Samsung Galaxy Tab 3 8.0 Repair Manual

Hide thumbs

Table Of Contents

Quick Links

Download this manual

HW Repair Guide

SM-T310 (LT01)

June, 2013

HHP Global CS team

Confidential

Table of Contents

Summary of Contents for Samsung Galaxy Tab 3 8.0

Page 1 HW Repair Guide HW Repair Guide SM-T310 (LT01) SM-T310 (LT01) June, 2013 HHP Global CS team © Samsung Electronics Co., LTD | Confidential...
Page 2 Therefore, it is strictly prohibited from information leak or forwarding this material, and if leak of management / technical information due to disobeying the law happens, it can be severely punished in accordance with information protection rule of our company. © Samsung Electronics Co., LTD | Confidential...
Page 3: Table Of Contents
Contents 1. Introduction of LT01 2. Service Guide • Boot Recovery 3. Repair Guide • Assembly & Disassembly • Electronic Components • SMD parts • Trouble Shooting 4. Q&A © Samsung Electronics Co., LTD | Confidential...
Page 4 Dual Core(Exynos 4212) Android JB Prime Memory 16GB NAND + 1.5GB RAM Display 8” TFT (1280x800) Camera 5MP + 1.3MP Sensor Accelerometer, Magnetic, Light Connectivit BT4.0, WiFi a/b/g/n A-GPS + GLONASS Battery 4450mA © Samsung Electronics Co., LTD | Confidential...
Page 5: Boot Recovery
1) One normal SM-T310(normally booted on) 2) External SD Card (memory size should be bigger than 2GB) 3) Odin3 v3.07.exe and Odin3.ini 4) SM-T310_Boot_Recovery.tar (uploaded on HHPsvc > Find Contents > J-TAG Program > SM-T310) © Samsung Electronics Co., LTD | Confidential...
Page 7 Boot Recovery (3/10) 3) Click ‘Bootloader’ button and load “SM- T310_Boot_Recovery.tar” © Samsung Electronics Co., LTD | Confidential...
Page 8 4) Enter download mode with the normal phone(SD Card inserted). ※ Download Mode : Volume Down Key + Power Key and press Volume Up key. <Volume Down key + Power Key> <Download Mode> © Samsung Electronics Co., LTD | Confidential...
Page 9 Boot Recovery (5/10) 5) Connect the phone to PC, using USB cable. © Samsung Electronics Co., LTD | Confidential...
Page 10 7) Disconnect the phone from PC. 8) Close the Odin3 v3.07.exe and Run it again. 9) Click ‘Bootloader’ button and load “SM-T310_Boot_Recovery.tar” And check ‘T Flash’ option in the Odin, to copy bootloader to SD Card © Samsung Electronics Co., LTD | Confidential...
Page 11 Boot Recovery (7/10) 10) Enter download mode with the normal phone(bootloader was copied before), and connect it to PC again 11) Click Start button to copy bootloader to the SD Card © Samsung Electronics Co., LTD | Confidential...
Page 12 12) After downloading, turn of the SM-T310 and remove the SD Card. → This SD card will be used to recover boot of the phone. 13) Disassemble the ‘Rear case’ from SM-T310, and disconnect battery connector and re-connect battery connector. © Samsung Electronics Co., LTD | Confidential...
Page 13 Boot Recovery (9/10) 14) Insert SD card(bootloarder was copied)to the PBA 16) Connect two test-point with tweezers. © Samsung Electronics Co., LTD | Confidential...
Page 14 And remove tweezers after 5 seconds from turning on the SM-T310. 18) You can see message on the LCD 19) Click Volume Down Key to enter Download Mode 20) Download Full S/W including PIT, Bootloader, PDA, CSC © Samsung Electronics Co., LTD | Confidential...
Page 15: Assembly & Disassembly
Assembly & Disassembly Instruction Disassembly © Samsung Electronics Co., LTD | Confidential...
Page 21: Electronic Components
GH59- FPCB 13405A GH59- 13424A GH59- 13346A 1.3M Camera GH96- 06290A Power Key Inner Battery GH43- Volume Key 03857A Left Ir LED Speaker GH96- 06317A Right USB FPCB Speaker GH96- GH59- 06319A 13370A © Samsung Electronics Co., LTD | Confidential...
Page 22 Electronic Components (2/2) TSP Connector LCD TSP Assy GH96- 06467A LCD Connector Home Key GH59- 13343A FPCB © Samsung Electronics Co., LTD | Confidential...
Page 23: Smd Parts
SOC300 3709-001811 SD Card Socket HDC201 3711-007172 HDC200 3711-007172 Right Speaker Connector Left Speaker Connector HDC601 3711-007295 HDC301 3711-006141 LCD Connector USB FPCB Connector BTC500 3711-008421 HDC300 3711-008347 Battery Connector Home Key Connector © Samsung Electronics Co., LTD | Confidential...
Page 24 HDC600 3708-002222 5M Camera Connector F600 2901-001625 F602 2901-001732 Filter for 5M Camera ANT100, ANT101 3712-001473 Antenna Contact (BT, Wif, GPS) U204 1205-004804 Audio Codec F601 2901-001625 F603, F604 2901-001732 Filter for LCD © Samsung Electronics Co., LTD | Confidential...
Page 25 Go to the next step (C524, C522, C521, C532, TP_AP_PS_HOLD > 1.8V TP_AP_PS_HOLD) If not the correct value PMIC (U500) 32KHz Main chip (UCP400) Check the frequency of OSC500(C513) If not the correct value TCXO (OSC500) © Samsung Electronics Co., LTD | Confidential...
