Antunes, AJ TBS-1X Owner's Manual page 18

TACO BELL STEAMER TBS-2X & TBS-1X
Item Part Description
No.
1 0011229 Top Cover Assy.
0011198 Top Cover Assy.
2 7000150 Calibration Kit
3 2100250 Guard, Knob, Top Cover
4 0503087 Cover, Control Housing
0503226 Cover, End Housing
5 2100247 Knob
6 0503085 Cover, Generator
7 0503592 Diffuser
8 0300129 Stud
9 7000430 Generator Kit,
(Incl. # 7, 8, 49, 56 &
Qty. 3 of 55 & Qty 2 of 27)
10 4010137 Rocker Switch, Power On/Off
11 0021110 Corner Filler
12 4060363 Indicator Light, Yellow,
(Steaming Light)
13 4060362 Indicator Light, Green
(Ready Light)
14 4010166 Switch, Cycle Start
15 0503315 Liner, Cavity
16 0020341 Spatula
17 2100249 Guard, Handle
18 2100107 Handle
19 210K230 Bumper Recess 1" Leg Kit
(Incl. parts for 4 legs)
210K123 4" Leg Kit (Incl 1 leg)
210K134 4" Leg Kit (Incl. 4 legs)
20 7000160 Control Board Kit
21 4050135 Thermocouple Assy.
22 7000156 Audio Alarm Kit
23 4040145 Solenoid Valve, 24 VAC
24 2000202 Tube, Inlet
25 2000203 Tube, Restrictor
26 4030222 Hi-limit Thermostat
27 2190107 Pipe, Teflon (see Note 2)
28 2080117 Connector,
Quick Disconnect Female
29 7000139 Connector,
Quick Disconnect Male
30 405K125 Relay, Solid State
REPLACEMENT PARTS (continued)
Qty.
TBS-1X TBS-2X
1
1
1 1
1 2
1 2
1
1 2
1 2
1 2
1 2
1 2
1 2
4 4
1 2
1 2
1 2
1 2
1 2
1 2
1 2
1 1
4 4
1 1
1 2
1 2
1 2
1 2
1 2
1 2
1 2
2 4
1 2
1 2
1 2
Item Part Description
No.
31 4050180 Heat Sink
32 0700452 Power Cord
33 040K251 Strain Relief
35 0021133 Chimney
0021136 Chimney
36 0700554 Wire Set (not shown)
37 7000136 Terminal Block Kit
(Includes 38, 50, & 51)
38 100P967 Label, Marking
39 2040146 Tee, Female
40 2040145 Elbow, Female
41 7000319 Transformer
42 0503093 Retainer, Thermocouple
43 1000975 Label, Control Panel
44 0503171 Bracket, Mounting
45 2040103 Valve Connector
46 308P103* Screw, #8-32 x 1/4"
47 308P105* Screw, #8-32 x 1/2"
48 308P104* Screw, #8-32 x 3/8"
49 306P136* Screw, #8-32 x 5/8"
50 306P123* Screw, Stainless Steel,
#6-32 x 7/8"
51 306P101* Nut, Hex, #6-32
52 308P143* Nut, Hex, KEPS, #8-32
53 3048105* Nut, Hex, Zinc, #4-40
54 300P102* Nut, Tinnerman, #8-32
55 306P134 Screw, #6-32 x 3/8"
56 325P170* Wingnut, Cast Iron, 1/4"-20
57 020P117* O-ring
58 362P102* Lock washer, Toothed
60 7000299 Nut (3-Pak) See Note 1
* Only available in packages of 10.
NOTE 1: This special wrench nut is required to
separate the stem from the solenoid valve on older
solenoid valves
NOTE 2: Always use Teflon® tape on threads and
tighten until very snug.
18
Qty.
TBS-1X TBS-2X
1 2
1 2
1 2
1 1
1 1
1 2
1 2
1 2
1 2
1 2
1 2
1 2
1 2
1 2
1 2
1 1
1 1
1 1
1 1
1 1
1 1
1 1
1 1
1 1
3 3
1 1
1 1
1 1
1 1
P/N 1010698 Rev. E 03/04