Table of Contents
Advertisement
Quick Links
GEN
RAC
°]
Portable Products
7500
Portable
Generator
Owner's Manual
Model No. 1315-0 (7,500 Watt AC Generator)
Manual No. B4369 Revision 3 (9/19/2000)
Visit our Generac
website:
www.generac-portables.com
This is the safety alert symbol. It is used to alert you to potential personal injury hazards.
Obey all safety messages that follow this symbol to avoid possible injury or death.
Advertisement
Table of Contents
Related Manuals for Generac Portable Products 1315-0
Summary of Contents for Generac Portable Products 1315-0
- Page 1 Generator Owner's Manual Model No. 1315-0 (7,500 Watt AC Generator) Manual No. B4369 Revision 3 (9/19/2000) Visit our Generac website: www.generac-portables.com This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages that follow this symbol to avoid possible injury or death.
-
Page 2: Equipment Description
• Sevengallon overhead fuel tank with fuel gauge. • The generator's revolving field is driven at about 3600 rpm by a Generac Power Systems 15 HP electric DANGER! You must isolate the generator... - Page 3 Generac Portable Products 7,500 EXL Generator • The generator produces a very powerful voltage that can • Never operate the generator: cause serious injury or death by electrocution. Never in rain; in any enclosedcompartment; when connected touch bare wires or receptacles. Never permit a child electrical devices overheat;...
- Page 4 Generac Portable P roducts 7,500 EXL Generator INSTALL WHEEL KIT AND • Slide a wheel on each end of the axle and secure with washer and retaining pin. If wheel does not spin freely, BATTERY TRAY omit one or both washers.
- Page 5 Generac Portable Products 7,500 EXL Generator • Connect one end of the red battery cable to the Installing Tray and Battery outboard terminal of the engine start switch. To obtain electric start, you must purchase and installa • Connect other end of the red battery cable from the 12 Volt DC battery (Series U1-109).
-
Page 6: Your Generator
Generac Portable P roducts 7,500 EXL Generator KNOW YOUR GENERATOR Read this owner's manual and safety rules before operating your generator. Compare the illustrations with your generator, to familiarize yourself with the locations of various controls adjustments. Save this manual for future reference. -
Page 7: Add Gasoline
Generac Portable Products 7,500 EXL Generator BEFORE STARTING • Use regular UNLEADED gasoline with the Generator engine. Do Not use premium gasoline. Do Not mix oil ENGINE with gasoline. • Clean area around fuel fill cap, remove cap. Add Oil •... - Page 8 Generac Portable Produc_s 7,500 EXL Generator OPERATING 5A. For electric s_rUng, press star_ switch on genera_or cradle until engine s_r_s. To prolong :he life of the G EN ERATO R starter components, press the s_r_er buL_con for no more :han I5 seconds, then pause for 30 seconds.
-
Page 9: Battery Safety
Generac Pori_ble Products7,500 EXL Generator To recharge 12 Volt batteries, proceed as follows: Operating Automatic Idle Control • Checl( fluid level in all ba_cery cells. If necessary, add ThTs control Tsdesigned to greatly improve fuel economy, ONLY distilled wa_r to each cell. Oo Not... - Page 10 40=F [4=C]. RECEPTACLES Under cer_in weather conditions (temperatures below 40°F [4°C] and a high dew point), your Generac generator may experience icing of :he carburetor and/or the This generator is equipped with :he following receptacles: crankcase breather system.
- Page 11 Generac Pori:able Products7,500 F..XL G enerator This receptacle powers 120 Volt AC, single phase, 60 Hz loads requiring up to 3,600 w_cs of power (3.6 IcW). Or it 8-WssO dSst will operate 240 Volt AC, single phase, 60Hz loads up to 7,200 w_cs (7.2 IcVV).
- Page 12 Generac Pori_ble Produc_s 7,5,00 EXL Generator DON'T OVERLOAD • If the appliance, tool or motor does not give wa_i_ge, multiply 120 Volts times ampere rating to determine GENERATOR wa_s (volts x amps = wa_i_), • Some electric motors, such as inductJon _/pes, require...
-
Page 13: Specifications
Generac Portable Products 7500 EXL.Generater SPECIFICATIONS To Clean the Generator Maximum Surge Watts ....9.375 watts • Use a d_mp cloth :o wipe exterior surfaces cle_n. Continuous Wattage Capacit7 ..... 7.500 watts • Soft, bristle brush m_y be used to loosen c_ked on dire Power Factor ......... -
Page 14: Troubleshooting
C-onnect another device thatis in Connected device Tsbad. output is available, good condition. Fault Tngenerator. Contact Generac service facility, ShorI; circuit in a connected load. Disconnect shorted electrical load. Generator is overloaded. See "Don't Overload Engine runs good but bogs Generator"... - Page 15 GerleracPortable Produ_s 7,500 EXL Generator NOTES...
- Page 16 Generac Pori_ble Products 7,5.00 F_XL Generator ELECTRICAL SCH EMATIC PDWER PDWER LRE_ LD P IDLE _LrI TCH...
- Page 17 GerleracPortable Produ_s 7,500 EXL Generator WIRING DIAGRAM AUTD RESET IDLE CDNTRDL SWITCH 11 _ BLUfWHT "X/ TRANSFDRHER IDLE CBNTRBL FEEDbaCK • PDS_ BRUSH ELECTRIC CLDSE_T TD START GRDUND TD REAR 3EARINO CARRIER BDTTDH PDVER REGULATDR _BARD SP_EK PLUG ENGINE BLDCK...
- Page 18 Generac Pori_ble Produces 7,S00 EXL Generator EXPLODED VIEW- MAIN UNIT < DETAL TO $TART_ E_ECIRIC 8TART SWITCH...
-
Page 19: Parts List
Generac Portable Products7,500 EXL Generator 2¸¸¸¸¸¸ .., ..PARTS LIST- MAIN UNIT Item Pat't# Deser!pt!on Item Part# QL'_/ Description G02432 CRADLE 850001 CLIP, i_sula_ie_ G9253! SUPPORT,E_gine 48!4:353621 WIREi Gou_d G9273! SUPPORT,E_gine &Muffler 26850 4922471 HOUSING, Engi_e DECALi B!342G ASSEMBLY,_oter DECAL, He_ Shield .... - Page 20 Generac Pori;_ble Produc_s 7,500 EXL Generator EXPLODED VIEW PARTS LIST - WHEEL Item Part# Description B93393A HANDLE 89742 WHEEL 93693A AXLE 87005 PIN, Rer_T_T_g B89635 SPACER, W heel B93696 LEG, Support 27007 MOUNT, Vibration 42909 CAPSCREW, Hex Hd. M8 - 1.25x 30...
- Page 21 Generac Portable Products7,500 EXL Generator 2¸¸¸¸¸¸ .., ..EXPLODED VIEW PARTS LIST - CONTROL PANEL 17 18 € Item Part# Qty, Description Item Part# Qty, Description BB4451 PANEL, Control 68759 OUTLET, 20A, 120V 23897 43180 WASHER, #I0 H5 Flat...
- Page 22 Generac Portable Produc_s 7_500 EXL Generator NOTES imam...
- Page 23 GerleracPortable Produ_s 7,500 EXL Generator NOTES...
-
Page 24: Limited Warranty
LIMITED WARRANTY "GN" ENGINE DRIVEN PORTABLE GENERATORS GENERAC PORTABLE PRODUCTS (hereafter referred :o as the COMPANY) warrants :o the original purchaser :ha: :he al:erna:or and control panel for Tts portable generator wTII be free from defects Tnma:erials or _rkmanship for the Ttems and period se;...