Advertisement
MODEL TG 8500M Industrial Generator
The Emission Control System for this generator is warranted for standards set by the Environment Protection Agency.
It is extremely important to read and understand the entire contents of this
Owner's Manual for the Titan Industrial Model TG 8500M before at-
tempting to operate the generator. This is a gas engine powered, indus-
trial strength generating unit of electrical power. The gas engine and the
generator are both potentially extremely hazardous and could cause
physical injury or even death if improperly used.
Do Not Operate Equipment until reading & understanding Owner's Manual!
Disconnect all loads before starting or stopping generator.
Allow to run for a few minutes with no load before stopping.
l
P.O.Box 791, Travelers Rest, S.C. 29690
Phone 864-834-7212
Service/Replacement Parts 800-845-4141
www.titanindustrial.net
OWNER'S
IMPORTANT!
WARNING!
MANUAL
®
Revision # 030321A
Advertisement
Table of Contents
Related Manuals for Titan TG 8500M
Summary of Contents for Titan TG 8500M
- Page 1 IMPORTANT! It is extremely important to read and understand the entire contents of this Owner’s Manual for the Titan Industrial Model TG 8500M before at- tempting to operate the generator. This is a gas engine powered, indus- trial strength generating unit of electrical power. The gas engine and the generator are both potentially extremely hazardous and could cause physical injury or even death if improperly used.
-
Page 2: Grounding The Generator
MODEL TG 8500M Industrial Generator TITAN INDUSTRIAL shall not be responsible for any consequences resulting from improper use of this equipment. The operator is required to read the entire contents of this manual before attempting to operate the unit. If the operator does not completely understand the instructions and all of the hazards of operating this unit after reading this manual, he/she must call the factory at 1-800-845-4141 to answer these questions to his/her complete satisfaction before proceeding. - Page 3 SAFETY This generator was designed for specific applications. DO NOT attempt to modify the unit in any way or use it for any application that it was not designed to do. Ask the dealer or contact the factory if you have any ques- tions concerning the generator’s application.
-
Page 4: Operation Of The Generator
OPERATION OF THE GENERATOR Starting the engine Stopping the engine Turn off all electrical devices connected to the 1. Check oil and Gas for proper levels generator. 2. Turn fuel valve to the ON postiton WARNING: 3. Turn stop switch to the On position DO NOT start or stop generator with electri- 4. -
Page 5: Troubleshooting
TROUBLESHOOTING Problem Cause Solution 1. Reset the circuit breaker. Engine is running but no power 1. Circuit breaker is open. 2. Check & repair. output is available. 2. Poor connection or defective 3. Connect another device cord set. that is in good condition. 3. -
Page 6: Control Panel
Control Panel Circuit Breakers Stop Switch Ground Lug 3 Prong L5-30 120v Receptacle (120v) 4 Prong Receptacle L14-30... - Page 7 Engine oil is a major factor affecting engine performance and service life. Non detergent and 2-stroke engine oils will damage the engine and are not recommended. Check the oil level BEFORE EACH USE with the generator on a level surface and the engine stopped. Use 4-stroke motor oil that meets or exceeds the requirements for API service classification SJ.
- Page 8 Wattage Reference Guide Device Running Watts Device Running Watts *Air Conditioner (12,000 BTU) 1700 Impact Wrench Battery Charger (20 Amp) *Jet Pump Belt Sander (3”) 1000 Lawn Mower 1200 Chain Saw 1200 Light Bulb Circular Saw (6-1/2”) 800 to 1000 Microwave Oven Coffee Maker 1000...
- Page 9 Storage...
-
Page 11: Specifications
Low Oil Shut Down 74 Decibel’s @ 10’ Oil Capacity 32oz. (30wt. SAE) Manual Start Size: L-32” W-28” H-26” 11hp Titan Gasoline Engine Net. Weight 220LBS. Steel Sleeve Cylinder One Year Warranty ... - Page 12 MODEL TG 8500M Industrial Generator MODEL 8500M Industrial Generator ® P .O. Box 791 • Travelers Rest, SC 29690 • Phone: (864) 834-7212 • Fax: (864) 834-5127 Service/Replacement Parts: (800) 845-4141 • www.titanindustrial.net...