Bionaire BCM1745 Instruction Leaflet

BCM1745C05EFM1.qxd 8/5/05 11:19 AM Page 1
HUMIDIFIER SAFETY
PLEASE READ AND SAVE
THESE IMPORTANT
cool mist
SAFETY INSTRUCTIONS
humidifier
BCM1745
MODEL
IMPORTANT SAFEGUARDS
When using electrical appliances, basic safety precautions
should always be followed to reduce the risk of fire, electric
shock, and injury to persons, including the following:
1. Read all instructions before using the appliance.
2. To avoid fire or shock hazard, plug the appliance directly
into a 120V AC electrical outlet.
3. Keep the cord out of heavy traffic areas. To avoid fire hazard,
NEVER put the cord under rugs or near heat registers.
4. DO NOT place humidifier near heat sources such as
stoves, radiators, and heaters. Locate your humidifier
on an inside wall near an electrical outlet. The humidifier
should be at least 4" away from the wall for best results.
5. NEVER place humidifier in an area where it is accessible
to children. NEVER use humidifier in a closed room,
particularly where a child may be sleeping, resting, or
playing (a closed room may result in excessive humidity).
6. WARNING: Do not attempt to refill humidifier without first
unplugging the unit from its electrical outlet. Failure to heed
this warning may cause personal injury. Be sure to unplug
the unit by pulling on the plug and not the cord.
7. Never place anything over moisture outlet when the unit
is running.
8. NEVER drop or insert any object into any openings
unless instructed in this manual.
9. DO NOT operate any appliance with a damaged cord
or plug, after the appliance malfunctions, or if it has
been dropped or damaged in any manner. Return
appliance to manufacturer for examination, electrical or
mechanical adjustment, or repair.
10.Use appliance only for intended household use as described
in this manual. Any other use not recommended by the
Read instructions before operating.
manufacturer may cause fire, electric shock, or injury to
Retain for future reference.
persons. The use of attachments not recommended or
Instruction Leaflet
sold by the manufacturer may cause hazards.
11.DO NOT use outdoors.
12.Always place humidifier on a firm, flat, level surface.
INFO-LINE
A waterproof mat or pad is recommended for use
If after having read this leaflet, you have any questions
under the humidifier. NEVER place it on a rug or carpet,
or comments on your humidifier,
or on a finished floor that may be damaged by exposure
call 1-800-253-2764 in North America.
to water or moisture.
13.DO NOT allow the Moisture Outlet to directly face the wall.
Moisture could cause damage, particularly to wall paper.
3. Empty the tank after 20 minutes, and rinse well with
4. Insert a new filter into the filter support in the base (Figure 2).
water until the bleach smell is gone. Dry with a clean
5. Replace the main housing and then the tank.
cloth or paper towel.
6. Repeat Operating Instruction steps.
4. Check the Filter Check™ Indicator to see if it is time to
It will take about 30 minutes for the humidifier to reach
see if it is time to replace the filter. Depending on your
maximum output.
water hardness, it may be necessary to change the
NOTE: You can purchase replacement filters (model
filter every 1-2 months.
BWF64) at a local retailer, by calling 1-800-253-2764 ,
5. Refill the water tank with fresh tap water, replace the
filling out the accessory card, or by visiting
housing of the humidifier, and then the water tank. Plug
www.bionaire.com It is recommended that a replacement
into the electrical outlet, and turn the power ON.
filter is purchased for uninterrupted use.
NOTE: Please be sure to wipe up any spilled cleaning
solution as it may damage furniture or floors.
CLEANING AND MAINTENANCE:
Humidifiers provide comfort by adding moisture to dry,
Storage Instructions
heated indoor air. To get the most benefit from the
If your humidifier will not be in use for two days or more,
humidifier and avoid product misuse, follow all
or at the end of the season follow these instructions.
instructions carefully, specifically the operation, care and
1. Clean and dry the humidifier thoroughly as per the
maintenance guidelines. Please note this is an electrical
"Weekly Maintenance" instructions.
appliance and requires attention when in use.
2. Let the humidifier dry completely before storing. Do not
In addition, if you do not follow the recommended care
store with water inside the base or water tank.
and maintenance guidelines, micro-organisms may be
3. Remove the tank cap. Do not store with the tank cap
able to grow in the water within the humidifier's reservoir.
in place.
4. Store in a cool dry location.
Daily Maintenance:
1. Before cleaning, set control to the OFF position and SERVICE INSTRUCTIONS
unplug the unit from the electrical outlet.
