Assembiy Instructions - Scag Power Equipment SW32-13KA Technical Manual

SCAB
SAFETY INSTRUCTIONS CONT'D
18. Do not touch engine or muffler while engine is mnning
or soon after it is stopped. These areas could be hot
enough to cause a burn.
19. Before leaving the operator's position or leaving mower
unattended, shift transmission into NEUTRAL, place
neutral latches in NEUTRAL LOCK position, move
cutter blade engagement lever to STOP and shut OFF
engine.
20. Do not pass or stand on the grass discharge side of any
mower with the engine running. Stop operation when
another person approaches.
MAINTENANCE AND STORAGE
21. Disconnect high tension wire from spark plug to prevent
accidental starting of the engine when servicing, adjust¬
ing or storing the machine.
22. If mower must be tipped to perform maintenance or
adjustment, renx)ve battery, drain gasoline from fuel
tank and oil from crankcase.
23. To reduce potential fire hazard, keep the engine free of
excessive grease, grass, leaves and accumulations of
dirt.
24. Be sure machine is in safe operating condition by
keeping nuts, bolts, and screws tight. Check the blade
mounting bolts and nuts frequently to be sure they are
tightened.
25. If the engine must be running to perform a maintenance
adjustment, keep hands, feet, clothing and other parts
ofthe body away from the cutter deck blades and other
moving parts.
26. Do not overspeed the engine by changing governor
settings. To be sure of safety and accuracy, have an
authorized dealer check maximum engine speed with a
tachometer.
27. Engine must be shut off before checking oil or adding oil
to the crankcase.
28. Allow engine to cool before storing mower in any
enclosure such as a garage or storage shed. Make sure
the mower fuel tank is empty if machine is to be stored
in excess of 30 days. Do not store mower near any open
flame or where gasoline fumes may be ignited by a
spark.
29. Always store gasoline in a safety-approved, red con¬
tainer.
30. Keep the mower and fuel container in locked storage to
prevent children from playing and tampering with them.
31. Perform only those maintenance instructions described
in this manual. If major repairs are ever needed or
assistance is desired, contact an Authorized Scag
Dealer. To ensure optimum performance and safety,
always purchase genuine SCAG replacment parts and
accessories. NEVER USE "WILL-FIT" replacement
parts and accessories made by other manufacturers.
Using unapproved replacement parts and accessories
may void the warranty.
32. Be careful when servicing the battery as it contains acid,
which is corrosive and could cause burns to skin and
clothing.
33. Batteries release explosive gases when being charged
or discharged. KEEP away from any source of sparks
and/or flame.
ASSEMBLY INSTRUCTIONS
ELECTRIC START UNITS ONLY!
Before proceeding with assembly, prep the battery. Fill
each cell with electrolyte until the top of the plates are
covered. Charge the battery at 3 to 4 amps for 4 hours (this
insures a good initial charge), check and add electrolyte as
needed to bring the fluid level to the bottom of the split ring.
Then wash and dry off the battery.
NOTE: Once the above fill and charge procedure has been
completed only distilled water should be added to the
battery cells.
Set the battery into the support, connect the positive cable
to the positive post, then connect the negative cable to the
negative post. Put the battery cover in place (at the back of
the battery), and clamp the battery into place (finger tight)
using the carriage bolts and wing nuts. DO NOT OVER
TIGHTEN.
WARNING: Severe chemical burns can result from im¬
proper handling of battery electrolyte. Use proper eye, skin
and clothing protection to prevent contact with eyes, skin
and clothing.
External contact: Flush with water.
Internal contact: Drink large quantities of water, followed by
milk of magnesia, beaten egg or vegetable oil.
CALL A PHYSICIAN IMMEDIATELY!
IMPORTANT - In case of internal contact DO NOT give
fluids that would induce vomiting.
Eye contact: Flush with water for at least 15 minutes and
GET MEDICAL ATTENTION IMMEDIATELY!
3