Table of Contents
Advertisement
Quick Links
Download this manual
See also:
Owner's Manual
GEN
RAC°
Portable Products
,_
3 5 0 0WATT
Portable
Generator
Owner's Manual
Model No. 1313-I (3,500 Watt AC Generator)
Manual No. 18721I Revision 0 (8/31/2000)
Visit our Generac
website:
www.generac-portables.com
This is the safety alert symbol. It is usedto alert you to potential personal injury hazards.
Obey all safety messages that follow this symbol to avoid possible injury or death.
Advertisement
Table of Contents
Related Manuals for Generac Portable Products 1313-1
Summary of Contents for Generac Portable Products 1313-1
- Page 1 Generator Owner's Manual Model No. 1313-I (3,500 Watt AC Generator) Manual No. 18721I Revision 0 (8/31/2000) Visit our Generac website: www.generac-portables.com This is the safety alert symbol. It is usedto alert you to potential personal injury hazards. Obey all safety messages that follow this symbol to avoid possible injury or death.
-
Page 2: Equipment Description
• The generator's revolving field is driven at about generator from the power utility may result 3,600 rpm by a Generac Power Systems6.5 h.p. engine. in injury or death to electric utility workers and damage to the generator due to a backfeed of electrical energy. - Page 3 Generac Portable Products 3,500 Watt Generator • The generator produces a very powerful voltage that can • Never operate the generator: cause serious injury or death by electrocution. Never in rain; in any enclosed compartment; when connected touch bare wires or receptacles. Never permit a child or electrical devices overheat;...
-
Page 4: Your Generator
Generac Portable P roducts 3,500 WattGenerator KNOW YOUR GENERATOR Read this owner's manual and safety rules before operating your generator. Compare the illustrations with your generator, to familiarize yourself with the locationsof various controls and adjustments. Savethis manual for future reference. -
Page 5: Install Wheel Kit
Generac Portable P roducts 3,500 WattGenerator INSTALL WHEEL NOTE: Be sure to installboth wheelswith the air pressure valveon the outboard side. IMPORTANT: This wheel kit is not intended for • Retain wheel on axle with the retaining pin.. You may acid the fiat washer if desired. -
Page 6: Add Gasoline
Generac Portable P roducts 3,500 WattGenerator BEFORE STARTING • Use regular UNLEADED gasoline with the Generator engine.Do Not use premium gasoline. Do Not mix oil ENGINE with gasoline. • Clean area around fuel fill cap, remove cap. Add Oil • Add unleaded regular gasoline, slowly to fuel tank. Be careful not to overfill. -
Page 7: Starting The Engine
Generac Portable Products 3,500 Watt Generator OPERATING 5B. For manual starting, grasp the recoil handle and pull slowly until slight resistance is felt. Then pull rapidly G EN ERATO R one time only to start engine. • If engine starts, proceed to step 7. - Page 8 Generac Portable Products 3,500 Watt Generator To recharge 12 Volt batteries, proceed as follows: Stopping the Engine • Check fluid level in all battery cells. If necessary,add • Unplug all electrical loads from generator panel ONLY distilled water to cover separators in battery receptacles.
- Page 9 • Enclosure should hold enough heat created by the Under certain weather conditions (temperatures below generator to prevent icing problems. 40°F [4°C] and a high dew point), your Generac generator may experience icingof the carburetor and/or the crankcase breather system. CAUTIONt Never run unit indoors;Do Not...
- Page 10 Generac Portable Products 3,500 Watt Generator 120/240 Volt AC, 20 Amp Locking 120 Volt AC, 30 Amp Locking Receptacle Receptacle Use a N EMA LI4-20 plug with this receptacle. Connect a Use a NEMA L5-30 plug with this receptacle. Connect a 3-...
- Page 11 Generac Portable Products 3,500 Watt Generator DON'T OVERLOAD • If the appliance, tool or motor does not give wattage, multiply 120 Volts times ampere rating to determine G EN ERATO R watts (volts x amps = watts). • Some electric motors, such as induction types, require...
-
Page 12: Specifications
Generac Portable Products 3,500 Watt Generator SPECIFICATIONS To Clean the Generator • Use a damp cloth to wipe exterior surfaces clean. Maximum Surge Watts ....4,375 watts • Soft, bristle brush may be used to loosen caked on dirt Continuous Wattage Capacity .. -
Page 13: Troubleshooting
Generac Portable Products 3,500 Watt Generator TROUBLESHOOTING Problem Solution Cause Reset circuit breaker. Circuit breaker is open. Poor connection or defective Check and repair. cord set. Engine is running, but no AC Connected device is bad. output is available. Connect another device that isin good condition. - Page 14 Generac Portable P roducts 3,500 WattGenerator ID_ELF_i_I_ ELECTRICAL SCHEMATIC • LdOJ O_OJ LdCd OrOJ • SWITCH 3PARK PLUG IGNITION BATTERY CHARGE AUTO • RESET...
- Page 15 Generac Portable Products 3,500 Watt Generator ID_'! WIRING DIAGRAM u© 120V/15A IDLE CONTROL BOARD TRANSFORMER PRESSURE GATE SWITCH SIGNAL CONNECTOR ENGINE PRESSURE RE]] ENGINE _LOCK BATTERY CHARGE RECTIFIER...
- Page 16 Generac Portable Products 3,500 Watt Generator EXPLODED VIEW - MAIN UNIT _"--_--55 DETAIL " X " DETAIL " Y " DETAIL " Y " D_AIL...
- Page 17 Generac Portable Products 3,500 Watt Generator - MAIN UNIT PARTS LIST Item Part # Description Description Item Part# 86292 HHCS, 10-16 x 3/4" Self Drill CRADLE, XL G93199 77395 NUT, M6 Flange Lock G84021 SUPPORT,Engine 83465 GROMMET, Tank ENGINE, 6.5 HP XL 78831B SCREW, M6- I .(3x 60 (black)
- Page 18 Generac Portable Products 3,500 Watt Generator ? j/_ EXPLODED VIEW / PARTS LIST - CONTROL PANEL Item Part# Part# Item Description Description BI431 84028 PANEL, Control TRANSFORMER, Idle Control 83975 67022 BOX, Control GROMMET, Rubber 66818 OUTLET 120 Volt AC...
- Page 19 Generac Portable Products 3,500 Watt Generator EXPLODED VIEW PARTS LIST - WHEEL USE EXISTIN8 FASTENERS TQ SECURE ITEbl Item Part # Description B4217 ASSEMBLY, H andle BI764 LEG, Mounting 52858 NUT, Locking Hex M8 - 1.25 39287 HHCS, M8 - 1.25x 45...
-
Page 20: Limited Warranty
PORTABLE GENERATORS GENERAC PORTABLEPRODUCTS (hereafter referred to as the COMPANY) warrants to the original purchaser that the alternator and control panel for its portable generator wilt be free from defects in materials or workmanship for the items and period set forth below from the date of original purchase. This warranty is not transferable and applies only to portable generators driven by a GN-Series engine.