Summary of Contents for MULTIQUIP Power Ultra-Silent DCA-70SSIU
Page 1
PARTS AND OPERATION MANUAL OPERATION AND PARTS MANUAL ULTRA-SILENT SERIES MODEL DCA-70SSIU 60 Hz GENERATOR PARTS LIST NO. M2870300504 Revision #1 (01/06/09) THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
DANGER - ELECTROCUTION HAZARDS During operation of this generator, there exists the possibility of electrocution, electrical shock or burn, which can cause severe bodily harm or even DEATH! PAGE 8 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
This generator, other property, or the surrounding environment NOTE could be damaged if you do not follow instructions. DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 9...
Unauthorized equipment modification will void all warranties. ■ Whenever necessary, replace nameplate, operation and safety decals when they become difficult read. PAGE 10 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
Page 11
■ NEVER power cables or cords lay in wate r. ■ NEVER stand in water while AC power from the generator is being transfer to a load. DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 11...
Page 12
PAGE 12 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
Page 13
■ DOT Requirements include the following: Connect and test electric brake operation. Secure portable power cables in cable tray with tie wraps. DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 13...
DCA-70SSIU (60 Hz) — GENERATOR DECALS The DCA-70SSIU (60 Hz) SuperSilent ™ Generator is equipped with a number of safety decals (Figures 2 & 3). These decals are provided for operator safety and maintenance information. The illustration below and on the preceding page show the decals as they appear on the machine.
Page 17
NFPA 110, Chapter 5-4.1). DO NOT remove the metal skids on the bottom of the generator. They are to resist damage to the bottom of the generator and to maintain alignment. DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 17...
(ON). be switched off. Voltage Regulator Control – Allows ±15% manual adjustment of the generator’s output voltage. DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 21...
Page 23
E. Overspeed Shutdown – Indicates the engine is running at an unsafe speed. This is considered a major fault. Engine Running – Indicates that engine is running at a safe operating speed. DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 23...
Page 24
. ■ ■ ■ ■ ■ Five (5) Output Terminal Lugs ( U, V, W, O, Ground) Figure 8. Output Terminal Panel PAGE 24 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
Page 26
The over current relay is lo- cated in the control box. Figure 14. Over Current Relay PAGE 26 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
. t f . t f . t f electrical system may occur without this transfer switch. t l u o r f t l o DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 27...
W-U and read the AC Voltmeter Gauge . Figure 18. AC Voltmeter Figure 19. AC Voltmeter Gauge Change-Over Switch (Volt reading on W-U Lug) DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 29...
3. Turn the voltage regulator knob (Figure 24) clockwise to increase voltage output, turn counterclockwise to increase voltage output, turn counterclockwise to decrease voltage output. decrease voltage output. DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 31...
API Service Classification CC/SD ■ ■ ■ ■ ■ API Service Classification CC/SE ■ ■ ■ ■ ■ API Service Classification CC/SF Figure 32. Internal Fuel Tank System PAGE 32 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
Page 33
CAUTION - REFUELING THE GENERATOR DO NOT OVER-FILL fuel system. Leave room for fuel expansion. Fuel expands when heated (Figure 36). Figure 36. Fuel Expansion DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 33...
Page 34
F - C ° F ° When the antifreeze is mixed with NOTE water, the antifreeze mixing ratio must be less than 50%. PAGE 34 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
Page 35
Tighten all hose clamps and check hoses for leaks. If any hose ( fuel or oil ) lines are defective replace them immediately. Figure 38. Battery Connections DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 35...
9. Once the engine starts, let the engine run for 1-2 minutes. Listen for any abnormal noises. If any abnormalities exists shutdown the engine and correct the problem. Figure 40. Engine Enclosure Doors PAGE 36 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
Page 37
The ammeter the generator. will only display a current reading if Figure 49. Ammeter a load is in use. Figure 54. Ammeter (No Load) (Load) DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 37...
OFF/RESET position. Figure 55. MPEC Control Switch (AUTO) 3. Continue to follow the steps outlined in the Manual Start- up procedure (start at step 9). PAGE 38 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
This can be air element, press the dust indicator button to reset the reduced by keeping the tank full with diesel fuel. indicator. DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 39...
Page 40
DO NOT spill the fuel during disassembly. place on blocks so tires do not touch the ground or block Vent any air. and completely remove the tires. PAGE 40 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
Figure 57. Battery Charger & Jacket Water Heater Power Connections DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 41...
Page 42
7. Coupler - Type of hitch used on the trailer for towing. 16. Application - Indicates which units can be employed on a particular trailer. PAGE 42 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
Page 43
. d i DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 43...
