Char-Broil 463250710 Product Manual

Char-broil red

Table of Contents

Quick Links

Download this manual

The following are trademarks registered by W.C. Bradley Co. in the U.S. Patent and Trademark Office: Caldera®; Charcoal2Go®; Char-Broil®; America's Legendary

Barbeque Company®; American Gourmet®; Bandera®; Brush Hawg®; CB 940®; Char-Diamonds®; Char-Broil Charcoal/Gas®; Everybody Grills®; Everybody

Outside®; FastStart®; Grill 2 Go®; Grill 2 Go® Express®; Grill Lovers®; Infrared Grilling That's All About U®; Keepers of the Flame®; New Braunfels Smoker

Company®; Patio Bistro®; Patio Caddie®; Patio Kitchen®; Pro-Sear®; RED®; Quantum®; Santa Fe®; Sear and Grill®; Sierra®; Signature Series®; Sure2Burn®;

The Big Easy®; Trentino®; U®; Wild West Tradition®; and the following marks:

The following are trademarks of W.C. Bradley Co.: Advantage Series™; Auto-Clean™;Chef Tested™; Commercial Series™; Designer Series™;; Diamond Flame™;

Double Chef™; Fireball™; Firenzy™; FlavorMaster™;Front Avenue™; Grill 2 Go® Advantage™; Hog and Yard Bird™; H20 Smoker™; Infrared. Grilling's Juicy Little

Secret™; Incredible Taste. Infallible Results™; Infrared Inside™; Insure™; Let's Grill Something Together™; Lev-Alert™; Longhorn™; Magneto™; Precision

Flame™; Quick2Burn™; QuickSet™; Ready When You Are™; Season, Set, And Savor™; Sizzle On The Grill™; Signature Series™; SureFire™; The Minute

Grill™;Torchfork™; Universal Grill Parts™; You Bring the Party™

Protected under one or more of the following U.S. Patents: 5,421,319; 5,458,309; 5,579,755; 5,996,573; 6,135,104; 6,279,566; 6,331,108; 6,484,900; 6,526,876; 6,595,197; 6,640,799; 6,640,803; 6,729,873; 6,739,473; 6,749,424; 6,792,935; 6,951,213; 7,047,590;

7,516,693; D364,535; D372,637; D373,701; D377,735; D383,035; D397,910; D405,643; D406,005; D406,009 ; D413,043; D413,229; D414,982; D415,388; D416,164; D416,441; D417,587; D417,588; D422,516; D423,274; D423,876; D428,303; D430,772; D435,396;

D436,004; D438,059; D438,060; D438,427; D439,110; D442,505; D443,179; D443,354; D443,464; D447,384; D447,385; D447,909; D448,610; D448,614; D448,615; D448,616; D448,975; D449,492; D450,544; D451,759; D454,028; D454,031; D455,205; D455,206;

D456,202; D456,222; D456,223; D457,789; D458,520; D458,760; D458,802; D459,088; D459,148 D459,149; D459,161; D459,163; D459,586; D459,943; D460,312; D460,313; D460,318; D461,359; D465,123; D465,693; D466,307; D466,439; D466,752; D473,414;

D474,371; D477,498; D477,501; D477,504; D477,506; D477,746; D478,471; D478,472; D480,914; D491,410; D494,009; D494,413; D498,523; D500,359; D504,048; D530,098; D535,000; Canada:D97,504;D99,355; D102,037; D104,200;D108,377; 2,315,567;

TEC™ is a trademark of Tec Infrared Grills.

Printed in China

PRODUCT GUIDE

MODEL 463250710

IMPORTANT: Fill out the product record information below.

Serial Number

See rating label on grill for serial number.

Date Purchased

For support and to register your

grill, please visit us at

www.charbroil.com

If you have questions or need

assistance during assembly,

please call 1-888-430-7870.

