Titan TG 4500 Owner's Manual
  1. Manuals
  2. Brands
  3. Titan Manuals
  4. Portable Generator
  5. TG 4500
  6. Owner's manual

Titan TG 4500 Owner's Manual

Industrial generator
Hide thumbs
Table of Contents

Advertisement

Quick Links

P.O.Box 791, Travelers Rest, S.C. 29690
Service\Parts (800) 845-4141
OWNER'S MANUAL
Titan TG 4500 Industrial Generator
The Emission Control System for this generator is warranted for standards set by the Environment Protection Agency.
IMPORTANT!
It is extremely important to read and understand the entire contents of
this Owner's Manual for the Titan Model TG 4500 before attempting to
operate the generator. This is a gas engine powered, industrial strength
generating unit of electrical power. The gas engine and the generator
are both potentially extremely hazardous and could cause physical injury
or even death if improperly used.
WARNING!
Do Not Operate Equipment until reading & understanding Owner's Manual!
Disconnect all loads before starting or stopping generator.
Allow to run for a few minutes with no load before stopping.
Revision # 030321A

Advertisement

Table of Contents
loading

Related Manuals for Titan TG 4500

Summary of Contents for Titan TG 4500

  • Page 1 IMPORTANT! It is extremely important to read and understand the entire contents of this Owner’s Manual for the Titan Model TG 4500 before attempting to operate the generator. This is a gas engine powered, industrial strength generating unit of electrical power. The gas engine and the generator are both potentially extremely hazardous and could cause physical injury or even death if improperly used.

  • Page 2: Industrial Generator

    It is extremely important to read and understand the entire contents of this Owner’s Manual for the Titan Model 4500 before attempting to operate the generator. This is a gas engine powered, industrial strength generating unit of electrical power. The gas engine and the generator are both potentially extremely hazardous and could cause physical injury or even death if improperly used.

  • Page 3: Connecting Loads

    CONNECTING LOADS TITAN Add up the Watts of all devices you connect to the TITAN Generator at one time. Do not exceed 4000 Watts on TITAN Generator Model TG 4500 (see wattage refer- ence guide). P.O. Box 791 The rated Watts of most electrical devices can be found Travelers Rest, S.C.
  • Page 4 SAFETY This generator was designed for specific applications. DO NOT attempt to modify the unit in any way or use it for any application that it was not designed to do. Ask the dealer or contact the factory if you have any questions concerning the generator’s application.

  • Page 5: Operation Of The Generator

    OPERATION OF THE GENERATOR Starting the engine Stopping the engine 1. Check oil and fuel levels Turn off all electrical devices connected to the generator. 2. Turn fuel valve to the “ON” position WARNING: 3. Put choke lever in the “ON” position DO NOT start or stop generator with electrical devices plugged in.

  • Page 7: Circuit Breakers

    D.C. VOLT 120VOLT. 3PRONG RECEPTACLE CIRCUIT BREAKERS L5-30 120VOLT. RECEPTACLE L5-20 VOLTMETER 120\240 VOLT. RECEPTA- GROUND LUG ON\OFF SWITCH TITAN P.O.Box 791, Travelers Rest, S.C. 29690...

  • Page 8: Wattage Reference Guide

    Wattage Reference Guide Device Running Watts Device Running Watts Impact Wrench *Air Conditioner (12,000 BTU) 1700 *Jet Pump Battery Charger (20 Amp) Belt Sander (3”) 1000 Lawn Mower 1200 Light Bulb Chain Saw 1200 Microwave Oven Circular Saw (6-1/2”) 800 to 1000 Coffee Maker 1000 *Milk Cooler...
  • Page 10 42oz.
  • Page 11 Storage...

  • Page 13: Troubleshooting

    TROUBLESHOOTING Problem Cause Solution 1. Reset the circuit breaker. 1. Circuit breaker is open. Engine is running but no power 2. Check & repair. 2. Poor connection or defective output is available. 3. Connect another device cord set. that is in good condition. 3.

  • Page 14: Specifications

    TITAN P.O. Box 791 Travelers Rest, S.C. 29690 (800) 845-4141 Model TG 4500 Specifications:_______________________________________ Output 4000watts Continuous Rpm 3720 4500watts Surge Brush type Generator Head 1- L5-20 Receptacle AVR Voltage Regulater 1- L14-30 Receptacle Copper Windings 1- L5-30 Receptacle Single Phase 60Hz.
  • Page 15 MODEL TG 4500 Generator MODEL TG 4500 TITAN P.O. Box 791 • Travelers Rest, SC 29690 • (800) 845-4141...

Table of Contents