Page 44
PARTS MUST ROTATE FREELY SHACKLE BOLT LOCKING NUTS OR COTTER PINS ARE PROVIDED SPRING EYE BOLT TO RETAIN NUT BOLT ASSEMBLY SHOULDER TYPE SHACKLE BOLT PAGE 44 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
Page 45
" 4 " 5 " 6 Figure 60. Wheel Lug Nuts Tightening Sequence NEVER use an pneumatic air NOTE gun to tighten wheel lug nuts. DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 45...
NOTE last one listed indicates newest (or latest) part available. NOTE The contents of this catalog are subject to change without notice . PAGE 52 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
1 ..0605501079 ..SENDER, FUEL SWITCH Part number on this Suggested Spare Parts list may supercede/replace the P/N shown in the text NOTE pages of this book. DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 53...
DCA-70SSIU (60 Hz) — ENGINE AND RADIATOR ASSY. ENGINE AND RADIATOR ASSY. PAGE 60 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
Page 61
AIR CLEANER HOSE 0605515230 HOSE BAND 0605515197 HOSE BAND 0191300500 BLOWBY HOSE 0605515189 HOSE BAND 0602022560 ADAPTER 0602022561 90 DEGREE ELBOW 0603306590 CONNECTOR 0603300285 LOCKNUT DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 61...
Page 62
DCA-70SSIU (60 Hz) — ENGINE AND RADIATOR ASSY. (CONT.) ENGINE AND RADIATOR ASSY. PAGE 62 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
Page 63
M2316100304 RESERVE TANK BRACKET 0016908020 HEX HEAD BOLT 8972333820 FAN BELT ............... 1 ..REPLACES P/N 0602011434 0602123260 UNIT, WATER TEMPERATURE 9827200690 SENDER, OIL SWITCH DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 63...
NUMBER WHEN ORDERING ANY PAINTED PANEL TO INDICATE COLOR OF UNIT: 1-ORANGE 5-BLACK 2-WHITE 6-CATERPILLAR YELLOW 3-SPECTRUM GREY 7-CATO GOLD 4-SUNBELT GREEN 8-RED THE SERIAL NUMBER MAY BE REQUIRED. PAGE 64 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
NUMBER WHEN ORDERING ANY PAINTED PANEL TO INDICATE COLOR OF UNIT: 1-ORANGE 5-BLACK 2-WHITE 6-CATERPILLAR YELLOW 3-SPECTRUM GREY 7-CATO GOLD 4-SUNBELT GREEN 8-RED THE SERIAL NUMBER MAY BE REQUIRED. PAGE 74 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
Page 75
HEX HEAD BOLT M9310000004 BLIND PLUG M2463000502 ROOF PANEL M2493504303 ACOUSTIC SHEET M2423202604 FRONT FRAME OVER COVER 0019208020 HEX HEAD BOLT M1465400104 COVER 0019208020 HEX HEAD BOLT DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 75...
Page 76
NUMBER WHEN ORDERING ANY PAINTED PANEL TO INDICATE COLOR OF UNIT: 1-ORANGE 5-BLACK 2-WHITE 6-CATERPILLAR YELLOW 3-SPECTRUM GREY 7-CATO GOLD 4-SUNBELT GREEN 8-RED THE SERIAL NUMBER MAY BE REQUIRED. PAGE 76 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
Page 77
0019206016 HEX HEAD BOLT M9310000004 BLIND PLUG 0600500090 EMBLEM 0021106016 MACHINE SCREW 0016908020 HEX HEAD BOLT 0040508000 TOOTHED WASHER 0600800320 MANUAL PAK 0027106015 MACHINE SCREW DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 77...
Page 79
RUBBER SEAL 0228800770 RUBBER SEAL 0228800540 RUBBER SEAL 0228800580 RUBBER SEAL 0228100550 RUBBER SEAL 0228100170 RUBBER SEAL 0228100350 RUBBER SEAL 0228100360 RUBBER SEAL 0228100180 RUBBER SEAL DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 79...
Freight is at the sender’s expense. All date will be billed at the revised price. Rebates parts must be returned freight prepaid to Multiquip’s designated receiving point. PAGE 82 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09)
Page 83
NOTE PAGE DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 83...
Page 84
FAX: 310-638-8046 310-537-3700, EXT. 279 Manufactured for Multiquip Inc. DENYO CO., LTD, JAPAN Your Local Dealer is: MQ POWER A Division of Multiquip Inc. POST OFFICE BOX 6254 CARSON, CA 90749 310-537-3700 • 800-421-1244 FAX: 310-632-2656 E-mail: mqpower@multiquip.com Internet: www.mqpower.com...