Estimated assembly time: 30 minutes

1/13/10 • G616-001-030801

Table of Contents

Summary of Contents for Char-Broil 463250710

Page 1 Estimated assembly time: 30 minutes The following are trademarks registered by W.C. Bradley Co. in the U.S. Patent and Trademark Office: Caldera®; Charcoal2Go®; Char-Broil®; America's Legendary Barbeque Company®; American Gourmet®; Bandera®; Brush Hawg®; CB 940®; Char-Diamonds®; Char-Broil Charcoal/Gas®; Everybody Grills®; Everybody Outside®;...
Page 2: Table Of Contents
TABLE OF CONTENTS DANGER For Your Safety ........2-3 If you smell gas: Use and Care .
Page 3 WARNING CAUTION CALIFORNIA PROPOSITION 65 Using pots larger than 6 quarts in capacity could exceed weight limit of the 1. Combustion by-products produced when using this product contain chemicals known to the State of side burner shelf California to cause cancer, birth defects, and other or side shelf, reproductive harm.
Page 4: Use And Care
LP Cylinder USE AND CARE •The LP cylinder used with your grill must meet the following requirements: DANGER •Use LP cylinders only with these required measurements: 12" (30.5cm) (diameter) x 18" (45.7 cm) (tall) with 20 lb. (9 kg.) capacity maximum. •...
Page 5: For Your Safety
LP Cylinder Exchange Connecting Regulator to the LP Cylinder •Many retailers that sell grills offer you the option of replacing 1.LP cylinder must be properly secured onto grill. (Refer to your empty LP cylinder through an exchange service. Use only assembly section.) those reputable exchange companies that inspect, precision fill, 2.Turn all control knobs to the OFF position.
Page 6 Leak Testing Valves, Hose and Regulator 1.Turn all grill control knobs to OFF. 2.Be sure regulator is tightly connected to LP cylinder. 3.Completely open LP cylinder valve by turning hand wheel counterclockwise. If you hear a rushing sound, turn gas off immediately.
Page 7 Safety Tips WARNING  Before opening LP cylinder valve, check the coupling nut for tightness.  When grill is not in use, turn off all control knobs and LP For Safe Use of Your Grill and to Avoid Serious cylinder valve. ...
Page 8 Burner Flame Check WARNING •Remove cooking grates and troughs. Light burners, rotate knobs from . You should see a smaller flame in position than seen on . Perform burner flame check Turn controls and gas source or tank OFF when not on sideburner, also.
Page 9: Spider Alert
Cleaning the Burner Assembly CAUTION Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting grill. 1. Turn gas OFF at control knobs and LP cylinder. 2. Remove cooking grates and flame tamers. SPIDER ALERT! 3.
Page 11: Limited Warranty
LIMITED WARRANTY This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase*.
Page 12: Parts List
PARTS LIST Description Qty Description TOP LID WELDMENT, OUTER CONDIMENT TRAY, F/ DOOR TOP LID, INNER LINER DOOR, RIGHT, NO HANDLE LOGO PLATE, W/ TEMP GAUGE TROUGH ASSY HANDLE END, TOP LID TROUGH MIDDLE BRACKET HANDLE, TOP LID WARMING RACK RUBBER BUMPER, RECTANGLE, F/ TOP COOKING GRATE SIDEBURNER SHELF...
Page 13: Parts Diagram
PARTS DIAGRAM...
Page 14: Assembly
ASSEMBLY Right and Left Shelf Assembly Attach two 1/4-20x3/4” screws, 7mm flat washers and 7mm 1/4-20x3/4” Screw lock washers through side shelf holes (right shelf ONLY) into 7mm Flat Washer towel bar shown A. 7mm Lock Washer Insert side shelf over screws and washers through bracket shown B.
Page 15 Place sideburner lid onto left shelf and align hinge holes in back of lid with shelf holes. Secure lid to the shelf using four 4mm flat washers, 4mm lock washers, and #8-32 hex nuts, shown A. #8-32x3/8” screws, Remove the two screws and lock washers factory attached to the sideburner valve bracket. Position sideburner valve bracket beneath sideburnder shelf fascia so that valve stem comes through larger center hole in fascia.
Page 16 Insert sideburner burner into left shelf. The stud on bottom of burner fits into rear small hole in sideburner drip pan on shelf, shown A. Secure burner to sideburner drip pan with one Wing nut, shown B. Under sideburner shelf, attach sideburner ignitor wire to electrode. Make sure burner tube engages sideburner valve, shown C.
Page 17 Place temperature probe to the clamp on the right side panel, shown A. Make the tank gauge wire go through the hole on the right side shelf and insert to the tank gauge, shown A/B. Temperature probe Clamp Tank gauge wire Tank gauge wire...
Page 18 Place sideburner cooking grate onto side burner shelf, Place griddle onto side burner shelf. Make sure the griddle pins are put into the holes on the shelf. Side burner Cooking Grate Place the Condiment Basket on the Left door inside, make sure insert the legs of the Condiment Basket into the brackets which were attached on the door inside shown as below.
Page 19 First, place Trough Middle onto Firebox show A. Second, place two Trough Assy onto Firebox. Align trough pins with the holes on firebox. Make sure they are put in the right direction as show in B. Trough Middle Trough Assy Trough Middle...
Page 20 Place cooking grates onto the firebox as shown. Place the warming rack onto the the firebox.Make sure insert the warming rack ends into the holes properly shown as below. Warming rack Cooking Grate...
Page 21 LP Tank LP TANK IS SOLD SEPARATELY. Fill and leak check the tank before attaching to grill and regulator (see Use & Care section). Once tank has been filled and leak checked, place cylinder into the tank tray in bottom shelf. Make sure tank valve is facing front of grill.
Page 22 Unscrew battery cap on left side panel. Insert AA battery into ignitor, negative (—) end first. Replace button. Battery Cap Battery Positive(+) side up towards Cap...
Page 23: Troubleshooting
EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Possible Cause Prevention/Solution...
Page 24 Troubleshooting (continued) Problem Possible Cause Prevention/Solution Burner(s) will not light •Faulty electronic ignition circuit. •See Troubleshooting Integrated Electronic Ignition section. using ignitor. •Sparking somewhere other than •Inspect wire insulation and proper connections. Replace wires if between burner and electrode. insulation is broken. Burner(s) will not •See “GAS ISSUES:”...
Page 25 Troubleshooting - Integrated Electronic Ignition Problem (Ignition) Possible Cause Check Procedure Prevention/Solution SECTION I •Battery not installed •Check battery orientation. •Install battery (make sure that “+” and “–” No sparks appear at properly. connectors are oriented correctly, with “+” end up any electrodes when burner control knobs and “–”...
Page 26 NOTES...
Page 27: Registration Card
Warranty Registration Department P.O. Box 1240 Columbus, GA 31902-1240...

This manual is also suitable for:

Red 463250710

Char-Broil 463250710 Product Manual

Quick Links

Related Manuals for Char-Broil 463250710

Summary of Contents for Char-Broil 463250710

This manual is also suitable for:

Table of Contents