Page 1
PLASMA DISPLAY TV Chassis : D70A(N)_Carnegie Model : HPP5581X/XAA (HP-P5581) SERVICE Manual PLASMA DISPLAY TV CONTENTS Specifications Alignment and Adjustments Exploded View and Parts List Service Item Schematic Diagrams...
Page 5
To increase and decrease the data of the selected items (ENTER) Confirm your choice(Store OR Enter) SOURCE button Change input source While in Tuner mode, the direct access buttons can be used to select and change channels. ♣ ♣ Samsung Electronics...
Page 6
4) Adjust Items "RGB DRIVES" and Items "RGB CUTOFFS". (c) Video 1) Input Toshiba Pattern (#16) at NTSC-M(MODEL #1) signal. 2) Select "WHITE BALANCE". 3) Adjust items "SUB CONTRA" and "SUB BRIGHT". 4) Adjust Items "RGB DRIVES" and Items "RGB CUTOFFS". Samsung Electronics...
Page 7
R_GAIN YGGAIN Contrast Offset G_GAIN B_GAIN R DRIVE LOGIC R_CR_OFFSET G DRIVE G_Y_OFFSET MPEG B DRIVE B_CB_OFFSET Decoding COMPONENT R CUTOFF Scaler G CUTOFF B CUTOFF SII9993 Memory mode - DVI TMDS HDMI - Component Receiver - Video Samsung Electronics...
Page 12
MICOM WATCHDOG MELODY VOL 2-3-9 WHITE BALANCE Initial Values of Input Modes ITEM VIDEO COMPONENT COMPONENT RF(NTSC) RF(DTV) HDMI (S-VIDEO) (480p/720p/1080I) (480i) SUB CONTRA SUB BRIGHT R DRIVE G DRIVE B DRIVE R CUTOFF G CUTOFF B CUTOFF Samsung Electronics...
Page 14
Vs Adjustment point (R432) Vs Adjustment point (R432) TEST ST POIN INT ☞ Notes 1. When the SMPS-PCB is replaced, the Va, Vs voltages must be checked and adjusted to the proper levels indicated on the panel sticker. 2-10 Samsung Electronics...
Page 15
SIGNAL CABLE(LOGIC ~ ABUS-D3) BN96-01686A ASSY PDP P-CABLE E PCB FPF24R-CBL200122 ND01103-K022 SIGNAL CABLE(LOGIC ~ X-SUS) BN96-01687A ASSY PDP P-CABLE F PCB FPF24R-CBL001502 ND01103-K013 SIGNAL CABLE(LOGIC ~ ABUS-U3) BN96-01688A ASSY PDP P-CABLE G PCB FPF24R-CBL001603 ND01103-K014 SIGNAL CABLE(ABUS ~ ABUS) Samsung Electronics 2-11...
Page 18
③ Remove the stand after you lay the set down. ⑥ You can replace defective smps, the upper fan assy, ⑤ Loosen the screws, and remove the back cover. side a/v pcb, function key pcb, remote signal receiving pcb in this step. 2-14 Samsung Electronics...
Page 19
2-4 section.) 2. When the Digital PCB is replaced, let user go through subscrption process after contacting user's cable service provider. Samsung Electronics 2-15...
Page 20
And remove the display pcb cover. ④ Reassemble in reverse order. ③ You can replace Ready pcb or Tuner pcb. ※ Notes 1. When the Digital PCB is replaced, let user go through subscrption process after contacting user's cable service provider. 2-16 Samsung Electronics...
Page 21
Exploded View & Parts List 3. Exploded View & Parts List 3-1 HPP5581X/XAA Yon can search for the updated part code through ITSELF web site. URL:http://itself.sec.samsung.co.kr Loc.No. Code No. Description;Specification Q'ty S.N.A T0003 BN96-01439A ASSY COVER P-FRONT;55P4,SEA,ABS V0,GRY M0013 T0213 BN67-00136A GLASS;55FHP,MESH,40%,1320*746,T3.0,Bias3...
Page 24
Schematic Diagrams 5. Schematic Diagrams 5-1 IR+CONTROL+CHANNEL(ASSY PCB MISC-DIGITAL, BN94-00578A) This Document can not be used without Samsung’s authorization. CHANNEL B'd CONNECTOR POWER INPUT FOR STAND-BY READY B'd CONTROL CONNECTOR ADD 2 INVERTER 3.3V_D 3.3V_D IC904 3.3V_D S_5V IC903 NC7S04P5X...
