Transportation And Storage; Troubleshooting - Husqvarna 590BTS Operator's Manual

To replace the harness and waist
belt
WARNING:
can make the product fall and cause
injuries.
1. Stop the engine.

Transportation and storage

WARNING:
fire, make sure that there are no leaks or
fumes during transportation or storage.
Make sure that there is no risk of sparks
or fire.
• Empty the fuel tank before transportation or long-
term storage. Push the air purge bulb to make
sure that all fuel is removed. Discard the fuel at
an applicable disposal location.
The engine does not start
Check Possible
cause
Stop switch. The stop
switch is in the
stop position.
Starter pawls. The starter
pawls cannot
move freely.
Fuel tank. Incorrect fuel
type.
Spark plug. Spark plug is
dirty or wet.
The electrode
gap on the
spark plug is
incorrect.
Spark plug is
loose.
1805 - 004 - 20.11.2023
A damaged harness
Transportation and storage
To prevent the risk of

Troubleshooting

Solution
Let an approved service agent replace the stop switch.
Remove the starter cover and clean around the starter pawls.
Let an approved service agent help you.
Drain the fuel tank and fill it with the correct fuel.
Make sure that the spark plug is dry and clean.
Clean the spark plug. Make sure that the electrode gap is correct. Make
sure that the spark plug has a supressor.
Refer to technical data for the correct electrode gap.
Tighten the spark plug.
2. Loosen the straps if it is necessary.
3. Push the clamps through the holes in the frame
to remove the harness and waist belt.
4. Attach the clamps of the new harness and waist
belt through the holes in the frame.
5. Make sure that all straps and clamps are safely
attached to the frame.
• Make sure that the product is clean and that a full
servicing is done before long-term storage.
• Remove the spark plug and put approximately 1–
2 ml of two-stroke oil into the cylinder. Pull the
starter rope handle slowly 3 times and install the
spark plug again.
• Attach the product safely to the vehicle during
transportation.
• Keep the product in a dry, cool and clean space
with good airflow. Keep the product away from
children.
19