Table of Contents
Advertisement
User's Information Guide
Noncondensing Gas Furnaces
Upflow / Horizontal and Downflow / Horizontal
WARNING:
If the information in this manual
is not followed exactly, a fire or explosion may
result causing property damage, personal in-
jury or loss of life.
— Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS
•
Do not try to light any appliance.
•
Do not touch any electrical switch;
do not use any phone in your build-
ing.
•
Immediately call your gas supplier
from a neighbor's phone. Follow the
gas supplier's instructions.
•
If you cannot reach your gas sup-
plier, call the fire department.
— Installation and service must be per-
formed by a qualified installer, service
agency or the gas supplier.
© American Standard Inc. 2001
WARNING:
unit before removing the blower door. Failure to
follow this warning could result in property damage,
personal injury or death.
▲
WARNING:
HIGH VOLTAGE ELECTRICAL COMPONENTS, FAST MOVING FANS,
AND COMBUSTIBLE GAS. FOR PROTECTION FROM THESE
INHERENT HAZARDS DURING INSTALLATION AND SERVICING,
THE ELECTRICAL SUPPLY MUST BE DISCONNECTED AND THE
MAIN GAS VALVE MUST BE TURNED OFF. IF OPERATING CHECKS
MUST BE PERFORMED WITH THE UNIT OPERATING, IT IS THE
TECHNICIANS RESPONSIBILTY TO RECOGNIZE THESE HAZARDS
AND PROCEED SAFELY.
▲
WARNING:
ANY PART HAS BEEN UNDER WATER. IMMEDIATELY
CALL A QUALIFIED SERVICE TECHNICIAN TO
INSPECT THE FURNACE AND TO REPLACE ANY
PART OF THE CONTROL SYSTEM AND ANY GAS
CONTROL WHICH HAS BEEN UNDER WATER.
32- 5034- 2
Disconnect power to the
BODILY INJURY CAN RESULT FROM
DO NOT USE THIS UNIT IF
Pub. No. 32-5034-02
Advertisement
Table of Contents
Related Manuals for American Standard Noncondensing Gas Furnaces
Summary of Contents for American Standard Noncondensing Gas Furnaces
- Page 1 — Installation and service must be per- formed by a qualified installer, service agency or the gas supplier. © American Standard Inc. 2001 WARNING: Disconnect power to the unit before removing the blower door. Failure to follow this warning could result in property damage, personal injury or death.
-
Page 2: Fire Or Explosion Hazard
Any attempt to repair a central air condi- tioning product may result in personal injury and/or prop- erty damage. American Standard Inc. or seller cannot be responsible for the interpretation of this information, nor can it assume any liability in connection with its use. - Page 3 Filter maintenance reduces energy use. WARNING: Disconnect power to the unit before removing the blower door. Failure to follow this warning could result in property damage, personal injury or death. A clean filter saves money. When the furnace circulates and filters the air in your home, dust and dirt particles build up on the filter.
-
Page 4: Upflow / Horizontal Furnace Filters
Filter Rack Assembly The filter rails are spring loaded for automatic adjustment to allow standard size, locally obtainable replacement filters. The filter rack itself slides to adjust to the required width needed for bottom or side return. Always insert the chamfer (angle edged sides) end first. -
Page 5: Downflow Filter
FACTORY SUPPLIED UPFLOW FURNACE RETURN AIR FILTERS UPFLOW FURNACE RETURN AIR FILTERS CABINET CABINET QTY* WIDTH BOTTOM FILTER 14-1/2" 14" X 25" X 1" 17-1/2" 17" X 25" X 1" 21" 20" X 25" X 1" 24-1/2" 24" X 25" X 1" *NOTE - On 5 or 6 ton airflow models, if the airflow requirement exceeds 1800 CFM, these models will require filters on both sides;... -
Page 6: The Problem Solver
The problem solver. A furnace is not a household appliance. It is complex and requires professional maintenance and repair. That’s why attempts at “do-it-yourself” repairs on an in- warranty unit may void the remainder of your warranty. Other than performing the simple maintenance recom- mended in this manual, you should not attempt to make any adjustments to your furnace. -
Page 7: Maintenance Information
Maintenance information. Never stop the cooling system by shutting off the main power. If the main power to your air conditioner is ever discon- nected for more than three hours, turn off the thermostat. Then wait for at least three more hours after the power has been restored before turning the thermostat back on. - Page 8 WARNING: Disconnect power to the unit before removing the blower door. Failure to follow this warning could result in property damage, personal injury or death. ▲ WARNING: DO NOT USE THIS UNIT IF ANY PART HAS BEEN UNDER WATER. IMMEDIATELY CALL A QUALIFIED SERVICE TECHNICIAN TO INSPECT THE FURNACE AND TO REPLACE ANY PART OF THE CONTROL SYSTEM AND ANY GAS...