Page 25
Schematic Diagrams 5-2 MICOM&I2C EXPANDER(ASSY PCB MISC-DIGITAL, BN94-00578A) This Document can not be used without Samsung’s authorization. I2C EXPANDER S_3.3V_POD C101 100nF IC101 PCA9545PW 3.3V_D SDA_DNIE SDA_DNIE SCL_DNIE SCL_DNIE R123 22ohm SDA_9545C GND_I2C R126 22ohm nRESETO /RESET SCL_9545C 3.3V_I2C GND_BUSSTOP...
Page 26
Schematic Diagrams 5-3 CPU(ASSY PCB MISC-DIGITAL, BN94-00578A) This Document can not be used without Samsung’s authorization. 3.3V_D S_3.3V S_3.3V_CPU BD300 RA300 RA301 MPZ2012S300A BD301 4.7K 4.7K MPZ2012S300A C302 C304 C306 C308 C300 C301 C303 C305 C307 C309 RA302 100uF 100nF...
Page 27
Schematic Diagrams 5-4 CPU_FLASH_MEM(ASSY PCB MISC-DIGITAL, BN94-00578A) This Document can not be used without Samsung’s authorization. S_3.3V_CPU C361 C363 C365 C367 C369 C371 C373 C375 C360 C362 C364 C366 C368 C370 C372 C374 100nF 10nF 100nF 10nF 100nF 10nF 100nF...
Page 28
Schematic Diagrams 5-5 POD(ASSY PCB MISC-DIGITAL, BN94-00578A) This Document can not be used without Samsung’s authorization. MDIA7 MOCLK MDIA6 RSTA MDIA5 R400 S_3.3V_POD WAITA# MICLK 100Kohm S_3.3V_POD S_3.3V_POD IC400 S_5V REG# MDIA4 R401 MIC39100-3.3BS MOVAL MIVAL 4.7Kohm MOSTAT MDIA3 S_3.3V_POD...
Page 29
Schematic Diagrams 5-6 EAGLE+(ASSY PCB MISC-DIGITAL, BN94-00578A) This Document can not be used without Samsung’s authorization. 3.3V_D C500 100nF 3.3V_D MACH JTAG PORT 4.7Kohm R501 CN330 SD656_HS SD656_DIVCLK dlcon10p_1 ETCK ETMS SD656_FID I,O5 I,O27 SD656_VS I,O6 I,O26 ETDI I,O7 I,O25...
Page 30
Schematic Diagrams 5-7 EAGLE+_MEM(ASSY PCB MISC-DIGITAL, BN94-00578A) This Document can not be used without Samsung’s authorization. 3.3V_EA 3.3V_EA C530 C531 C532 C533 C534 C535 C536 C537 C538 C539 C540 C541 C542 C543 C544 C545 C546 C547 C548 C549 C550 C551...
Page 31
Schematic Diagrams 5-8 EAGLE+_PWR(ASSY PCB MISC-DIGITAL, BN94-00578A) This Document can not be used without Samsung’s authorization. 1.8V_EA 3.3V_EA IC501-4 S5H2010A VDDI VDDI VDDOP C556 C557 C558 C559 VDDI VDDOP 10nF 100nF 10nF 100nF C560 C561 C562 C563 VDDI VDDOP 10nF...
Page 32
Schematic Diagrams 5-9 LVDS_INPUT(ASSY PCB MISC-DIGITAL, BN94-00578A) This Document can not be used without Samsung’s authorization. 3.3V_D C600 BD600 100uF HH-1H4532-121JT C602 C604 C601 C603 C605 100nF 10nF 100nF 10nF 100nF R600 22ohm SD656_FID R601 22ohm EA_HIVS R602 22ohm EA_HIHS...
Page 33
Schematic Diagrams 5-10 DNIE_PRO(ASSY PCB MISC-DIGITAL, BN94-00578A) This Document can not be used without Samsung’s authorization. SNI_DQ(0:63) SNI_ADDR(0:10) SNI_BANK0 SNI_BANK1 R700 47ohm SNI_DCLK SNI_DQM SNI_NCAS SNI_NRAS SNI_NWE I_HSYNC HD_HS O_OUTD_R0 I_VSYNC HD_VS O_OUTD_R1 HD_CLK I_CLK O_OUTD_R2 I_EXT_CLK O_OUTD_R3 HD_R(0:7) O_OUTD_R4...
Page 34
Schematic Diagrams 5-11 DNIE_PRO_MEM(ASSY PCB MISC-DIGITAL, BN94-00578A) This Document can not be used without Samsung’s authorization. 3.3V_DNIE C732 C734 C736 C738 C740 C742 C730 C731 C733 C735 C737 C739 C741 100uF 100nF 10nF 100nF 10nF 100nF 10nF 100nF 10nF 100nF...