1. Do NOT attempt to repair or adjust any electrical or
2. Lift off the tank and the housing of the humidifier.
mechanical functions on this unit. Doing so will void
3. Carry the base and the tank to the sink, remove the
the Warranty. The inside of the unit contains no user
wick filter, then drain and rinse the base and tank
serviceable parts. All servicing should be performed
thoroughly to remove any sediment or dirt. Wipe clean,
by qualified personnel only.
and dry with a clean cloth or paper towel.
2. If you need to exchange the unit, please return it in its
4. Put the filter back in the filter supports, replace the
original carton, with a sales receipt, to the store where
housing, then refill the tank with with cool tap water as
you purchased it. If you are returning the unit more than
instructed in Pre-Operating Instructions. Do not overfill.
30 days after the date of purchase, please see the
5. If moisture forms on walls or windows, turn off the
enclosed Warranty.
humidifier. Weekly Maintenance:
3. Should your humidifier require service, please call
1-800-253-2764 in North America for further
Weekly Maintenance:
assistance.
To Remove Scale
4 . If you have any other questions or comments, feel
1. Repeat steps 1-3 above and remove the circular wick filter.
free to write to us or visit our website
2. Clean the base by partially filling the base with one-8
www.bionaire.com
oz. Cup of undiluted white vinegar. Let solution stand
20 minutes, cleaning all interior surfaces with a soft
brush. Dampen a cloth with undiluted white vinegar and
wipe out entire base to -remove scale.
The Holmes Group, Inc.
3. Rinse with clean warm water to remove scale and the white
Consumer Service Department
vinegar solution before beginning to disinfect the tank.
13052 Jurupa Avenue
To Disinfect Tank:
Fontana, CA 92337
1. Fill tank with 1 teaspoon of chlorine bleach and 1
gallon of water.
2. Let the solution stand for 20 minutes, swishing every
few minutes, wet all surfaces.
14.Humidifier should be unplugged when not in use. DO NOT DEFEAT THE SAFETY PURPOSE OF THIS
POLARIZED PLUG IN ANY WAY.
15.NEVER tilt, move, or attempt to empty unit while it is
operating. Shut off and unplug before removing the
PLEASE READ AND SAVE
water tank and moving the unit.
THESE IMPORTANT
16.This humidifier requires daily and weekly maintenance
to operate appropriately. Refer to daily and weekly
SAFETY INSTRUCTIONS
cleaning procedures. Use only cleaners and additives
recommended by the manufacturer.
17.NEVER use detergents, gasoline, glass cleaner, furniture CONSUMER SAFETY INFORMATION
polish, paint thinner, or other household solvents to
NOTE: This is an electrical appliance and requires
clean any part of the humidifier.
attention when in use.
18.Excessive humidity in a room can cause water
NOTE: If moisture forms on the walls or windows of the
condensation on windows and some furniture. If this
room, turn off the humidifier. The room already has plenty
happens, turn the humidifier OFF.
of humidity and additional moisture may cause damage.
19.Do not use humidifier in an area where humidity level is
NOTE: DO NOT block air inlet or outlet.
in excess of 50%. Use a hygrometer, available at your
local retailer or through the manufacturer, to measure
CORD AND PLUG INSTALLATION SAFETY
the humidity.
INSTRUCTIONS
20.DO NOT attempt to repair or adjust any electrical or
mechanical functions on this unit. Doing so will void The length of cord used on this appliance was selected to
your warranty. The inside of the unit contains no user reduce the hazards of becoming tangled in, or tripping
serviceable parts. All servicing should be performed by
over a longer cord. If a longer cord is necessary an
qualified personnel only.
approved extension cord may be used. The electrical
21.Never place housing under water flow or immerse in liquids.
rating of the extension cord must be equal to or greater
than the rating of the humidifier. Care must be taken to
22.Do not plug in the cord with wet hands: electric shock
arrange the extension cord so that it will not drape over
could result.
the countertop or tabletop where it can be pulled on by
23.Do not pour water in any openings other than the
children or accidentally tripped over.
water tank.
24.To prevent damage to surfaces, do not place humidifier
HOW COOL MIST WORKS
under overhanging surfaces.
Your Bionaire
25.NEVER operate unit without water in the tank.
the rear air intake grill area. This air is then passed
26.Use both hands when carrying full tank of water.
through a moisture–laden wick filter, which retains the
27.Never unplug unit while it is running as arcing may minerals and deposits in the water. The resulting moist air
occur and cause injury. Use power switch to turn off is directed back into the room from the top air grill.
unit before unplugging.