- Page 9 To light furnace. WARNING: FIRE OR EXPLOSION HAZARD Failure to follow the safety warnings exactly could result in serious injury, death or property damage. Never test for gas leaks with an open flame. Use a com- mercially available soap solution made specifically for the detection of leaks to check all connections.
-
Page 10: Limited Warranty
High Efficiency Induced Draft Gas Furnace This limited warranty is extended by American Standard Inc., to the original purchaser and to any succeeding owner of the real property to which the Gas Furnace is originally affixed, and applies to products purchased and retained for use within the U.S.A. -
Page 11: Precautionary Measures
The following warning complies with State of California law, Proposition 65. WARNING: This product contains fiberglass wool insulation! Fiberglass dust and ceramic fibers are be- lieved by the state of California to cause cancer through inhalation. Glasswool fibers may also cause respiratory, skin, or eye irritation. - Page 12 American Standard Inc. 6200 Troup Highway Tyler, TX 75711-9010 Page 12 Since the manufacturer has a policy of continuous product and product data improvement, it reserves the right to change design and specifications without notice. Pub. No. 32-5034-02...
-
Page 13: User's Information Guide
— Installation and service must be per- formed by a qualified installer, service agency or the gas supplier. © American Standard Inc. 2001 WARNING: Disconnect power to the unit before removing the blower door. Failure to follow this warning could result in property damage, personal injury or death. - Page 14 Any attempt to repair a central air condi- tioning product may result in personal injury and/or prop- erty damage. American Standard Inc. or seller cannot be responsible for the interpretation of this information, nor can it assume any liability in connection with its use.
- Page 15 Filter maintenance reduces energy use. WARNING: Disconnect power to the unit before removing the blower door. Failure to follow this warning could result in property damage, personal injury or death. A clean filter saves money. When the furnace circulates and filters the air in your home, dust and dirt particles build up on the filter.
- Page 16 Filter Rack Assembly The filter rails are spring loaded for automatic adjustment to allow standard size, locally obtainable replacement filters. The filter rack itself slides to adjust to the required width needed for bottom or side return. Always insert the chamfer (angle edged sides) end first.
- Page 17 FACTORY SUPPLIED UPFLOW FURNACE RETURN AIR FILTERS UPFLOW FURNACE RETURN AIR FILTERS CABINET CABINET QTY* WIDTH BOTTOM FILTER 14-1/2" 14" X 25" X 1" 17-1/2" 17" X 25" X 1" 21" 20" X 25" X 1" 24-1/2" 24" X 25" X 1" *NOTE - On 5 or 6 ton airflow models, if the airflow requirement exceeds 1800 CFM, these models will require filters on both sides;...
- Page 18 The problem solver. A furnace is not a household appliance. It is complex and requires professional maintenance and repair. That’s why attempts at “do-it-yourself” repairs on an in- warranty unit may void the remainder of your warranty. Other than performing the simple maintenance recom- mended in this manual, you should not attempt to make any adjustments to your furnace.
- Page 19 Maintenance information. Never stop the cooling system by shutting off the main power. If the main power to your air conditioner is ever discon- nected for more than three hours, turn off the thermostat. Then wait for at least three more hours after the power has been restored before turning the thermostat back on.
- Page 20 WARNING: Disconnect power to the unit before removing the blower door. Failure to follow this warning could result in property damage, personal injury or death. ▲ WARNING: DO NOT USE THIS UNIT IF ANY PART HAS BEEN UNDER WATER. IMMEDIATELY CALL A QUALIFIED SERVICE TECHNICIAN TO INSPECT THE FURNACE AND TO REPLACE ANY PART OF THE CONTROL SYSTEM AND ANY GAS...
- Page 21 To light furnace. WARNING: FIRE OR EXPLOSION HAZARD Failure to follow the safety warnings exactly could result in serious injury, death or property damage. Never test for gas leaks with an open flame. Use a com- mercially available soap solution made specifically for the detection of leaks to check all connections.
- Page 22 High Efficiency Induced Draft Gas Furnace This limited warranty is extended by American Standard Inc., to the original purchaser and to any succeeding owner of the real property to which the Gas Furnace is originally affixed, and applies to products purchased and retained for use within the U.S.A.
- Page 23 The following warning complies with State of California law, Proposition 65. WARNING: This product contains fiberglass wool insulation! Fiberglass dust and ceramic fibers are be- lieved by the state of California to cause cancer through inhalation. Glasswool fibers may also cause respiratory, skin, or eye irritation.
- Page 24 American Standard Inc. 6200 Troup Highway Tyler, TX 75711-9010 Page 12 Since the manufacturer has a policy of continuous product and product data improvement, it reserves the right to change design and specifications without notice. Pub. No. 32-5034-02...