Page 35
Schematic Diagrams 5-12 LVDS_FHP(ASSY PCB MISC-DIGITAL, BN94-00578A) This Document can not be used without Samsung’s authorization. IC702 MIC39100-3.3BS 3.3V_LVDS 6V_D C723 C722 100nF 100nF 3.3V_LVDS LVDS_swing_is_350mV BD800 R800 IF_R1504_OPEN MPZ2012S300A 0ohm C800 C801 C802 C803 C804 C805 C808 R801 10uF...
Page 36
Schematic Diagrams 5-13 POD TUNER & IF(ASSY SUB PCB-POD CHANNEL B/D, BN95-00369A) This Document can not be used without Samsung’s authorization. Samsung Electronics 5-13...
Page 37
Schematic Diagrams 5-14 ATSC_DEMODULATOR_NXT2004(ASSY SUB PCB-POD CHANNEL B/D, BN95-00369A) This Document can not be used without Samsung’s authorization. 5-14 Samsung Electronics...
Page 38
Schematic Diagrams 5-15 TS_MUX(ASSY SUB PCB-POD CHANNEL B/D, BN95-00369A) This Document can not be used without Samsung’s authorization. Samsung Electronics 5-15...
Page 39
Schematic Diagrams 5-16 OOB_IF(ASSY SUB PCB-POD CHANNEL B/D, BN95-00369A) This Document can not be used without Samsung’s authorization. 5-16 Samsung Electronics...
Page 40
Schematic Diagrams 5-17 QAM_DEMODULATOR_BCM3125(ASSY SUB PCB-POD CHANNEL B/D, BN95-00369A) This Document can not be used without Samsung’s authorization. Samsung Electronics 5-17...
Page 41
Schematic Diagrams 5-18 POD_CONNECTOR(ASSY SUB PCB-POD CHANNEL B/D, BN95-00369A) This Document can not be used without Samsung’s authorization. 5-18 Samsung Electronics...
Page 42
Schematic Diagrams 5-19 I2C_GPIO(ASSY PCB MISC-READY, BN94-00579A) This Document can not be used without Samsung’s authorization. S_3.3V S_5V DO NOT STUFF do not stuff L101 R101 R102 R103 R104 R105 R106 R107 R108 R109 R111 R112 R113 R114 R115 R116...
Page 43
Schematic Diagrams 5-20 AV INPUT_OUT(ASSY PCB MISC-READY, BN94-00579A) This Document can not be used without Samsung’s authorization. DVI_INPUT +3.3V_DB S_5V HDMI_INPUT +5V_DDC_2 S_5V HPLUG_2_5V HPLUG_2_5V R202 D202 S_5V PMLL4148 D231 MMBD4148SE +3.3V_DB HPLUG_1_5V HPLUG_RST_DVI D232 PMLL4148 C201 R201 HDMI_DET 100nF...
Page 44
Schematic Diagrams 5-21 AV_SWITCH(ASSY PCB MISC-READY, BN94-00579A) This Document can not be used without Samsung’s authorization. +8V_A C301 L305 C302 220nF 100uF 10uH IC301 TEA6425D 330nF C303 R303 S-VHS_CVBS R304 SDA_5 10uF C304 R305 3D_CVBS_IN MAIN_CVBS R307 SCL_5 R308 10uF...
Page 45
Schematic Diagrams 5-22 3D_COMB(ASSY PCB MISC-READY, BN94-00579A) This Document can not be used without Samsung’s authorization. +5V_B C319 PMLL4148 C320 D309 10uH 47uF 100nF R342 SCL_V1 L306 100K R343 R344 SDA_V1 R345 C4008 47nF 100nF C321 L301 C322 C323 C324...
Page 46
Schematic Diagrams 5-23 SAA7119(ASSY PCB MISC-READY, BN94-00579A) This Document can not be used without Samsung’s authorization. +1.8V_MAIN_D L401 C401 C402 C405 10uF 100nF 100nF +1.8V_SUB_D L403 +3.3V_VD L404 C409 C410 C411 C406 C403 C404 47uF 100nF 10nF 220pF 100nF 100nF...
Page 47
Schematic Diagrams 5-24 FLI2300(ASSY PCB MISC-READY, BN94-00579A) This Document can not be used without Samsung’s authorization. C1301 C1302 22pF 22pF +1.8V_DAC X1301 13.5MHz R1301 +3.3V_DAC R1302 C1303 HC-49/SM5H 13.5MHz 100nF C1304 C1305 SAA7119_MAIN 7119_MAIN_D(0:7) R1303 100nF R1304 C1306 PR_OUT R1305...
