Titan TG 4500 Owner's Manual page 4

This generator was designed for specific applications. DO NOT attempt to modify the unit in any way or
use it for any application that it was not designed to do. Ask the dealer or contact the factory if you have
any questions concerning the generator's application.
Warnings and cautions in this manual and on decals and tags on the unit are not all inclusive. It would be
impossible to anticipate every circumstance that might involve a hazard. Handling, operating, or servicing
this unit by any procedure not recommended by the manufacturer may render this equipment unsafe and
may pose a threat to you or to others.
z
The generator produces a very powerful voltage
that can cause extremely dangerous electrical
shock. Avoid contact with bare wires, terminals,
etc. never permit an unqualified person to oper-
ate or service the generator.
z
Never handle any kind of electrical cord or de-
vice while standing in water, while barefoot or
with wet hands or when feet are wet. Dangerous
electrical shock could result.
z
The National Electric Code requires that the
frame and external conductive parts be properly
connected to an approved earth ground. Local
electrical codes may vary. Check with an electri-
cian for local grounding requirements.
z
Use a ground fault circuit interrupter in any damp
or highly conductive area such as metal decking
or steel work.
z
Do not use worn, bare, frayed or otherwise
damaged electrical cords or wiring with the gen-
erator. A defective cord may result in electrical
shock or may cause damage to equipment.
z
Do not expose unit to excessive moisture, dirt
or corrosive vapors. Unit must be operated on
a level surface.
z
Do not overfill the fuel tank. Always allow room
for fuel expansion. Fuel could overflow and
cause fire or explosion if tank is overfilled. Al-
low for a 20 minute cool down before refueling.
Never refuel tank while engine is running.
Caution: Customer takes full responsibility for
use
z
SAFETY
z
z
z
z
z
z
4
z
Only operate this unit outside with adequate ven-
tilation. This generator's exhaust produces carbon
monoxide gas that can cause unconsciousness or
even death.
Never store a generator with fuel in the tank where
fuel vapors could be ignited by a flame, spark, or
pilot light from an appliance such as a furnace,
water heater, or clothes dryer.
Always allow a minimum of 2 feet of clearance on
all sides for ventilation while unit is operating. Allow
2 feet of clearance from all combustibles.
Generator must always be stopped or started with
all loads unconnected. Start the engine and let it
stabilize before connecting any loads. Disconnect
all loads before shutting down the generator.
Never insert any object through the cooling slots of
the engine. You could damage the unit or cause
injury.
NEVER OPERATE THE GENERATOR:
In rain
In an enclosed compartment
If connected devices overheat
If electrical output is lost
If engine or generator sparks
If flame or smoke is observed
If unit vibrates excessively
CAUTION! The engine exhaust contains chemicals
known to the State of California to cause cancer,
birth defects, or other reproductive harm.
CAUTION! If it is your first time starting the genera-
tor, allow it to run for 30 minutes before connecting
electrical loads. This is for wet seating purposes