Lubrication (Except Oil Injection Models); Battery Care - Yamaha FT60B Owner's Manual

ing and fogging at the same time.
EWM00090
WARNING
Do not touch or remove electrical parts
G
when starting or during operation.
Keep hands, hair, and clothes away
G
from the flywheel and other rotating
parts while the engine is running.
6. Run the engine at a fast idle for a few
minutes in neutral position.
7. Just prior to turning off the engine, quick-
ly spray "Fogging Oil" alternately into
each carburetor or the fogging hole of
the silencer cover, if equipped. When
properly done, the engine will smoke ex-
cessively and almost stall.
8. Remove the outboard motor from the
test tank.
9. Install the silencer cover/cap of fogging
hole and top cowling.
10. If the "Fogging Oil" is not available, run
the engine at a fast idle until the fuel sys-
tem becomes empty and the engine
stops.
11. Drain the cooling water completely out
of the motor. Clean the body thoroughly.
12. If the "Fogging Oil" is not available, re-
move the spark plug(s). Pour a tea-
spoonful of clean engine oil into each
cylinder. Crank several times manually.
Replace the spark plug(s).
13. Drain the fuel from the fuel tank.
NOTE:
Store the fuel tank in a dry, well-ventilated
place, not in direct sunlight.
EMU28400
Lubrication (except oil injection
models)
1. Grease the spark plug threads and in-
stall the spark plug(s) and torque to
proper specification. For information on
spark plug installation, see page 45.
2. Change the gear oil. For instructions,
see page 53. Inspect the oil for the pres-
ence of water that indicates a leaky seal.
Seal replacement should be performed
by an authorized Yamaha dealer prior to
use.
3. Grease all grease fittings. For further de-
tails, see page 45.
EMU28430

Battery care

EWM00330
WARNING
Battery electrolytic fluid is dangerous; it
contains sulfuric acid and therefore is
poisonous and highly caustic.
Always follow these preventive mea-
sures:
Avoid bodily contact with electrolytic
G
fluid as it can cause severe burns or
permanent eye injury.
Wear protective eye gear when han-
G
dling or working near batteries.
Antidote (EXTERNAL):
SKIN - Flush with water.
G
EYES - Flush with water for 15 minutes
G
and get immediate medical attention.
Antidote (INTERNAL):
Drink large quantities of water or milk
G
followed by milk of magnesia, beaten
egg, or vegetable oil. Get immediate
medical attention.
Batteries also generate explosive hydro-
gen gas; therefore, you should always
follow these preventive measures:
Charge batteries in a well-ventilated ar-
G
ea.
Keep batteries away from fire, sparks,
G
or open flames (for example: welding
equipment, lighted cigarettes, and so
Maintenance
40