Page 1
SEARS OWNER"S MANUAL Model 919.679500 I (RRFTSMRN] 1201240 VOLT " 5000 WATT GENERATOR IMPORTANT:. Read the Safety Guidelines and All Instructions Carefull • SAFETY GUIDELINES Before Operating • ASSEMBLY • OPERATION • MAINTENANCE • TROUBLESHOOTING • REPAIR PARTS Sold by Sears Canada, Inc., Toronto,...
Page 2
Sears will repair, free of charge, any defect in material and workmanship. If your Craftsman engine is used for commercial or rental purposes, this warranty applies only for 90 days form the date of purchase. This warranty does not cover: Expendable items such as spark plugs and air filters, which become worn during normal use.
SAFETY GUIDELINES - DEFINITIONS This manualcontainsinformation that I _I_CAUTION I A DANGER is important for you to know and URGENT SAFETY INFORMATION - A HAZ- Information for preventing damage understand.This informationrelates ARD THAT WILL CAUSE SERIOUS INJURY equipment. to protecting YOUR SAFETY and OR LOSS OF LIFE.
READ AND UNDERSTAND ALL WARNINGS BEFORE All'EMPTING TO OPERATE GENERATOR. RISK OF ELECTROCUTION AND FIRE (cont'd) HAZARD WHAT COULD HAPPEN HOW TO PREVENT IT Operation of generator in rain, wet, icy, Water is an excellent conductor of Operate generator in a clean, dry, well or flooded conditions.
READ AND UNDERSTAND ALL WARNINGS BEFORE ATTEMPTING TO OPERATE (_ENERATOR. RISK OF FIRE HAZARD WHAT COULD HAPPEN HOWTO PREVENTIT Attempting to fill the fuel tank while the Gasoline and gasoline vapors can Turn engine off and allow it to cool engine is running.
Page 6
READ AND UNDERSTAND ALL WARNINGS BEFORE ATTEMPTING TO OPERATE GENERATOR. Risk of Injury and ProDertv Damage When Transporting Generator HAZARD WHAT COULD HAPPEN HOW TO PREVENT IT Fire, Inhalation, Damage to Vehicle Fuel or oil can leak or spill and could If generator is equipped with a fuel Surfaces result in fire or breathing hazard, seri-...
READ AND UNDERSTAND ALL WARNINGS BEFORE ATTEMPTING TO OPERATE GENERATOR. RISK OF UNSAFE OPERATION HAZARD WHAT COULD HAPPEN HOW TO PREVENT IT Operation of generator in careless All sources of energy include the poten- • Review and understand aUof the manne[ tial for injury.
READ AND UNDERSTAND ALL WARNINGS BEFORE ATTEMPTING TO OPERATE GENERATOR. RISK FROM LIFTING HAZARD WHAT COULD HAPPEN HOW TO PREVENT IT Lifting a very heavy object. Serious injury can result from attempt- The generator is too heavy to be lifted ing to lift too heavy an object.
Page 9
INSTALLING WHEEL Locate the engine support. Place one wheel bracket (4) on top of support as shown in illustration below. The Sears Wheel Kit was designed to greatly improve Align with the pre-ddlled holes in support. Place 2 the portablility of your generator. You will need (2) 1/2" cap screws (9) through holes in bracket and support.
KNOW YOUR GENERATOR CIRCUIT BREAKER- Each receptacle has a circuit breaker to protect the generator from overloading. Read this Owner's Manual and Safety Rules be- fore operation of your Generator. Compare this 120 VOLT RECEPTACLES- Used to supply 1800 watts of illustration with your generator to famUiarize yourself electrical power per receptacle or a combination of 3600...
Page 11
RECEPTACLES The guide below is provided to assist you in determining the appliances and tools that can be ran with the wattage Yourgenerator is equipped with duplex 120 volt receptacles capacity of your generator. and a twistlock 240 volt receptacle. The unit is also equipped with a 15 amp circuit breaker for the 120 volt receptacles and a 20 amp circuit breaker for the 240 volt receptacle which is provided to protect the...
Generator To Main Electrical Supply Your Craftsman generator engine is equipped with Low Oil Shutdown, Low Oil Shutdown is a safety device Potential hazards exist when a electrical generator is con- designed to protect your engine from damage in the nected to the main electrical supply coming into the house.
Page 13
• On the engine there is a choke/run lever. Place this • Plug in the desired 120 or 240 volts tools. lever to the choke position. • DO NOT connect 240 volt equipment to the 120 volt duplex receptacles. FULl. CHOKE Pt_tTION •...
GENERAL RECOMMENDATIONS Reinstall the drain plug. Make sure it is tightened securely. The warranty of the generator does not cover items that have been subjected to operator abuse or negligence. To • Fill the crankcase with new oil of the proper type (See receive full value from the warranty, operator must maintain Adding Oil Section), to the Full mark on the dipstick.
Before running engine, clean muffler area to remove Clean and Replace Spark Plug all combustible debris. Change the spark plug every 100 hours of operation or once each year, whichever comes first. This will help your engine to start easier and run better. .030"...
Page 16
CAUSE CORRECTION PROBLEM 1. Add fuel or oil. Low on fuel or oil. Engine will not start Ignition switch in "Off" position. 2. Turn to "ON" position Faulty spark plug. 3. Replace spark plug. Choke in wrong position. 4. Adjust choke accordingly. Fuel shut-off valve in closed 5.
Page 18
CRAFTSMAN 5000 GENERATOR 919.679500 ORIENTWITH VENTS DOWNWARDAS SHOWN 30 31 TOROUETO204-2641N.I.BS TORQU E U NTIL THREADS RU N OUT TORQUE TO 60-70 IN-LBS S HOWN FOR REFERENCE ONLY 34" 35 TOROU E TO 120-144 IN-LBS TORQU E TO 30-40 IN-LBS...
CALIFORNIA & US EPA EMISSION CONTROL WARRANTY STATEMENT The U. S. Environmental Protection Agency ('EPA"), the California Air Resources Board ("CARB') and Tecumseh Products Co. are pleased to explain the Federal and Califomia Emission Control Systems Warranty on your new utility or lawn and garden equipment engine.
EMISSION CONTROL SYSTEM WARRANTY Emission Control System Warranty ('ECS Wananty') for 1995 end later model year Califomta utility and lawn and garden equip ment engines (for other states, 1997 and later model year engines): A. APPLICABILITY: This warranty shall apply to 1995 and later model year California utility and lawn and garden equipment engines (for other states, 1997 and later model year engines1, The ECS Warranty Pedod shall begin on the date the now engine or equipment is delivered to its original, end-use porcnaser, and shall continue for 24 consecutive months thereafter.
Page 26
Dear Customer, In manufacturing this product, many steps have been taken to provide you with the highest quality. Unfortunately, errors or omissions occasionally occur. In the event that you find a missing or defective part, please contact your nearest Sears store. SERVICEAND REPAIRPARTS CALL 1-800-665-4455 Keep this number...