Page 26 Power problem Step2 Step2 Step3 Step3 batt Check the power-key FPCB Step5 Step5 Step6 Step6 AP_PS_HOLD(TP) C705 C523 C524 OSC700 U500 C521 C532 © Samsung Electronics Co., LTD | Confidential...
Page 27 C304 = 5V Go to the next step Connection status Check the voltage of V_BUS(C304). If not the correct value of USB FPCB or U300. Abnormal IF PMIC(U502) Check the charging operating of battery. Normal © Samsung Electronics Co., LTD | Confidential...
Page 29 If not the correct value F601, F603, F604 (F601, F603, F604) Same signal compared with Notice. It should be measured when the MAIN CHIP or PBA a good PBA display is activated on © Samsung Electronics Co., LTD | Confidential...
Page 30 Display problem HDC601 C603 Step2 Step2 Step5 Step5 LCD CONNECTOR U602 Step5 Step5 Step6 Step6 Step6 Step6 F601, F603, F604 Step7 Step7 C605 U600 Step8 Step8 C606 © Samsung Electronics Co., LTD | Confidential...
Page 31 Same signal compared with a Go to the next step Notice. It should be measured when the good PBA display is activated on Solved Replace the TSP Not solved Main chip or PBA © Samsung Electronics Co., LTD | Confidential...
Page 32 TSP problem HDC700 Step2 Step2 Step3 ~ Step3 ~ C701 TSP power C703 C700 C702 R909 R907 Step5 Step5 R906 TSP signal TSP CONNECTOR © Samsung Electronics Co., LTD | Confidential...
Page 33 F600, F602 Notice. It should be measured when the Normal Go to the next step 5M CAM is activated on Solved 5M CAM Replace the 5M CAM Not solved Main chip or PBA © Samsung Electronics Co., LTD | Confidential...
Page 35 Abnormal F902 Notice. It should be measured when the Normal Go to the next step 1.3M CAM is activated on Solved 1.3M CAM Replace the 1.3M CAM Not solved Main chip or PBA © Samsung Electronics Co., LTD | Confidential...
Page 37 Same signal compared with a Speaker Connector (HDC200, HDC201) good PBA (HDC200, HDC201) Notice. It should be measured when the Normal Voltage and No signal Audio Codec (U204) speaker path is activated on © Samsung Electronics Co., LTD | Confidential...
Page 38 Speaker problem Step3 Step4 Step3 Step4 Right Speaker Left Speaker Module Module (GH96-06319A) (GH96-06317A) HDC200, HDC201 Speaker connector Step7 Step7 HDC201 HDC200 Sound signal path U204 Audio Codec © Samsung Electronics Co., LTD | Confidential...
Page 39 (*#0*# → Speaker(L), Speaker(R)) Same signal compared with a Check the signal of D204, D207 Earphone good PBA Notice. It should be measured when the Audio codec No signal Earphone path is activated on (U204) © Samsung Electronics Co., LTD | Confidential...
Page 40 Earphone problem Step3 Step4 Step3 Step4 Earjack (GH59-13405A) Earjack connector Step7 Step7 D204 D207 © Samsung Electronics Co., LTD | Confidential...
Page 41 Same signal compared with a Check the signal of C204, C215 Microphone good PBA Notice. It should be measured when the AUDIO If not the correct value microphone path is activated on CODEC(U204) © Samsung Electronics Co., LTD | Confidential...
Page 42 Microphone problem Step5 Step5 Step2,3 Step2,3 Microphone HDC701 Microphone Rubber Holder MIC Connector Step7 Step6 Step7 Step6 U204 Audio Codec C204 C215 TP_704 Microphone signal path © Samsung Electronics Co., LTD | Confidential...
Page 43 Check the clock of R120, C150, C151 (Same signal compared BT/WIFI IC (U104) with a good PBA) Notice. It should be measured when the BT/WIFI path is activated on If not the correct value OSC101 © Samsung Electronics Co., LTD | Confidential...
Page 44 BT/WIFI Problem Step1 Step2 Step1 Step2 ANT101,ANT10 BT/ WIFI ANTENNA (Carrier TYPE) You can check the this layout if open the shied cover U500(PMI Step3,4 Step3,4 U104 OSC101(37M (BT/WIFI IC) R120 C135 © Samsung Electronics Co., LTD | Confidential...
Page 45 Check the clock of OSC100 GPS IC(U102) (Same signal compared GPS LNA(U101) with a good PBA) Notice. It should be measured when the GPS path is activated on If not the correct value OSC100 © Samsung Electronics Co., LTD | Confidential...
Page 46 GPS/GLONASS Problem Step1 Step2 Step1 Step2 ANT100,ANT10 You can check the this layout BT/ WIFI ANTENNA if open the shied cover (Carrier TYPE) U500(PMI Step3,4 Step3,4 L101 U102(GPS OSC100(26M © Samsung Electronics Co., LTD | Confidential...

This manual is also suitable for:

Sm-t310

Samsung Galaxy Tab 3 8.0 Repair Manual

Quick Links

Related Manuals for Samsung Galaxy Tab 3 8.0

Summary of Contents for Samsung Galaxy Tab 3 8.0

Page 3: Table Of Contents

Page 5: Boot Recovery

Page 15: Assembly & Disassembly

Page 21: Electronic Components

Page 23: Smd Parts

Page 47: Q&A

This manual is also suitable for: