electrical characteristics ....................
Page 4
Service manual SC-140 5-4-1 Introduction............................49 5-4-2 CPU ..............................49 -Controller I/O pin configuration and function 5-4-3 ................50 5-4-4 Tuning ..............................50 5-4-5 Automatic rmat switching and WSS ....................50 5-4-6 EXTERNAL source control logic ......................52 5-4-7 Over Current Protection .
Service manual SC-140 1- Main Features TV standard Sound system Power consumption Sound Output P o w er Speaker Teletext system Aerial input Channel coverage Tuning system V isual screen Channel indication program Selection Aux. terminal Remote Control Unit...
Service Manual SC-140 Specification Matrix Chassis Name SC-140 VCT Version 3834 Software Version Remote Control R46G22 PCB Serial Number 4859809424 Tube 16:9 FST / 16:9 Real Flat SVHS 3 “picture Improvements, Comb Filter, Horizontal Scaler” Teletext Split Screen Formats Available in Video Mode Atuo / 4:3 / 14:9 / Zoom 14:9/ Zoom 16:9 / Full Screen AV2 Monitor Output MSP Version (Option) 3410...
Page 7
Service manual SC-140 Signal Description Matching value Signal Description Matching value...
Page 9
Service manual SC-140 FREQUENCY TABLE EUROPE CCIR FRANCE GB(IRELAND) EAST OIRT...
Page 10
Service manual SC-140 EUROPE CCIR FRANCE GB(IRELAND) EAST OIRT...
Page 11
Service manual SC-140 EUROPE CCIR FRANCE GB(IRELAND) EAST OIRT...
Page 12
Service manual SC-140 Group I Group II Group III Group IV Program Program Group Skip Group Skip number number Country selection = Others France...
Page 13
Service manual SC-140 France Switzerland...
Service Manual SC-140 2. Safety instruction WARNING : Only Competent Service personnel may carry out work involving the testing or repair of this equipment. X-RAY RADIATION PRECAUTION 1. Excessive high voltage can produce petentially hazardous X-RAY RADIATION. To avoid such hazards, the high voltage must not exceed the specified limit.
Page 18
Service manual SC-140 CORNER EW TRAPEZ 3-4-8- AGC - Adjust the antenna signal level at 70 dB V 2 - Tune a colour bar pattern. - Find the “ A GC” item in service mode. - Adjust AGC volume ( RB10 ) to bring the cursor to central position : 32.
Page 22
Service manual SC-140 IC version VCT 3832A VCT 3834A Chassis OSD languages Text ATSS countries IC marking PSDIP Pin Name Short Description Type 64-pin...
Page 23
Service manual SC-140 PSDIP Pin Name Type Short Description 64-pin...
Page 24
Service manual SC-140 Power S/B 5V MUTE MOD SW SECAM L AFC/RES RESET XTAL in SC1 SW OSC GND SC2 SW Vout S/B 3.3V SGND Cb in C in XREF Cr in IF-IN SC1-IN SC2-IN B out RCA VIN G out TEST R out H out...
Service manual SC-140 4-2-1- Basic Features of the MSP 341x 4-2-1-1 Demodulator and NICAM Decoder Section...
Page 26
Service manual SC-140 4-2-1-2 DSP-Section (Audio Baseband Processing) 4-2-1-3 Analogue Section 4-2-1-4 NICAM plus FM/AM-Mono 4-2-1-5 German 2-Carrier System (DUAL FM System)
Page 58
Service manual SC-140 5-9 Power supply (STR F6654) 5-9-1 STR-F6654 general description The STR-F6654 is an hybrid IC with a build-in MOSFET and control IC, designed for flyback converter type switch mode power supply applications. 5-9-2 Power supply primary part operations An oscillator generates pulses signals which turn on and off a MOSFET transistor.
Page 59
Service manual SC-140 When the power switch is pushed on, V increases slowly. During this time, C806 is charged through R802. As soon as V reaches 16V, the STR-F6654 control circuit starts operating. Then, V is obtained by smoothing the winding voltage which appears between pin6 and pin7 of the SMPS transformer.
Page 60
Service manual SC-140 5-9-2-2 STR-F6654 oscillating operation...
Page 61
Service manual SC-140 overcurrent protection function (OCP) • la tch circuit ther mal shutdown circuit (TSD) o vervoltage protection circuit (OVP)
Service manual SC-140 5-10 TV start-up, TV normal run and stand by mode operations 5-10-1 TV start-up operations * Schematic diagram for start-up operations * TV start-up and microcontroller initialisation - When SW801 power switch is pushed, main AC voltage is applied to T801 transformer (after rectification by D801... D804 diodes).
Service manual SC-140 On normal run mode, I501 microcontroller pin 1 (power) is set to high So, I810 controlled rectifier is not conducting - Q809 is conducting. So, Q808 is not conducting and Q807 is conducting - So, Q807 collector is connected to the ground and I810 controlled rectifier gate pin is set to low (no conducting) So, current from 14V DC voltage (from T801 SMPS transformer pin 13) does not flow through Q811 and Q810 transistors but flows through I806 IC error amplifier...
