Lennox Crestline LSBV-3628MN Care And Operation Instructions Manual
Lennox Crestline LSBV-3628MN Care And Operation Instructions Manual

Lennox Crestline LSBV-3628MN Care And Operation Instructions Manual

Crestline series b-vent gas fireplaces 36"/42" lsbv models

Advertisement

P/N 875035M REV. E 04/2013
This manual is one of a set of two supporting this product.
850042M
Refer to P/N
for Care and Operation Instructions.
This manual is available in French. Order P/N
Ce manuel est disponible en francais. Simplement en faire
la demande numéro de la pièce
506223-08
Portland
US
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
INSTALLATEUR : Laissez cette notice avec l'appareil.
CONSOMMATEUR : Conservez cette notice pour
consultation ultérieure.
WARNING / AVERTISSEMENT / AVISO
HOT GLASS WILL
CAUSE BURNS.
DO NOT TOUCH GLASS
UNTIL COOLED
NEVER ALLOW CHILDREN
TO TOUCH GLASS.
WARNING: If the information in these instructions
is not followed exactly, a fire or explosion may
result, causing property damage, personal injury,
or death.
- Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any other
appliance.
- WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any
phone in your building.
• Immediately call your gas supplier from a
neighbor's phone. Follow the gas supplier's
instructions.
• If you cannot reach your gas supplier, call the fire
department.
- Installation and service must be performed by a
qualified installer, service agency or the gas supplier.
506223-08
.
.
OTL Report No. 116-F-45-5
NE PERMETTEZ JAMAIS À UN ENFANT
CARE AND OPERATION INSTRUCTIONS
Crestline™ B-Vent Gas Fireplaces
36"/42" LSBV Models
MODELS
Millivolt Models
LSBV-3628MN
LSBV-3628MP
LSBV-3628MN-H
LSBV-3628MP-H
Decorative Product: Not for use as a heating appliance.
NOTICE: Fireplace is not to be operated by a thermostat.
UNE SURFACE VITRÉE CHAUDE
PEUT CAUSER DES BRÛLURES.
LAISSER REFROIDIR LA SURFACE
VITRÉE AVANT D'Y TOUCHER.
DE TOUCHER LA SURFACE VITRÉE.
AVERTISSEMENT : Assurez-vous de bien suivre les
instructions données dans cette notice pour réduire au
minimum le risque d'incindie ou d'explosion ou pour
éviter tout dommage matériel, toute blessure ou la mort.
- Ne pas entreposer ni utilizer d'essence ni d'autres vapeurs
ou liquides inflammables dans le voisinage de cet appareil
ou de tout autre appareil.
- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ :
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucan interrupteur. Ne pas vous servir des
téléphones se trouvant dans le bâtiment où vous trouvez.
• Appelez immédiatement votre fournisseur de gaz depuis
un voisin. Suivez les instructions du fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service des incindies.
- L'installation et l'entretien doivent être assurés par un
installateur ou un service d'entretien qualifié ou par le
fournisseur de gaz.
Electronic Models
LSBV-4228MN
LSBV-3628EN
LSBV-4228MP
LSBV-3628EN-H
LSBV-4228MN-H
LSBV-4228EN
LSBV-4228MP-H
LSBV-4228EN-H
EL VIDRIO CALIENTE
CAUSARÁ QUEMADURAS.
USTED DEBE NUNCA
TOCAR EL VIDRIO CALIENTE.
LOS NIÑOS DEBEN NUNCA
TOCAR EL VIDRIO.

Advertisement

Table of Contents
loading

Summary of Contents for Lennox Crestline LSBV-3628MN

  • Page 1 506223-08 This manual is available in French. Order P/N Ce manuel est disponible en francais. Simplement en faire la demande numéro de la pièce 506223-08 Millivolt Models Electronic Models LSBV-3628MN LSBV-4228MN LSBV-3628EN LSBV-3628MP LSBV-4228MP LSBV-3628EN-H Portland OTL Report No. 116-F-45-5...
  • Page 2: Table Of Contents

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS Important Safety Information Thank you for your purchase. We appreciate your business! Please carefully read and follow all instructions in this manual.
  • Page 3 LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS Información importante de seguridad L'information de sûreté importante 1. Ne pas utiliser cet appareil s’il a été plongé, même partiellement, 1. No use este artefacto si alguna de sus partes ha estado bajo agua.
  • Page 4: Attaching Safety In Operation Warnings

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS HOMEOWNER’S INSTRUCTIONS - ATTACHINg SAFETY IN OPERATION WARNINgS ATTACHINg SAFETY IN OPERATION WARNINgS APPOSITION DES MISES EN gARDE RELATIVES COLOCACIóN DE ADVERTENCIAS DE SEgURIDAD à...
  • Page 5: Appliance Installation, Service, And Maintenance Notices

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS WARRANTY INFORMATION APPLIANCE INSTALLATION, SERVICE, APPLIANCE OPERATION NOTICES AND MAINTENANCE NOTICES Your gas appliance is covered by a limited These fireplaces are vented gas life-time warranty.
  • Page 6: General Information

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS gENERAL INFORMATION gas Pressure - All Models Deration - At higher elevations, the amount of BTU fuel value delivered must be reduced...
  • Page 7: Operation/Care Of Your Appliance