Page 48
Schematic Diagrams 5-25 CXA2171_MST9883(ASSY PCB MISC-READY, BN94-00579A) This Document can not be used without Samsung’s authorization. +5V_B C601 C602 C603 C604 10uF C605 100nF 10.000000 100nF 100nF C606 R601 10uF D601 R605 C608 470nF BZX84C6V2 C612 Q607 470nF KSA1182 X601...
Page 49
Schematic Diagrams 5-26 DVI_SII9993(ASSY PCB MISC-READY, BN94-00579A) This Document can not be used without Samsung’s authorization. +3.3V_DB R703 SAM_DDE 4.7K INTERRUPT_OUTPUT SAM_DVSYNC 1/16W SAM_DHSYNC DVI_INT SAM_DCLK NRSTO R704 R705 C701 100nF +3.3V_DB R706 390ohm SAM_DB(0:7) 1/16W SAM_DB(0) EXT_RES SAM_DB(1) SAM_DB(2)
Page 50
Schematic Diagrams 5-27 HDMI_SII9993(ASSY PCB MISC-READY, BN94-00579A) This Document can not be used without Samsung’s authorization. +3.3V_DB SAM_DDE R726 SAM_DVSYNC 4.7K SAM_DHSYNC INTERRUPT_OUTPUT 1/16W SAM_DCLK HDMI_INT RA709 NRSTO R727 R728 C726 +3.3V_DB 1/16W HDMI 100nF 1/16W R729 390ohm SAM_DB(0:7) SAM_DB(0)
Page 51
Schematic Diagrams 5-28 BOARD_CONNECTION(ASSY PCB MISC-READY, BN94-00579A) This Document can not be used without Samsung’s authorization. +3.3V_DB +3.3V_LVDS 10uH L801 MAIN CVBS & SIF C801 C802 C803 C804 C805 C806 C807 C808 C809 C810 100uF 100nF 47uF 100nF 47uF 100nF...
Page 52
Schematic Diagrams 5-29 DSP56371(ASSY PCB MISC-READY, BN94-00579A) This Document can not be used without Samsung’s authorization. R6001 DSP_SDO R6002 5333_SDO R6003 DSP_LRCLK R6004 DSP_SCLK R6005 +3.3V_S DSP_3.3V DSP_MCLK do not stuff 10uH MATERIAL 5333_SDO L903 C901 C902 C903 C904 DSP_3.3V...
Page 53
Schematic Diagrams 5-30 MSP4440(ASSY PCB MISC-READY, BN94-00579A) This Document can not be used without Samsung’s authorization. IN_COMP_SR R1001 C1001 COMP_SR IN_COMP_SL IN_COMP_SR 4.7uF IN_V1_SR 100K R1002 IN_V1_SL IN_V2_SR R1003 C1002 IN_COMP_SL COMP_SL IN_V2_SL 4.7uF IN_DVI_SR 100K R1004 IN_DVI_SL R1005 C1003...
Page 54
Schematic Diagrams 5-31 SOUND OUT(ASSY PCB MISC-READY, BN94-00579A) This Document can not be used without Samsung’s authorization. R1101 4.7K 1/16W +3.3V_6241 +3.3V_S +5V_A S_5V +12V_A D1131 do not stuff PMLL4148 MGND1 R1105 BD1103 MPZ2012S300A +18V_A R1104 R1107 +18V_A R1171 1/10W...
Page 55
Schematic Diagrams 5-32 NTST_TUNER(ASSY PCB MISC-NTSC TUNER, BN94-00580A) This Document can not be used without Samsung’s authorization. BN59-00442A X101 1. AGC S_9V 2. SW 3. 9V 4. GND R101 1 2 3 4 LNA_ON L103 +33V_A S_9V CN101 PCN10EA-32S-2.54DS C102...
Page 56
Schematic Diagrams 5-33 Function(ASSY BOARD P-FUNCTION, BN96-00878B) This Document can not be used without Samsung’s authorization. +5V-ST 0.1u 100uF 16V +5V-ST +5V-ST LED_RED SPR-505MVWT31 LED_GREEN Key1 Key2 MENU VOL-DN C3 22p C4 22p Board In Connector ADA01 SOT ADA01 SOT...
Page 57
Schematic Diagrams 5-34 Side-AV(ASSY PCB MISC-SIDE A/V, BN94-00606A) This Document can not be used without Samsung’s authorization. 5-34 Samsung Electronics...