Page 67
Service manual SC-140 I810 CONTROLLED RECTIFIER 6V DC HIGH R829 R830 R820 C830 HIGH Q807 Q808 HIGH POWER Q809 Fig : I810 controlled rectifier switching circuit * TV set stand-by mode operations - On stand-by mode, I501 microcontroller pin 1 (power) is set to low. - So, Q809 collector is set to high.
Page 68
ZZ100 48B4846G22 TRANSMITTER REMOCON R-46G22 (AAA) C812 CH1BFE472M C CERA AC AC400V 4700PF M U/C/V ZZ120 PEBCSHD034 COVER BACK AS DSC-3210E C813 CEXF2E101V C ELECTRO 250V RSS 100MF 18X35.5 M211 4952101201 COVER BACK HIPS C840 CEXF1C222V C ELECTRO 16V RSS 2200MF (16X31.5) TP...
Page 69
TT2 WAS 3X12 MFZN BK C997 CEXF2E100V C ELECTRO 250V RSS 10MF (10X20) TP M682 4856816300 CLAMP WIRE NYLON 6 (V0) ZZ200 PEMPJBD034 PCB MAIN M-10 AS DSC-3210E P102 485923162S CONN WAFER YW025-03 (STICK) E002 4856310600 EYE LET BSR T0.2 (R2.3) P401 4950704023 CONNECTOR...
Page 70
R FUSIBLE 1W 2.7 OHM J (TAPPING) C612 CEXF1H109V C ELECTRO 50V RSS 1MF (5X11) TP ZZ200 PEMPJRD034 PCB MAIN RADIAL AS DSC-3210E C613 CEXF1H109V C ELECTRO 50V RSS 1MF (5X11) TP C102 CEXF1H470V C ELECTRO 50V RSS 47MF (6.3X11) TP...
Page 71
FILTER EMI CFI 06 B 1H 470PF CA03 CCZB1H101K C CERA 50V B 100PF K (AXIAL) ZZ200 PEMPJAD034 PCB MAIN AXIAL AS DSC-3210E CA04 CCZB1H102K C CERA 50V B 1000PF K (AXIAL) A001 4959809424 PCB MAIN 330 X 246 CA07...
Page 72
Service manual SC-140 z_loc z_parts_code parts_name parts_descr z_loc z_parts_code parts_name parts_descr CA16 CCZB1H102K C CERA 50V B 1000PF K (AXIAL) D997 DLT2A05G— DIODE LT2A05G (TP) CA17 CCZB1H102K C CERA 50V B 1000PF K (AXIAL) DA03 DUZ5R1BM— DIODE ZENER UZ-5.1BM CA18 CCZB1H102K C CERA 50V B 1000PF K (AXIAL)
Page 73
Service manual SC-140 z_loc z_parts_code parts_name parts_descr z_loc z_parts_code parts_name parts_descr J803 85801065GY WIRE COPPER AWG22 1/0.65 TIN COATING L504 5CPZ479K02 COIL PEAKING 4.7UH K (AXIAL 3.5MM) J826 85801065GY WIRE COPPER AWG22 1/0.65 TIN COATING L601 5CPZ479K02 COIL PEAKING 4.7UH K (AXIAL 3.5MM) J827 85801065GY WIRE COPPER...
Page 74
Service manual SC-140 z_loc z_parts_code parts_name parts_descr z_loc z_parts_code parts_name parts_descr R398 RD-2Z109J- R CARBON FILM 1/2 1 OHM J R588 RD-AZ101J- R CARBON FILM 1/6 100 OHM J R401 RD-4Z272J- R CARBON FILM 1/4 2.7K OHM J R589 RD-AZ330J- R CARBON FILM 1/6 33 OHM J R402...
Page 75
RD-AZ223J- R CARBON FILM 1/6 22K OHM J R807 RD-2Z272J- R CARBON FILM 1/2 2.7K OHM J ZZ300 PEUNSWD034 PCB UNION AS DSC-3210E R808 RD-2Z821J- R CARBON FILM 1/2 820 OHM J 2193102005 SOLDER BAR SN:PB=63:47 S63S-1320 R810 RD-4Z102J- R CARBON FILM...
Page 76
Service manual SC-140 z_loc z_parts_code parts_name parts_descr z_loc z_parts_code parts_name parts_descr R902 RD-AZ472J- R CARBON FILM 1/6 4.7K OHM J R903 RD-AZ750J- R CARBON FILM 1/6 75 OHM J R904 RD-AZ750J- R CARBON FILM 1/6 75 OHM J...
Page 77
PE FILM PART CODE PART NAME MATERIAL REMARKS Designed by Checked by Inspected by Approved by PART NAME UNITS HJLEE HJLEE BKCHOI BKCHOI EXPLODED VIEW SCALE 02.02.15 02.02.15 02.02.15 02.02.15 MODEL DSC-3210E Daewoo Electronics CO.,LTD. Digital TV Research Center REFERENCE -76-...
Page 78
Service manual SC-140 8- PCB Layout -77-...
Page 79
Service manual SC-140 9- Schematic Diagram -78-...