Table of Contents
Advertisement
8
MAINTENANCE
8.12 HYDRAULIC FLUID FILTERS ________________________________________________
The hydraulic system is protected by one 20 micron filter.
To replace hydraulic fluid filter:
1.
Remove the old filter.
2.
Fill new filter with clean hydraulic fluid then install new
filter. Hand tighten only.
8.13 ELECTRICAL SYSTEM _____________________________________________________
!
CAUTION
Always turn the ignition switch to the OFF position and
remove the Negative (BLACK) battery cable before
inspecting or working on the electrical system.
General precautions that can be taken to reduce electrical
problems are listed below.
1.
Verify that all terminals and connections are clean and
properly secured.
2.
Check the Interlock System and circuit breakers
regularly.
8.14 MUFFLER AND EXHAUST __________________________________________________
!
WARNING
Exhaust fumes contain carbon monoxide that is toxic and
can be fatal when inhaled.
NEVER operate an engine without proper ventilation.
CALIFORNIA PROPOSITION 65
!
WARNING
The engine exhaust from this product contains
chemicals known to the State of California to
cause
cancer,
birth
reproductive harm.
8.15 TIRES ___________________________________________________________________
1.
Keep tires properly inflated to prolong tire life. Check
inflation pressure while the tires are cool. Inspect tread
wear.
2.
Check the pressure with an accurate, low pressure tire
gauge.
3.
Keep tires inflated to:
Front - 10-12 psi (69-83 kPa)
Rear - 8-10 psi (55-69 kPa)
32
defects
and
other
3.
Operate engine at idle speed with hydraulic system in
Neutral for five minutes. The oil level alarm may sound
during this time (optional Green Sentry).
4.
Check hydraulic fluid level in reservoir and fill to Full
mark on dipstick.
If the Interlock System does not function properly and
the problem cannot be corrected, contact an authorized
Jacobsen Dealer.
3.
Keep the wire harness and all individual wires away
from moving parts to prevent damage.
4.
Make sure the seat switch harness is connected to the
main wire harness.
5.
Check the battery and battery charging circuit.
6.
Do not wash or pressure spray around electrical
connections and components.
To protect against carbon monoxide poisoning, inspect the
complete exhaust system regularly and always replace a
defective muffler.
If you notice a change in the color or sound of the exhaust,
stop the engine immediately. Identify the problem and have
the system repaired.
Torque all exhaust manifold hardware evenly. Tighten or
replace leaking exhaust clamps.
!
CAUTION
Unless you have the proper training, tools, and
experience, DO NOT attempt to mount a tire on a rim.
Improper mounting of tire can produce an explosion
which may result in serious injury.
Advertisement
Table of Contents
Troubleshooting
