Exhaust System - Generac Power Systems NP-30G Series Owner's Manual And Installation Instructions

EXHAUST SYSTEM
The generator exhaust system must be safely and
properly installed. Only approved mufflers and other
exhaust system parts must be used. A properly
installed exhaust system must be vapor tight, quiet
and completely safe.
CAUTION: Never tee the generator engine exhaust
pipe into the vehicle engine exhaust piping. This
causes excessive back pressure on the generator
engine. Also, water from one engine can damage
the other engine.
DANGER: THE GENERATOR ENGINE GIVES OFF
DEADLY CARBON MONOXIDE GAS THROUGH ITS
EXHAUST SYSTEM. THIS DANGEROUS GAS, IF
BREATHED IN SUFFICIENT CONCENTRATIONS,
CAN CAUSE UNCONSCIOUSNESS OR EVEN
DEATH. SYMPTOMS OF CARBON MONOXIDE POI-
SONING ARE (a) INABILITY TO THINK COHERENT·
LY, (b) VOMITING, (c) TWITCHING MUSCLES, (d)
THROBBING IN TEMPLES, (e) DIZZINESS, (f)
HEADACHE, (g) WEAKNESS AND SlEEPINESS. IF
ANY OF THESE SYMPTOMS ARE EXPERIENCED,
MOVE INTO FRESH AIR IMMEDIATELY. IF SYMP-
TOMS PERSIST, GET MEDICAL ATIENTION. DO
NOT OPERATE THE GENERATOR UNTil ITS
EXHAUST SYSTEM HAS BEEN INSPECTED AND
REPAIRED.
MUFFLERS AND SPARK ARRESTORS
Exhaust mufflers and spark arrestors that Generac sup-
plies meet code and standard requirements, and are
approved by the U.S. Forest Service. Use only mufflers
and parts approved by Generac. Any person(s)
installing an unapproved muffler, or an unapproved
exhaust system part, or modifying an exhaust system in
any way that might cause a hazard, is liable for any
damage, injury or warranty expense that might be
caused by such unapproved installation or modification.
Failure to provide and maintain a spark arrestor may
be in violation of the law. If this generator is used on
any forest covered, brush covered, or grass covered
unimproved land, you must provide a spark arrestor.
The vehicle owner or operator must maintain this
device in good condition. In the State of California, the
preceding is required by law (Section 4442 of the
California Public Resources Code). Other states may
have similar laws. Federal laws apply on federal lands.
TYPE OF EXHAUST SYSTEM
The NP-30G generator has a configuration for a bot-
tom out exhaust system and is equipped with such an
exhaust muffler (Figure 26).
EXHAUST SYSTEM SAFETY
• Maintain a clearance of at least 3 inches (76mm)
between exhaust system parts and any combustible
material (such as wood, felt, cotton, organic fibers or
other like material). If you cannot maintain the 3-inch
clearance, locate, insulate or shield the exhaust part(s)
so that the temperature of any combustible material is not
raised more than 11 ?"F (65°C) above the ambient air
temperature.
• Extend the exhaust system at least one inch (25mm) past
the outer edge of the vehicle. Do not terminate the
exhaust system under the vehicle.
• Terminate the exhaust tailpipe such that exhaust gases
will not be drawn back into the generator compartment
and recirculated.
• If there is any possibility of the tailpipe or muffler being
damaged, protect these damage prone areas by means
of a protective device (such as a "skid bar'').
• Install the generator exhaust system according to safe
automotive practices.
• Use enough exhaust system hangers to prevent any part
of the system from being dislocated.
• Use exhaust system parts recommended by Generac.
Using unapproved exhaust mufflers and exhaust system
parts is the responsibility of the person(s) installing such
unauthorized parts.
• Do not terminate the exhaust system under any opening,
window or vent which can be opened or is not perma-
nently sealed from the vehicle interior.
• Exhaust piping must be large enough to prevent exces-
sive back pressure on the generator engine.
• Never tee the generator engine exhaust pipe into the
vehicle engine exhaust piping. This causes excessive
back pressure on the generator engine. Also, water from
one engine can damage the other engine.
• Plan exhaust system installation carefully. Comply with all
applicable codes, standards and regulations.
EXHAUST
MUFFLER
-22-