Power miser 6 series 30/40/50 gallon 30/40 gallon short 30/40/50 gallon high altitude 30/40/50 gallon propane (lp.) 40/50 gallon propane (l.p.) high altitude (32 pages)
Gas water heater power vented gas models with hot surface ignition (34 pages)
Summary of Contents for Kenmore 153.336152
Page 1
Owners Manual FOR POTABLE WATER HEATING ONLY NOT SUITABLE FOR SPACEHEATING POWER MISERTM6 FOR USE IN MOBILE HOMES WATER HEATER Model 153.336152 30 Gal. Short • Care and Maintenance • Safety Instructions 153.336252 40 Gal. Short • Installation • Troubleshooting 153.336313 30 Gal.
Safety Precautions AWARNING _,WARNING Improper installation, adjustment, alteration, service or | At the time of manufacture this water heater was pro* BODILY / maintenance can cause DEATH, SERIOUS vialed with a combination temperature-pressures relief INJURY, OR PROPERTY DAMAGE. Refer to this manu- / valve certified by a nationally recognized testing labora-...
Page 3
Safety Precautions _WARNING A, WARNING A gas water heater cannot operate properly without the This water heater must not be installed directly on car- correct amount of air for combustion. Do not install in a peting. Carpeting must be protected by a metal or wood confined area such a closet, unless you provide air as panel beneath the appliance extending beyond the full shown in the "Locating...
Page 4
Safety Precautions • , CAUTION AWARNING The water heater with draft hood installed must be prop- J WATER HEATERS EVENTUALLY LEAK: Installation of erly vented to a chimney which terminates outdoors. I the water heater must be accomplishedin sucha manner Never operate the water heater unless it is vented to the_ that if the tank or any connections shouldleak, the flow outdoors and has adequate air supply to avoid risks...
Table of Contents <€,_,_,_,a,,._y Precautions ....................Table of Contents ....................Customer lZesponslblhtles ......................Product bpecmcanons ..................Materials and Basic Tools Needed ..............Materials Needed ..................................Basic Tools ....................................Installation Instructions ..................8-16 Removing the Old Water Heater ............................... Facts to Consider About the Location ............................Combustion Air and Ventilation for Appliances in Unconfined Spaces ...................
Customer Responsibilities Thank You This manual contains instructions for the installation, opera- for purchasinga Sears water heater tion, and maintenance of the gas-fired water heater. It also Properly maintained, give installed it should you years of contains warnings through out the manual that you must read trouble free service.
Materials and Basic Tools Needed Materials Needed To simplify the installation Sears has available the installation parts shown below. You may or may not need all of these materi- als, depending on your type of installation. WATER HEATER STAND 24"x24"x I 8" FOR USE WITH WATER HEATERS INSTALLED...
Installation Instructions Removing the Old Water Heater ODisconnect the vent pipe from the draft hood where Turn "OFF" the gas supply to the water heater. they connect to the water heater. In most installations the vent pipe can be lifted off after any screw or other AWARNING attached devices are removed.
Installation Instructions (cont'd) Facts to Consider About the Location You should carefully choose an indoor location for the new • The location selection must provide adec_uateclearances for ser- water heater, because the placement is a very important consid- vicing and proper operation of the waterneater. eration for the safety of the occupants in the building...
Installation Instructions (cont'd) Combustion Air and Ventilation for Appliances Located Unconfined Spaces Unconfined Space is a space whose volume is not less than 50 1. When directly communicating with the outdoors, each open- cubic feet per 1,000 Btu per hour of the aggregate input rating ing shall have a minimum free area of 1 square inch per 4,000...
Installation Instructions (cont'd) Water Piping A WARNING • Look at the top cover of the water heater. The cold water HOTTER WATER CAN SCALD:Water heatersare intended to inlet is marked cold. Put two or three turns of teflon tape around the threaded end of the threaded-to-sweat coupling...
Installation Instructions (cont'd) Temperature-Pressure Relief Valve _,WARNING AWARNING At the time of manufacture this water heater was provided The temperaturo-pressure relief valve must be manually with a combination temperature-pressures relief valve certi- operated at least once a year. Caution should be taken to fied by a nationally recognized testing laboratory that main- ensure that (|) no one is in front of or around the outlet of...
Installation Instructions (cont'd) Filling the Water Heater For proper venting in certain installations, a larger diameter vent A CAUTION pipe may be necessary. Due to great variances in installations, Never use this water heater unless it is completely filled with J unforeseeable by the manufacturer of the water heater, you mus water.
Installation Instructions (cont'd) Venting (cont'd) Gas Piping All vent gases must be completely vented to the outdoors of the AWARNING structure (dwelling). Installonly the draft hood provided with Make sure the gas suppliedis the same type listed on the the new water heater and no other draft hood. model rating plate.
Installation Instructions (cont'd) GAS PIPING WITH FLEXIBLE CONNECTOR he appliance and its gas connection must be leak tested _b T _, WARNING efore placing the appliance in operation. GAS SUPPLY PIPING FLEXIBLE GAS CONNECTOR _,WARNING GROUNDIO'NT • The appliance and its individual shutoff valve must be discon- nected from the gas supply piping system during any pressure testing of the gas system at test pressures in excess of _/2 pound per square inch (3.5kPa).
Installation Instructions (cont'd) Installation Checklist BEFORE LIGHTING PILOT: • Check the gas lines for leaks. a. Use a soapy water solution. DO NOT test for gas leaks using a match or open flame. b. Brush the soapy water solution on all gas pipes, joints and VENT PIPE TO fittings.
Operating Instructions Lighting _WARNING BEFORE LIGHTING [PROPANE (L.P.) GAS WATER HEATERS]:Propane (LR) gasis heavierthan air.Shouldthere be a leak in the system,the gaswill settle near the ground. Basements,crawl spaces, s kirted areasunder mobile homes (evenwhenventilated), c losets and areasbelowground levelwill serve as pockets for the accumulation of this gas. Before attemptingto lightor relight the water heater's pilot or turning on a nearbyelectrical l ightswitch,be absolutely surethere isno accumulated gasin the area.
Page 18
Operating Instructions (cont'd) Lighting label on the water heater as it appears above the thermostat YOUR SAFETY READ BEFORE LIGHTING WARNING if you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. A.
Operating Instructions (cont'd) Temperature Regulation Due to the nature of the typical gas water heater, the water tem- Turn the water temperature dial clockwise_f"_) to decrease roerature in certain situations may vary up to 30°F higher or the temperature, or counterclockwise (_'f -"0 to increase the wer at the point of use such as, bathtubs, showers, sink, etc.
Service and Adjustment Tank (Sediment) Cleaning Sediment build-up on the tank bottom may create varying AWARNING amounts of noise, and if left in the tank will cause premature Soot build-upindicates a problem that requires correction [ tank failure. In some water areas, you may not be able to drain beforefurther use.Turn "OFF"...
Service and Adjustment (cont'd) Draining The water heater should be drained if being shut down during AWARNING freezing temperatures. Also periodic draining and cleaning When checking the temperature-pressure relief valve opera. sediment from the tank may be necessary. tlon, make sure that (I) no one is in front of or around the outlet of the temperature-pressure relief valve discharge line, Turn the gas control knob to the "OFF"...
Troubleshooting Guide Start Up Conditions THERHAL EXPANSION WATER HEATER COlD - COLD WATER PRESSURE INLET FITTING REDUCING W_.rer supply systems may, because of high line pressure, fre- VALVEWITH quent cut_offs, the effects of water hammer and others, have BY-PASS installed devices such as pressure reducing valves, check valves,...
Troubleshooting Guide (cont'd) CONDENSATION SMOKE/ODOR Whenever the water heater is filled with cold water, a certain It _s not to experience tnlcommon a small amount of smoke amount of condensation will form while the burner is on. A odor during the initial start-up. This is due to burning off of oil from metal parts, and will disappear in a short while.
Troubleshooting Guide (cont'd) Operational Conditions (cont'd) HIGH TEMPERATURE SHUT SYSTEM AWARNING Due to the nature of the typical gas water heater, the This water heater is equipped with an automatic gas shut offsys- water temperature in certain situations may be hotter tem.
Troubleshooting Guide (cont'd) Leakage Checkpoints Use this guide to check a "Leaking" water heater. Many suspect- ed "Leakers" are not leaking tanks. Often the source of the water ACAUTION can be found and corrected. Read this manual first. Then before checking the water I heater make sure the...
Parts Order List POWER MISER 6 GAS WATER HEATERS MODEL NUMBERS: 30 Gal. Short 153.336152 40 Gal. Short 153.336252 153.336313 30 Gal. High Altitude 30 Gal. 153.336352 153.336413 40 Gal. High Altitude 40 Gal. 153.336452 t,..... , _ 20...
Page 29
Parts Order List (cont'd) POWER MISER 6 GAS WATER HEATERS MODEL NUMBERS: 153.336152 3OG_. Short 153.336252 4OGM. Short 153.336313 30 G_. High Altitude 153.336352 3OG_. 153.336413 40 GM. High Altitude 153.336452 4OGM. Model Numbers 153.336152 153.336313 153.336352 153.336252 153.336413 153.336452 PART DESCRIPTION PART NUMBERS 9000071...
Page 30
Parts Order List (cont'd) POWER MISER 6 GAS WATER HEATERS MODEL NUMBERS: 5OGaLHighAldtude 153.336513 50Gal. 153.336552 30Gal. Propane (L.R) 153.336752 153.336813 40Gal. Propane (L.E) HighAldtud¢ 153.336852 40Gal. Propane(L.R) 153.336913 50Gal. Propane (L.R) HighAlfitude 50Gal. Propane (L.R) 153.336952...
Page 31
Parts Order List (cont'd) POWER MISER 6 GAS WATER HEATERS MODEL NUMBERS: 153.336513 50 Gal. High Altitude 50 Gal. 153.336552 30 Gal. Propane (L.P.) 153.336752 40 Gal. Propane (L.P.) High Altitude 153.336813 153.336852 40 Gal. Propane (L.P.) 153.336913 50 Gal. Propane (L.R) High Altitude 153.336952 50 Gal.
Page 32
LIMITED WARRANTYON PARTS After one year and through 6 years from the date of purchase, when your Sears Kenmore water heater is used in a single-family residence and is installed and operated in accordance with the information in this manual, ira part fails due to a materials or workmanship, Sears will furnish a replacement free of charge.