Insulation Jackets - Kenmore 153.339111 HA Owner's Manual

Minimumclearances betweenthe water heaterand
combustible construction are0 inchatthesides andrear, 4
inches ( 102 ram) a tthefront, a nd 6 inches ( 153 mm) f romthe
vent p ipe, s eeFigure 8 . Clearance from thetopofthe jacket i s
12inches (305ram) on mostmodels.Notethata lesser
dimension may beallowed o nsome models, refer t othelabel
attached adjacent tothegascontrol valve onthewater h eater.
TOP VIEW TOP VIEW
OF CLOSET OF CLOSET
WITHOUT DOOR WroTH DOOR
(104 mm)
0" MIN.
FIGURE&
Breathing Hazard - Carbon Monoxide Gas
Install water heater in accordance
with the instruction manual and
NFPA 54.
Breathing carbon monoxide can cause brain damage or
death. Always read and understand instruction manual.
To avoid injury, combustion and
ventilation air must be taken from
outdoors.
Do not place chemical vapor
emitting products near water
heater.
If this water heater will be used in beauty shops, barber shops,
cleaning establishments, or self-service laundries with dry
cleaning equipment, it is imperative that the water heater or
water heaters be installed so that combustion and ventilation
air be taken from outside these areas.
Propellants of aerosol sprays and volatile compounds,
(cleaners, chlorine based chemicals, refrigerants, etc.) in
addition to being highly flammable in many cases, will also
change to corrosive hydrochloric acid when exposed to the
combustion products of the water heater. The results can be
hazardous, and also cause product failure.
Insu_ation B_ankets
Insulation blankets available to the general public for external
use on gas water heaters are not necessary with Kenmore
products. The purpose of an insulation blanket is to reduce the
standby heat loss encountered with storage tank heaters. Your
Kenmore water heater meets or exceeds the National Appliance
Energy Conservation Act standards with respect to insulation
and standby loss requirements, making an insulation blanket
unnecessary.
Breathing Hazard - Carbon Monoxide Gas
* Do not obstruct water heater air
intake with insulating blanket.
* Gas and carbon monoxide
detectors are available.
Install water heater in accordance
with the instruction manual
Breathing carbon monoxide can cause brain damage or
death. Always read and understand instruction manual.
A gas water heater cannot operate properly without the correct
amount of air for combustion, see Figure 9. Do not install in a
confined area such as a closet, unless you provide air as shown
in the Locating The New Water Heater section. Never obstruct
the flow of ventilation air. If you have any doubts or questions at
al!, call your gas supplier. Failure to provide the proper amount
of combustion air can result in a fire or explosion and cause
death, serious bodily injury, or property damage.
T
(30 era)
VENTULATUON
AiR
OPENtNG O
JL 12" NAX.
(3e
c_q}
FRONT VmEW
OF DOOR
AIR DUCT
HGURE&
10
Should you choose to apply an insulation blanket to this heater,
you should follow these instructions (See Figure 1 for
identification of components mentioned below). Failure to follow
these instructions can restrict the air flow required for proper
combustion, potentially resulting in fire, asphyxiation, serious
personal injury or death.
Do not apply insulation to the top of the water heater, as this
will interfere with safe operation of the draft hood.
Do not cover the outer door, thermostat or temperature &
pressure relief valve.
Do not allow insulation to come within 2" (50.8 mm) of the
floor to prevent blockage of combustion air flow to the burner.
Do not cover the instruction manual. Keep it on the side of
the water heater or nearby for future reference.
Do obtain new warning and instruction labels from Sears
for placement on the blanket directly over the existing labels.
Do inspect the insulation blanket frequently to make certain
it does not sag, thereby obstructing combustion air flow.