Table of Contents
Advertisement
THE MANUFACTURER SUGGESTS THAT THESE RULES FOR SAFE OPERATION BE COPIED AND
POSTED IN POTENTIAL HAZARD AREAS. SAFETY SHOULD BE STRESSED TO ALL OPERATORS AND
POTENTIAL OPERATORS OF THIS EQUIPMENT.
WARNING:
The engine exhaust from this product
contains chemicals known to the state
of California to cause cancer, birth
defects or other reproductive harm.
WARNING:
This product contains or emits chemicals
known to the state of California to cause
cancer, birth defects or other reproductive harm.
Study these "SAFETY RULES" carefully before
installing, operating or servicing this equipment.
Become familiar with the Owner's Manual and with the
unit. The generator can operate safely, efficiently and
reliably only if it is properly set up, operated and main-
tained. Many accidents are caused by failing to follow
simple and fundamental rules or precautions.
Generac cannot possibly anticipate every possible cir-
cumstance that might involve a hazard. The warnings in
this manual, and on tags and decals affixed to the unit,
are, therefore, not all-inclusive. If you use a procedure,
work method or operating technique Generac does not
specifically recommend, you must satisfy yourself that it
is safe for you and others. You also must make sure the
procedure, work method or operating technique that
you choose does not render the generator unsafe.
DANGER: Despite the safe design of this genera-
tor set, operating this equipment imprudently,
neglecting its maintenance or being careless can
cause possible injury or death. Permit only
responsible and capable persons to operate or
maintain this equipment.
DANGER: Generator sets can be dangerous. Only
suitably qualified personnel should attempt to
install or work on this type of equipment.
DANGER: Potentially lethal voltages are generat-
ed by these machines. Ensure all steps are taken
to render the machine safe before attempting to
work on the generator set.
DANGER: Parts of the generator set are rotating
and/or hot during operation. Exercise care near
running generator sets.
For safety reasons, Generac recommends that
the initial start-up of this equipment is carried
out by a Generac Authorized Dealer.
2
Generac
Power Systems, Inc.
®
Important Safety Instructions
GR-210 Generator Set
• Adequate, unobstructed flow of cooling and venti-
lating air is critical to correct generator set opera-
tion. Do not alter the installation or permit even
partial blockage of ventilation provisions, as this
can seriously affect safe operation of the generator
set.
• Diesel engine exhaust fumes contain carbon
monoxide, which can be DEADLY. This dangerous
gas, if breathed in sufficient concentrations, can
cause unconsciousness or even death. This exhaust
system must be properly installed, in strict compli-
ance with applicable codes and standards.
Following installation, you must do nothing that
might render the system unsafe or in noncompli-
ance with such codes and standards. Inspect the
exhaust system regularly to ensure that it is free
from leaks and damage, and that it is not possible
for fumes to enter any area where people or ani-
mals are located. Never operate this equipment
with a leaking or defective exhaust system. Repair
or replace any damaged or leaking component
immediately.
• Keep hands, feet, clothing, etc., away from drive
belts, fans, and other moving or hot parts. Never
remove any drive belt or fan guard while the unit is
operating.
• When working on this equipment, remain alert at
all times. Never work on the equipment when you
are physically or mentally fatigued.
• This generator set may be capable of automatic,
unattended operation, and may start and run at
any time. To prevent possible injury under such
conditions, NEVER work on a generator in auto-
matic mode. Before commencing work, select the
control system to "OFF ," disconnect generator start-
ing battery and isolate any other sources of electri-
cal power to the machine (such as battery charger
or engine heater supplies).
• Remove the fuse from the battery charger before
disconnecting the battery to minimize the chance of
equipment damage.
• Before performing any maintenance on the genera-
tor set, disconnect its battery cables to prevent
accidental start up. Disconnect the cable from the
battery post indicated by a NEGATIVE, NEG or (-)
first. When reconnecting the battery, connect the
NEGATIVE, NEG or (-) last.
• Never use the generator or any of its parts as a
step. Stepping on the unit can stress and break
parts, and may result in dangerous operating con-
ditions from leaking exhaust gases, fuel leakage, oil
leakage, etc.
• Inspect the generator set regularly, and repair or
replace all damaged or defective parts immediately.
Advertisement
Table of Contents
