For Your Safety Read Before Operating - Weil-McLain CGa User's Information Manual

CGa, CGi, CGs, EG, EGH, LGB, PEG, PFG Boilers
Operating instructions
• Spark-ignited pilot
• Gas valve — Honeywell VR8204/VR8304

FOR YOUR SAFETY READ BEFORE OPERATING

A. This appliance is equipped with an ignition device
which automatically lights the pilot.
to light the pilot by hand.
BEFORE OPERATING
B.
appliance area for gas. Be sure to smell next to the
floor because some gas is heavier than air and will
settle on the floor. See below.
• Do not try to light any appliance.
• Do not touch any electric switch; do not use any phone in
your building.
STOP!
1. Read the safety information above on this label.
2. Set the thermostat to lowest setting.
3. Turn off all electrical power to the appliance.
4. Remove from panel.
5. This appliance is equipped with an ignition device which
automatically lights the pilot.
by hand.
6. Turn gas control knob clockwise
1. Set the thermostat to lowest setting.
2. Turn off all electric power to the appliance if service is to
be performed.
16
If you do not follow these instructions exactly, a fire or explosion may result
causing property damage, personal injury or loss of life.
C. Use only your hand to turn the gas control knob. Never use tools. If
Do not
try
, smell all around the
D. Do not use this appliance if any part has been under water.
WHAT TO DO IF YOU SMELL GAS
OPERATING INSTRUCTIONS
Do not try to light the pilot
"OFF" .
to
TO TURN OFF GAS TO THE APPLIANCE
CGa, EG-30 to EG-75,
PEG-30 to PEG-55,
PFG-5
the knob will not turn by hand, don't try to repair it, call a qualified
service technician. Force or attempted repair may result in a fire or
explosion.
Immediately call a qualified service technician to inspect the appliance
and to replace any part of the control system and any gas control,
which has been under water.
• Immediately call your gas supplier from a neighbor's phone.
Follow the gas supplier's instructions.
• If you cannot reach your gas supplier, call the fire
department.
7. Wait five (5) minutes to clear out any gas. Then smell for
gas, including near the floor. If you smell gas,
"B" in the safety information above. If you don't smell gas,
go to the next step.
8. Turn gas control knob counterclockwise
9. Turn on all electric power to the appliance.
10. Set thermostat to desired setting.
11. If the appliance will not operate, follow the instructions
To Turn Off Gas To The Appliance
technician or gas supplier.
12. Replace front panel.
3. Remove front panel.
4. Turn gas control knob clockwise
5. Replace front panel.
STOP! Follow
to "ON" .
and call your service
to "OFF" . Do not force.
550-223-041(0906)
Part Number 550-110-592/0709