Flowmeter And Humidifier; Cell Electrolyte Level; Reservoir - Teledyne 356WA Instruction Manual

T T T T T race Oxyg race Oxyg race Oxyg race Oxygen Anal en Anal en Anal en Analyz
race Oxyg en Anal
After the analyzer has been put into operation and calibration has been
accomplished, routine inspection will be required for normal operation.
The flowmeter and humidifier column must be checked daily to insure
proper flow, and corrected as necessary. Refer to Section 2.2: Humidifier
and 4.4: Throttle Valve .
The level of electrolyte in the cell must be checked daily and adjusted
as necessary. Refer to Section 4.2.3: Cell Installation . The proper level for
the electrolyte is when the bottom edge of the sensor screen is wetted but not
immersed. Approximately
pool of electrolyte.
The water level in the reservoir should be checked at least every two
weeks. Follow this procedure:
a) Remove the cap from the filler spout.
b) Obtain a clean glass tube about 4 to 5 inches long and about ¼ "
c) Lower the tube into the tank through the filler spout until it
d) Place a finger over the end of the tube, and withdraw the tube
e) If the water level in the reservoir is below 1 "
f) Replace the filler spout cap securely after verifying that the O-
yz yzer er er er er yz yz Maintenance & Maintenance & Maintenance & T T T T T r r r r r oub
Maintenance & Maintenance &
Maintenance & Maintenance & T T T T T r r r r r oub Maintenance &
Maintenance & Maintenance &

5.1 Flowmeter and Humidifier

5.1 Flowmeter and Humidifier 5.1 Flowmeter and Humidifier
5.1 Flowmeter and Humidifier 5.1 Flowmeter and Humidifier

5.2 Cell Electrolyte Level

5.2 Cell Electrolyte Level 5.2 Cell Electrolyte Level 5.2 Cell Electrolyte Level 5.2 Cell Electrolyte Level
3
/ " of the silver electrode should extend into the
32

5.3 Reservoir

5.3 Reservoir 5.3 Reservoir
5.3 Reservoir 5.3 Reservoir
outer diameter.
touches bottom.
from the tank. The height of water in the tube is the height
of the water level in the tank.
distilled water.
ring seal is in good condition.
Teledyne Analytical Instruments
oub oubleshooting 5 oub leshooting 5 leshooting 5 leshooting 5
oub leshooting 5
oubleshooting oub oub leshooting leshooting leshooting
oub leshooting
1 " 1 " 1 " 1 ", add a quart of
5-1