NOTE: This humidification system provides a cool, invisible
moisture output. It is normal not to see the mist.
PLEASE SAVE THESE
NOTE: A humidity level below 20% can be unhealthy and
uncomfortable. The recommended humidity level is
INSTRUCTIONS
between 40%-50%.
CONSUMER SAFETY INFORMATION PRE-OPERATING INSTRUCTIONS:
THIS PRODUCT IS EQUIPPED 1. Be sure the unit is disconnected from the electrical
WITH A POLARIZED AC PLUG (a outlet and the power switch is in the OFF position.
plug having one blade wider than 2. Lift off the humidifier housing and the water tank (see
the other). This plug will fit into the
Fig. 1). Check to see that the circular, extended life filter
power outlet only one way. If the is installed correctly around the filter supports in the
plug does not fit fully into the base (see Fig. 2). Replace the humidifier housing.
outlet, reverse the plug. If it still 3. Twist off the tank cap by turning counter-clockwise and
does not fit, contact qualified personnel to install the proper fill the water tank with cool, tap water. Replace the tank
outlet.
cap by firmly turning clockwise and then replace the
Fig. 4 Fig. 5
FREQUENTLY ASKED QUESTIONS
Trouble Shooting for your Cool Mist Humidifier
Trouble Probable Cause Solution QUESTION
Filter has not
• Mist output minimal to Wait 15 minutes before
none. absorbed water. starting humidifier. • What are the variables that
Mineral buildup in base. Regular cleaning of tray affect run time?
after each use will help
keep the unit functioning
properly.
Humidistat is set too low. Set the humidistat to
high.
Wick Filter needs Replace your wick filter
to be replaced. (BWF64) by calling
1-800-253-2764, or visit
www.bionaire.com.
Normal operation. Mist is invisible.
Check to see if inlet or
outlet grills are blocked.
• Water leaks from water Rubber O-ring is missing Remove tank
reservoir. or improperly placed. cap then replace
or reposition ring.
• How do I remove film on
Tank Cap not Tighten the
water tank?
tight enough. tank cap.
• How can I extend the run
• Water Filter turns brown. Your filter needs Replace your wick filter
time?
to be changed. (BWF64) by calling
1-800-253-2764, or visit
www.bionaire.com.
In areas with hard water Use Clean Away TM Solution
(DMS216), to order call
your wick filter will need
to be changed frequently. 1-800-253-2764, or visit
www.bionaire.com.
Mineral deposits cause
• Film on water reservoir. Replace your wick filter
film on tank to build up.
(BWF64) by calling
1-800-253-2764, or visit
www.bionaire.com.
Filter needs
• Water cloudy. Refill using cool water.
to be replaced.
Using warm water
to refill water tank.
Humidifier is reacting Set the humidistat to a
• Humidistat cycles on/off.
to room humidity level.
higher or lower setting.
Add liquid soap or
Over tightened.
• Very tight reservoir cap. petroleum jelly to cap
gasket to ease opening.
water tank on the base. THE TANK WILL
IMMEDIATELY EMPTY ABOUT A QUARTER OF THE
WATER INTO THE BASE OF THE HUMIDIFIER (the
humidifier tank and base hold about 1.4 gallons).
NOTE: The BCM1745 produces a clean, cool, INVISIBLE
moisture. It is normal not to see the moisture.
To reach the maximum water capacity, remove and fill the
tank a second time after it finishes emptying into the
base. Replace the tank onto the base. A small amount of
water may empty into the base.
4. Plug the power cord into the electrical outlet.
OPERATING INSTRUCTIONS:
1. Move the Humidity Control Switch to the HI position.
Move the Humidity Control to the LO setting to lower
the humidification rate. Allow up to 30 minutes for the
filter to fully absorb water and the unit to produce the
maximum moisture output.
NOTE: We recommend the use of the hygrometer which
reads the actual humidity level in your room. A humidity
level below 20% can be unhealthy'and uncomfortable.
The recommended humidity level is between 40% to
50%.
Figure 1
A
A. Carry Handle
B. Humidifier Tank
C. Filter Check
Indicator
D. Humidifier
® Cool Mist humidifier draws dry air through
Housing
E. 3-Speed
Humidity Control
F. Humidifier Base
B
Figure 2
A. Circular
Extended
A
Life Filter
B. Humidifier
Base
C. Circular Filter
Supports
B
WARRANTY
The Manufacturer warrants to the original retail purchaser,
for ONE (1) YEAR from the date of original purchase,
ANSWER either to repair or replace at its option, without charge
(parts and labor), any supplied or manufactured part of
The estimated run time for this humidifier is based on
average room conditions. The actual run time of your this humidifier which, upon inspection by an authorized
humidifier is dependent on numerous vari ables such
service center, proves to have failed in normal use due to
as:
1. Air exchange in the room where the humidifier is
defects in material or workmanship, or, at its option, to
placed.
