General Safety Operations; A.danger; Warning; Caution - Cub Cadet THE TANK S6031 Operator's And Service Manual

GENERAL SAFETY
OPERATIONS
A. DANGER
1. Do not operate machine in confined areas where
exhaust gases can accumulate.
2. Do not operate machine without mower chute deflec-
tor in place and operational.
3. Do not carry passengers.
4. Do not operate nor store machine in areas where open
flames, electrical switches and circuit breakers are
present.
B. WARNING
1. Do not operate machines under the influence of alco-
hol or drugs.
2. Do not operate machines without all guards and
safety devices in place and functional.
3. Do not start machines if there are fuel or oil leaks or
spillage — clean it up.
4. Do not operate machines near spilled or leaking
fuels.
5. Do not stop or park machine over dry leaves, grass,
debris, etc. that could be combustible.
6. Use extreme care when backing up.
7. Do not operate machine on slopes greater than 20
degrees (36%).
8. Do not operate machines on slopes when traction is
reduced (wet grass, ice, soft ground, loose ground,
leaves, pine needles, debris, etc.).
9. Avoid turning downhill if possible, go slowly and use
extra care when turning downhill.
10. Do not operate machines during reduce visibility
(low light, fog, rain, etc.).
11. Do not operate machines with non-approved attach-
ments.
12. Do not operate machines that are damaged.....have
machine repaired.
13. Do not operate machines that have not been properly
maintained.
14. Use only replacement parts that are the same or
equivalent to the original equipment.
15. Do not modify machines or any of their components,
especially the engine governor!
16. Do not operate machine for more than 2 hours with-
out hearing protection.
C. CAUTION
1. Use proper protective equipment when operating
machine (gloves, boots, and hearing protection are
recommended).
2. Read entire machine Operator's Manual.
3. Make sure operators are fully trained in the safe use
of the machine.
4. Follow all safety instructions when using the
machine.
5. Keep all safety signs legible and properly installed.
6. Do not check for hydraulic leaks with any part of the
body.
7. Do not add fuel to a machine when the engine is run-
ning and/or the exhaust system is hot.
8. Keep machine clean and free of debris, grass, leaves,
oil, grease, etc.
9. Place speed control pedals in the neutral position, set
park brake, disengage P.T.O., turn engine off, and
remove ignition key before you dismount from
machine.
10. Use machines laterally or diagonally across slopes,
avoid going downhill when possible.
11. Go slowly and use extra care when descending
slopes.
12. Disengage P.T.O. when crossing surfaces such as
asphalt, concrete, loose ground, sand, gravel, etc.
13. Use extra care when loading and unloading machines
from trucks or trailers.
14. Equipment driven on public roads must comply with
state & local ordinances, SAE J137, and ANSI/
ASABE S279.

SAFETY PRECAUTIONS

A. General
1. Read this Operator's Manual before starting the
mower. Study the controls and learn the proper
sequence of operation.
2. Do not allow anyone to operate or maintain this
machine who has not read this manual. Never permit
children to operate this machine.
3. Never carry passengers.
4. Do not remove any shields, guards or safety devices.
If a shield, guard or safety device is damaged or does
not function, repair or replace it before operating the
mower.
5. Always wear safety glasses and safety shoes when
operating or maintaining this mower. Do not wear
loose-fitting clothing.
6. Disconnect the spark plug wires and remove the key
from the ignition to prevent the engine from acciden-
tally starting before performing any maintenance on
this mower.
7. Never run the engine indoors without adequate venti-
lation. Exhaust fumes are deadly.
8. To avoid serious burns, do not touch the engine,
exhaust pipe or muffler while the engine is running or
until it has cooled after it has been shut off.
9. The liquid in the battery is dilute sulfuric acid.
Always wear safety glasses and rubber gloves when
working on the battery. Do not overfill the battery.
10. Lead-acid batteries generate hydrogen and oxygen
gases which form an explosive mixture. Keep sparks
and flames away at all times.
11. When looking for oil leaks, never run your hand over
hydraulic hoses, lines or fittings. Never tighten or
adjust hydraulic hoses, lines or fittings while the sys-
tem is under pressure. If high-pressure oil penetrates
the skin, the oil must be removed within a few hours
by a doctor familiar with this form of injury or seri-
ous complications may result.
4