Front Fender; Underhood Dimensions - Mazda 3 Manual

w/Burglar Alarm System BN8P-56-620
w/o Burglar Alarm System BN8V-56-620
14 Lever, Latch BN8F-56-625
15 Cable, Latch Release
To 11-1-03 BP4K-56-720B
From 11-1-03 BP4K-56-720C
16 Clip, Front Cable GJ6A-56-731A
17 Clip, Center Cable LA89-67-C41
18 Clip, Cable Rear D001-56-731
19 Rod, Prop
Hatchback BP4K-56-651A
Sedan BN8V-56-651A
COOLING
1 Radiator Assy Z602-15-200C
2 Cock, Drain¶ Z602-15-203
¶Included w/Radiator Assy
3 Bracket, Upper Rad R/L Z601-15-240F
4 Mount, Lower Rad
w/ A/C R/L Z603-15-202A
w/o A/C R/L Z601-15-202B
5 Hose, Radiator
Upper LF50-15-186F
Lower LF50-15-185D
6 Shroud & Fan Z602-15-025B
7 Harness, Fan Z601-66-991
8 Tank, Coolant LF50-15-350
9 Cap, Tank LF50-15-205A
10 Hose, Coolant Tank R Z601-15-383E
L LF50-15-381B
Hose, By-Pass
11 No. 1 L309-15-260
12 No. 2 LF70-15-260E
13 Thermostat Assy
To 2-1-04 LF50-15-170
From 2-1-04 LF50-15-170A
14 Gasket, Cover¶ LF02-15-165
¶Included w/Thermostat Assy
15 Outlet, Water L327-15-17Z
16 Gasket, Outlet LF01-15-169
17 Pump Assy, Water LF01-15-100
18 Gasket, Water Pump¶ LF01-15-116
¶Included w/Water Pump Assy
19 Pulley, Water Pump LF50-15-131
Belt, Drive
2.0L Eng
Man Trans LF51-15-909
Auto Trans LF50-15-909A
2.3L Eng
Man Trans L373-15-909
Auto Trans L372-15-909A
A/C REFRIGERANT CAPACITIES
A/C R-134a Refrigerant Capacity
2004: 18.6 Ozs (1.16 Lbs)
madpl1_g01_
Comments or suggestions? Need assistance? Call 1-800-854-7030 or 858-578-6550. Ext. 8220. Fax 1-888-256-7969 or 858-549-0629.
Page 3—April 22, 2004—13:28:08—Version
A/C /HEATER/VENTILATION
1 Condenser Assy
2 Receiver/Drier¶
3 Bracket, Receiver¶
¶Included w/Condenser Assy
4 Hose, High Pressure
5 Hose, Low Pressure
6 Pipe Assy, Condenser
7 Switch, Pressure¶
¶Included w/Condenser Pipe Assy
8 Compressor Assy
9 Pulley Kit¶
¶Included w/Compressor Assy
10 Bracket, Compressor
11 Evaporator/Heater Assy
w/ A/C
w/o A/C
12 Case, Heater Upper¶
13 Case, Heater Lower¶
w/ A/C
w/o A/C
14 Motor & Fan Unit¶
15 Lining, Blower¶
16 Resistor, Blower¶
Procedure Explanation Pages Must Be Used with the Above Text for an Accurate Damage Report.
BPYK-61-48Z
BP4K-61-501
BP4K-61-502
BP4S-61-4G0B
BP4S-61-462C
BP4K-61-46X
B01A-61-503
BP4S-61-K00
BP4S-61-L20
BP4S-61-458B
BNYR-61-42Y
BN8P-61-130F
R/L BP4K-61-B01-2
R BP4K-61-A02A
L BN8P-61-A01A
R BP4L-61-A02A
L BN8P-61-A01A
BP4K-61-B10
BP4K-61-B04
BP4K-61-B15
MAZDA3 2004
17 Link Set, Temp¶ BP4K-61-A20
18 Link Set, Mode¶ BP4K-61-A30
19 Evaporator¶ BPYK-61-J1Z
20 Sensor, Valve¶ BP4K-61-J22
21 Core, Heater¶ BP4K-61-A10
22 Case, Evaporator¶ BP4K-61-A03
23 Valve, Expansion¶ BP4K-61-J14
Seal, Cooling Unit¶
24 Upper BP4K-61-J31
25 Lower Outer
w/ A/C BP4K-61-J06
w/o A/C BP4L-61-J06
26 Lower Inner BP4K-61-J12
27 Pipe, Evaporator¶ BP4K-61-J15
¶Included w/Evaporator/Heater Assy

FRONT FENDER

1 Fender
Hatchback R BP4K-52-111C
L BP4K-52-211C
Sedan R BN8V-52-111C
L BN8V-52-211C
2 Bracket, Fender R BP4K-53-290
L BP4K-54-290
3 Liner, Fender
Sport Type R BP4L-56-130D
L BP4L-56-140D
Std Type R BP4K-56-130E
L BP4K-56-140E
4 Fastener, Liner
w/Mudguard (23) NA01-56-145
w/o Mudguard (27) NA01-56-145
5 Mudguard Assy R BP4K-51-840A
L BP4K-51-850A
6 Clip, Mudguard¶ R/L BP4K-51-SJ3
¶Included w/Mudguard Assy
7 Grommet, Clip R/L GJ6E-51-832A
8 Rivet, Mudguard (2/Side) R/L B092-51-833
Lamp, Repeater-See Front Lamps Section

UNDERHOOD DIMENSIONS

Information not available at time of publication.
FRONT INNER STRUCTURE
FRONT
1 Support Assy, Radiator BP4K-53-110F
2 Nut, Support Mounting¶ (6) FB01-50-133C
¶Included w/Radiator Support Assy
3 Support, Hood Lock BP4K-52-15YA
4 Plate, Seal R BP4K-56-251
5 Guide, Air L BP4K-56-L21
6 Fastener, Air Guide L GD7A-50-EA1
7 Cover, Hole BP4K-56-078A
SIDE
Illustration Located in Next Column
1 Apron & Sidemember Assy R BPY0-53-20X
L BPY0-54-20X
2 Apron Assy¶ R BP4K-53-210L
L BP4K-54-210J
3
Manufacturer