2. Room construction where the humidifier is placed. replace the unit.
3. Temperature of the room where the humidifier is
placed. Operation under conditions other than those
4. Humidity levels in the room where the humidifer is
recommended or at voltages other than the voltage
placed.
5. Movement of occupants and the opening and indicated on the unit, or any attempts by unauthorized
closing of doors in the room where the humidifier is
personnel to service the unit or modify it, will render the
placed.
6. Home furnishings in the room where the humidifer is
guarantee void.
placed.
The Manufacturer shall not be liable for any personal
See Daily Maintenance instructions. Regular cleaning
injury, property damage or any incidental or consequential
is recommended.
damages of any kind, resulting from defects, malfunctions,
Run your unit on the lowest setting.
If your unit has electronics, set it to your desired humid misuse, improper installation or alteration of the product.
ity level.The unit will turn on and off, which will extend
the run time.
Fill the tank all the way full, place it on the base, let THE MANUFACTURER EXPRESSLY DISCLAIMS ALL
the water empty into the base until it stops bubbling,
RESPONSIBILITY FOR CONSEQUENTIAL
then refill the tank full again. This ensures maximum
water capacity and will extend run time. DAMAGES OR INCIDENTAL LOSSES CAUSED
BY USE OF THIS PRODUCT.
The provisions of this Warranty are in addition to, and not
a modification of, or subtraction from the statutory warranties
and other rights and remedies contained in any
applicable legislation and to the extent that any such
provision purports to disclaim, exclude or limit any such
statutory warranties or other rights or remedies, such
provisions shall be deemed to be amended to the extent
necessary to comply therewith.
FOR WARRANTY SERVICE, PLEASE CALL
1-800-253-2764 IN NORTH AMERICA.
A consumer service representative will help determine
which is the best procedure in order for your humidifier to
be repaired.
KEEP THIS NUMBER FOR FUTURE REFERENCE.
Bionaire ® , the Bionaire ® logo ,Filter Check™ and Clean-
Away™ are trademarks of The Holmes Group, Inc.
Printed In China
2. When the water tank is empty and the water in the
base is almost empty, you need to refill the tank. The
fan will continue to run to help dry the humidifier. Shut
off and unplug the unit. Please follow the Daily Cleaning
Instructions. Filter Check™ (located on the front of the
housing near the grill) will let you know when the filter
needs replacing. Refill the tank as directed in Pre-
Operating Instructions.
3. Plug into the electrical outlet. Turn the power ON.
IMPORTANT:
If you do not plan to use your humidifier for two or more
days, make sure any residual water is drained from the
water tank, base and wick filter to prevent any algae or
bacteria growth in stagnant water.
NOTE:This humidifier holds about 1.4 gallons of water
between the tank and the base and will produce up to 3
gallons of moisture over a 24-hour period, depending on
the room humidity and temperature.
REPLACING THE FILTERS
Through normal use, water borne minerals and sediment
become trapped in the wick filter. The harder your water,
the greater the amount of minerals in the water, and the
more often you will need to change your filter.
You will be able to monitor the life of the filter in your
humidifier by checking the Filter Check™ Indicator. When
the unit is off, the Filter Check™ Indicator will read in the
C
OFF position. After 60 minutes of use, Filter Check™
D Indicator (refer to Figure 3 for close-up
Figure 3
of indicator) will move from the OFF
E
position and indicate your filter condition.
A brand new filter will register in the blue
section reading GOOD filter. After
frequent use of your humidifier, the
F
Filter Check™ Indicator will let you know
when the filter needs to be changed.
When the needle is in the CHANGE section, this means
the proper amount of moisture is not getting into your air
due to the excessive minerals and sediment that have
become trapped on your filter. At this point, you should
replace your filter. It is important to change your filter as
indicated to obtain stated performance level.
TO REPLACE THE FILTER, FOLLOW THE STEPS
BELOW:
1. Be sure the humidifier is switched OFF and
C
disconnected from the electrical outlet.
2. Remove the tank and main housing to access the base
tray (see Figures 1 and 2).
3. Discard the old filter and follow weekly cleaning instructions.
BCM1745C05EFM1