Weil-McLain GOLD CGS 550-110-260/0107 Manual page 28

GOLD CGs Gas-Fired Water Boiler — Boiler Manual
7a
Start-up — preparation
Inspect system water piping
After filling the boiler and system with water,
piping throughout the system for leaks. If found, repair
immediately. Repeat this inspection after the boiler has
been started and the system has heated up.
7b
Start-up — operate boiler
Final check before starting
boiler
9
• Read manual Section including the
instructions 9c
(Section ).
• Verify the boiler and system are
Start-up preparation
• Verify the
7a
tion have been completed.
Start the boiler
• Follow the Operating instructions
to start the boiler.
• See Section 7c if boiler fails to start.
Check system and boiler
Do not use
cleaning or sealing compounds
in boiler system. Severe damage to
boiler will occur, resulting in sub-
stantial property damage.
8
Leaks must be repaired at once.
Failure to do so can damage the
boiler, resulting in substantial prop-
erty damage.
petroleum-based
Do not use
cleaning or sealing compounds
in boiler system. Severe damage to
boiler will occur, resulting in sub-
stantial property damage.
Operating
Check system piping for leaks
1.
full of water
.
immediately.
procedures of Sec-
. Vent air from system
with circulation and cause heat distribution problems and noise.
3. Inspect vent system
rosion, physical damage or sagging. In addition — Check for gas-tight
from Section 9c
seal at every connection and seam.
4. Check around the boiler
petroleum-based
tion
Verify operation
5.
tion
page.
(continued)
Inspect base insulation
Check to make sure
inspect all
four sides of the base. If insulation is damaged or dis-
do not
placed,
insulation.
Eliminate all system leaks
water will reduce boiler life. Minerals can build up in
sections, reducing heat transfer, overheating cast iron,
and causing section failure.
using manual vents. Air in the system will interfere
thoroughly for signs of deterioration from cor-
Venting system must be sealed gas-tight
flue gas spillage and carbon monoxide emissions which
will result in severe personal injury or death.
for gas odor following the procedure of Sec-
7a of this manual.
7b
per Section
8 Installation and service certificate
, and fill in the
insulation is secure
operate boiler. Replace or reposition
Failure to replace
damaged insu-
lation or reposition insulation can
result in a fire hazard, causing severe
personal injury, death or substantial
property damage.
The boiler contains ceramic fiber
and fiberglass materials. Use care
when handling these materials per
page 64
instructions on
manual. Failure to comply could
result in severe personal injury.
. Continual fresh makeup
. If found, shut down boiler and repair
. Perform check-out procedure in Sec-
on the same
Part number 550-110-260/0107
against all
of this
to prevent