Page 1
Projection Television 52HMX95 62HMX95 - SUMMARY - 52HMX95/62HMX95 is the same as 62HM95 (REVISED.3) except for the parts tabled on back of this sheet. Use this service manual together with the service manual of 62HM95 (File No. 020- 200510 REVISED.3).
Page 2
Hazardous Substances. From July 1, 2006, the RoHS Directive will prohibit any marketing of new products containing the restricted substances. Increasing attention is given to issues related to the global environmental. Toshiba Corporation recognizes environmental protection as a key management tasks, and is doing its utmost to enhance and improve the quality and scope of its environmental activities.
Page 3
REPLACEMENT PARTS LIST DIFFERENCES Location Parts No. Description Location Parts No. Description #1 : [52HMX95] ACCESSORIES #2 : [62HMX95] A701 #1 23067801 CARTON #2 23067803 CARTON CAPACITORS A703 #1 23946771 PACKING, TOP PACKING CB511 76092730 CERAMIC CHIP, 16V B 0.1UF K...
Page 5
FILE NO. 020-200510 SERVICE MANUAL CIRCUIT DIAGRAMS Projection Television 62HM95 TOSHIBA CORPORATION 2005 Published in Japan Jul. 2005 (YC) DOCUMENT CREATED IN JAPAN, July, 2005...
Page 6
SCHEMATIC DIAGRAM MODEL : 62HM95 WARNING: BEFORE SERVICING THIS CHASSIS, READ THE "X-RAY RADIATION PRECAUTION", "SAFETY PRECAUTION" AND "PRODUCT SAFETY NOTICE" ON THE MANUAL FOR THIS MODEL. CAUTION: The international hazard symbols " " in the schematic diagram and the parts list designate components which have special characteristics important for safety and should be replaced only with types identical to those in the original circuit or specified in the parts list.
Page 10
CIRCUIT BLOCK DIAGRAM BACK AV SIGNAL BOARD DDR SDRAM DDR SDRAM FLI8532 CORTEZ VBI Data PJ22 VIDEO Processor YCbCr CS 1/2 Analog DCDi Video CVBS Front MADi E 1-3 Decoder Scaling (16port) TUNER SC 1-3 ANT 1/2 LVDS RF-SW TIF OUT Chanel CVBS Process...
Page 11
OPTICAL ENGINE UNIT Smooth Picture Control Board Projection Lens Lamp Light Tunnel Chip From RTIR Prism Color Wheel Color Wheel Sensor Board Drive Ballast Board Ballast Engine DMD MAIN POWER FAN EX FAN EX FAN DMD FAN DMD Mother Board TRANS E2.5 E2.5...
Page 18
BACK AV /MONO PV60 W-B 10P 2.5mm PLUG R/A PV02 PIN JACK JACK 1S3P RV22 1/6P75 CV14 0.01 RV21 1/6P75 LV20 CV15 0.01 FRONT AV TO POWER P902A 3P_2.5mm_L_SMK DOOR SW 62HM95 FRONT_AV (7/142)
Page 19
+5V_D +5V_D RA91 RA92 OPEN RA93 RA54 GA89 OPEN OPEN RA84 VOLDN CA97 VOL DN CA84 RA64 TLA6 2.2k OPEN RA94 100k RA44 0.033 DB82 DB81 CB81 SML-810MT-T86 SML-811UT-T86 0.1uF QA84 Key Sense Power +5V_D CB82 RN1404 DA91 0.1uF(OPEN) RB82 RB81 2.2k RA53...
Page 20
GR120 GR121 SHORT SHORT OOB OUT GR122 GR123 SHORT SHORT DIGITAL TUNER H003 RSU143 ANT±1 H001 ENG36A36GF TIF Type : Horizontal ANT±2 TUNER-GND P515 TO SUB POWER (GAP) P516 C150 TO A/V GND C164 Q161 R165 0.1uF 3.9k 2SC4081-Q C104 C102 D101 C162...
Page 30
R2525 Q251 NOT MOUNT 2SC4116-Y(TE85L,F) NOT MOUNT R2513 R2549 W205 NOT MOUNT 100(J) C2624 [TRP] 200:2A R2501 CVBS_CD 205:2B Q257 NOT MOUNT NOT MOUNT NOT MOUNT C2525 R2514 R2507 100nF(K) NOT MOUNT 4.7K(J) CD_3.3V 206:9G;206:9K GDM470000823 BD4728G-TR [L4728] IC254 MCDRST VOUT 205:2A GND_A...
Page 50
W418 W418/W419 0(X) US : MOUNT W419 UK : MOUNT ASIA : MOUNT 0(X) SCL2 400:1F [CL2G066] IC424 SDA2 400:1F IN/OUT SCL_STBY OUT/IN 405:8E SW1.8V 300:2C;405:4C;406:4A CONT IN/OUT 3.3V1 SDA_STBY 405:8E OUT/IN CONT 3.3V1 NOT MOUNT C483 100nF(K) NOT MOUNT [7SH04] IC423 3.3V1...
Page 68
2.5V-HDMIPHY NOT MOUNT [L26901] IC610 R648 R658 NOT MOUNT I2S_DA_OUT I2S_DA_IN1 400:6C;601:1D R649 NOT MOUNT NOT MOUNT I2S_DA_WS R650 NOT MOUNT I2S_DA_CL COUNT[0] COUNT[1] C646 NOT MOUNT 62HM95 SH.NO. SIGNAL (AUDIO_DELAY) (57/142)
Page 86
PI017: Enc STOP signal is Pull-up at the receiving end. PI016: Enc RESET signal is Pull-down at the receiving end. PI012: VMUTER signal is Pull-down at the receiving end. 62HM95 SH.NO. SEINE_DIGITAL (PIO) (75/142)