TROUBLESHOOTING CHART
PROBLEM
Will not start
Hard to start
Engine will not
turn over
Engine clicks but
will not start
CAUSE
•
Out of fuel.
•
Engine not "CHOKED"
properly.
•
Engine fl ooded.
•
Bad spark plug.
•
Dirty air fi lter.
•
Dirty fuel fi lter.
•
Water in fuel.
•
Loose or damaged wiring.
•
Carburetor out of adjustment. •
•
Engine valves out of
adjustment.
•
Dirty air fi lter.
•
Bad spark plug.
•
Weak or dead battery.
•
Dirty fuel fi lter.
•
Stale or dirty fuel.
•
Loose or damaged wiring.
•
Carburetor out of adjustment. •
•
Engine valves out of
adjustment.
•
Clutch/brake pedal not
depressed.
•
Attachment clutch is
engaged.
•
Weak or dead battery.
•
Blown fuse.
•
Corroded battery terminals.
•
Loose or damaged wiring.
•
Faulty solenoid or starter.
•
Faulty operator presence
switch(es).
•
Weak or dead battery.
•
Corroded battery terminals.
•
Loose or damaged wiring.
•
Faulty solenoid or starter.
CORRECTION
•
Fill fuel tank.
•
See "TO START ENGINE"
in Operation section.
•
Wait several minutes
before attempting to start.
•
Replace spark plug.
•
Clean/replace air fi lter.
•
Replace fuel fi lter.
•
Drain fuel tank and
carburetor, refi ll tank with
fresh gasoline and replace
fuel fi lter.
•
Check all wiring.
See "To Adjust Car bu re tor"
in Service Ad just ments
section.
•
Contact an authorized
service center/department.
•
Clean/replace air fi lter.
•
Replace spark plug.
•
Recharge or replace
battery.
•
Replace fuel fi lter.
•
Drain fuel tank and refi ll
with fresh gasoline.
•
Check all wiring.
See "To Adjust Car bu re tor"
in Service Ad just ments
section.
•
Contact an authorized
service center/department.
•
Depress clutch/brake
pedal.
•
Disengage at tach ment
clutch.
•
Recharge or replace
battery.
•
Replace fuse.
•
Clean battery terminals.
•
Check/replace ignition
•
Check/replace solenoid or
starter.
•
Contact an authorized
service center/department.
•
Recharge or replace battery.
•
Clean battery terminals.
•
Check all wiring.
•
Check/replace solenoid or
starter.
26
switch.