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS OPERATION AND CARE OF YOUR APPLIANCE gas Valve Diagrams See Figure 2 for Millivolt models and Figure 3 WARNINg For Electronic Models.
  • Page 8: Damper & Combustion Air Controls

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS OPTIONAL gLASS DOOR WARNINg WARNINg 7. Clean the optional glass doors only when necessary. Wipe surface with clean, damp- Only doors certified with the Damper must be in open position ened, soft cloth.
  • Page 9: Manual Limit Switch

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS MANUALLY-RESET BLOCKED FLUE SAFETY SWITCH Wire Detail A Terminals This appliance is equipped with a manually- reset blocked flue safety switch. Refer to Figure 6 for its location.
  • Page 10: Maintenance

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS MAINTENANCE LOgS, gLOWINg EMBERS AND the burner. Ensure the burner ports are “open.” Remove any carbon deposits from the under VOLCANIC STONE PLACEMENT...
  • Page 11 LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS Proper log placement is critical to prevent soot- Rear Log Left Log Rear Log Landing ing. Carefully position the ceramic fiber logs over the burner as described in the following steps, and detailed in Figures 7 through 12.
  • Page 12: Burner Adjustments

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS BURNER ADJUSTMENTS Burner Flame Adjustments WARNINg (QUALIFIED TECHNICIANS ONLY) To adjust the flame, position the air shutter • Air shutter adjustment should Flame Appearance and Sooting to the nominal setting (see Figure 14).
  • Page 13: Millivolt Appliance Checkout

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS REPLACEMENT PARTS Millivolt Appliance Checkout If you encounter any problems or have any questions concerning the installation or applica- The pilot flame should be steady, not lifting...
  • Page 14: Wiring Diagrams

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS WIRINg DIAgRAMS CAUTION: LABEL ALL WIRES ATTENTION: AU MOMENT DE L'ENTRETIEN PRIOR TO DISCONNECTION WHEN DES COMMANDES, éTIQUETEZ TOUS Wiring diagrams are provided here for reference SERVICINg CONTROLS.
  • Page 15: Accessory Components

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS ACCESSORY COMPONENTS Product Reference Information Cat. Model Ship. Shipping Weight Volume H5782 LSBV-3628NM 298 lbs. 36.3 cu.ft. H5783 LSBV-3628PM 298 lbs. 36.3 cu.ft.
  • Page 16 LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS ACCESSORY COMPONENTS Pine Cones and Wood Bits Kit Cat. No. Model No. Description H5800 LDgHK36 36" Black Hood Kit Arch Screen Door Kits...
  • Page 17: Maintenance Schedule

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS MAINTENANCE SCHEDULE Annually (Before the onset of the Burning Season) MAINTENANCE TASK ACCOMPLISHINg PERSON PROCEDURE Inspecting/Cleaning Burner, Logs Qualified Service Technician Inspect valve and ensure it is properly operating. Check piping and Controls for leaks.
  • Page 18: Lighting Instructions - Millivolt

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS LIgHTINg INSTRUCTIONS – MILLIVOLT gAS VALVE FOR YOUR SAFETY READ BEFORE LIgHTINg WARNINg: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life.
  • Page 19 LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS INSTRUCTIONS D’ALLUMAgE – VANNE gAZ MILLIVOLT POUR PLUS DE SéCURITé, LIRE AVANT D’ALLUMER AVERTISSEMENT. Quiconque ne respecte pas à la lettre les instructions dans la présente notice risque de déclencher un incendie ou une explosion entraînant des dommages, des blessures ou la mort.
  • Page 20: Lighting Instructions - Electronic

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS LIgHTINg INSTRUCTIONS – MILLIVOLT gAS VALVE FOR YOUR SAFETY READ BEFORE OPERATINg WARNINg: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life.
  • Page 21 LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS INSTRUCTIONS D’ALLUMAgE – VANNE gAZ MILLIVOLT POUR PLUS DE SéCURITé LIRE AVANT DE METTRE EN MARCHE AVERTISSEMENT. Quiconque ne respecte pas à la lettre les instructions dans la présente notice risque de déclencher un incendie ou une explosion entraînant des dommages, des blessures ou la mort.
  • Page 22: Troubleshooting Guide - Millivolt

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS TROUBLESHOOTINg THE MILLIVOLT gAS CONTROL SYSTEM NOTE: Before troubleshooting the gas control system, Ensure external gas shut off valve, located at gas supply inlet, (and wall switch, iff applicable), is in the “ON”...
  • Page 23: Troubleshooting Guide - Electronic

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS TROUBLESHOOTINg THE ELECTRONIC IgNITION SYSTEM NOTE: Before troubleshooting the gas control system, Ensure external gas shut off valve, located at gas supply inlet, (and wall switch, iff applicable), is in the “ON”...
  • Page 24: Replacement Parts List

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS REPLACEMENT PARTS LIST REPLACEMENT PARTS LIST gAS CONTROLS — MILLIVOLT LSBV-3628 LSBV-4228 Natural gas Propane gas Description Description Part No. Qty. Part No.
  • Page 25: Replacement Parts

    LENNOX HEARTH PRODUCTS • CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS REPLACEMENT PARTS ELECTRONIC MILLIVOLT NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.
  • Page 26 Lennox Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information. LENNOX , the LENNOX design, DAVE LENNOX, the image of DAVE LENNOX and other related ®...

Table of Contents