Samsung PCL545RX/XAA Service Manual page 137

Loc. No. Code No. Description ; Specification
PC+DB 6003-001023 SCREW-TAPTITE;RWH,+,B,M3,L10,ZPC(YEL),SWRCH1
6003-001233 SCREW-TAPTITE;PWH,+,P,M3,L8,ZPC(BLK),SWCRH18A
DB+BM 6006-000255 SCREW-ASS'Y MACH;WSP,PH,+,M3,L6,ZPC(WHT),SWRC
DG+BM 6044-001028 RING-E;ID3,OD7,T0.6,BLK,SK5
AA61-00069A BRACKET-MOTOR,ASSY;HCH551W,SECC-1+SUM 24L,,NTR,
AA61-20311A HOLDER-SHAFT;-,-,POM,M90-44,NAT,P15xH5.5
AA61-20312A HOLDER-CAP;-,-,POM,M90-44,NAT,-
AA61-80058A DAMPER-GEAR,A;-,POM,-,-,WHT,-,-,-,-,-,-,-,-
AA61-80059A DAMPER-GEAR,B;-,POM,-,-,WHT,-,-,-,-,-,-,-,-
AA61-80060A DAMPER-GEAR,C;-,POM,-,-,WHT,-,-,-,-,-,-,-,-
AA61-80061A DAMPER-GEAR,WARM;-,POM,-,-,WHT,-,-,-,-,-,-,-,-
AA63-00129A SPACER-RUBBER,TOWER;HCH551W,EPDM,BLK,M3 NUT-I
AA63-10002A BAND-TIE;-,NYLON66 V2,-,-,L100,NTR,-
AA65-30105C CLAMP-WIRE;ALL MODEL,NYLON 66,V2,NTR,5MM,-,-,-
AA68-01087B LABEL-MODULE;AA95-00364A,A/P90(G),-,-,-,-,-,-,DOOR,-
AA91-20071C ASSY-DOOR,BODY;-,-,P51A E2,652W,552W
AA91-20072B ASSY-DOOR,SLIDE;-,-,SILVER,SVP-65W2DR
AA91-20073B ASSY-DOOR,COVER;-,-,SILVER,SVP-65W2DR
AA95-01156A ASSY-PCB,CONTROL A/V;,HCL552WX/XAA,P54A,USA
AA95-90029A ASSY-PCB,DOOR SUB;-,SPT-555JHD,APT52A,-,-,MVT
0202-000008 SOLDER-WIRE;S63S-W3.0,S63S,D3,63Sn/37Pb,-
0202-000187 SOLDER-WIRE FLUX;-,RS60S,D1.2,63Sn/37Pb
0204-000442 SOLVENT;1M-1000,C3H70H,96,-
0204-001024 FLUX;DF-98TVS,-,20%,-
DY01 0401-000005 DIODE-SWITCHING;1N4148,100V,200mA,DO-35,TP
DY02 0401-000005 DIODE-SWITCHING;1N4148,100V,200mA,DO-35,TP
DZY01 0403-000720 DIODE-ZENER;MTZJ9.1B,9.1V,8.57-9.01V,500mW
QY02 0501-000303 TR-SMALL SIGNAL;KSA733,PNP,250mW,TO-92,TP,120-240
QY01 0504-000123 TR-DIGITAL;KSR1010,NPN,300mW,10K,TO-92,TP
ICY03 0904-001121 IC-I/O SUPPORT CHIP;8574,8BIT,DIP,16P,300MIL,100KH
ICY04 0904-001121 IC-I/O SUPPORT CHIP;8574,8BIT,DIP,16P,300MIL,100KH
ICY01 1003-001090 IC-MOTOR DRIVER;LB1643,SIP,10P,-,SINGLE,1.6A,S
ICY02 1202-000103 IC-VOLTAGE COMP.;393,DIP,8P,300MIL,DUAL,36V,CMO
RY36 2001-000281 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM
RY37 2001-000281 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM
RY43 2001-000281 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM
RY44 2001-000281 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM
RY04 2001-000290 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY07 2001-000290 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY23 2001-000290 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY09 2001-000347 R-CARBON;13KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY30 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY31 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY41 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY42 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY47 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY50 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY51 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY34 2001-000449 R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY08 2001-000539 R-CARBON;24KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY10 2001-000539 R-CARBON;24KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY02 2001-000633 R-CARBON;30KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY24 2001-000734 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY35 2001-000734 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY45 2001-000734 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY48 2001-000734 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY01 2001-000780 R-CARBON;470OHM,5%,1/8W,AA,TP,1.8X3.2MM
RY49 2001-000800 R-CARBON;5.1KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY32 2001-000924 R-CARBON;680OHM,5%,1/8W,AA,TP,1.8X3.2MM
RY33 2001-000924 R-CARBON;680OHM,5%,1/8W,AA,TP,1.8X3.2MM
RY11 2001-000947 R-CARBON;7.5KOHM,5%,1/8W,AA,TP,1.8X3.2MM
RY12 2003-001091 R-METAL OXIDE(S);10ohm,5%,2W,AF,TP,4x12mm
RY22 2004-000218 R-METAL;10Kohm,1%,1/8W,AA,TP,1.8x3.2mm
RY21 2004-000253 R-METAL;11Kohm,1%,1/8W,AA,TP,1.8x3.2mm
CY01 2301-000383 C-FILM,PEF;10nF,5%,50V,TP,6x7x3.2mm,5mm
CY03 2306-000122 C-FILM,MPPF;100nF,5%,50V,TP,7.3x4.0x5.0mm,
CY06 2306-000122 C-FILM,MPPF;100nF,5%,50V,TP,7.3x4.0x5.0mm,
CY04 2401-000444 C-AL;10uF,20%,25V,GP,TP,5x5mm,5mm
CY05 2401-000486 C-AL;10uF,20%,50V,GP,TP,6.3x7mm,5
CY02 2401-001537 C-AL;47uF,20%,25V,GP,TP,6.3x7mm,5mm
LY01 2701-000115 INDUCTOR-AXIAL;10uH,10%,3x7mm
SWY01 3404-000178 SWITCH-TACT;12V,50mA,120gf,6x6mm,SPST
SWY02 3404-000178 SWITCH-TACT;12V,50mA,120gf,6x6mm,SPST
SWY03 3404-000178 SWITCH-TACT;12V,50mA,120gf,6x6mm,SPST
SWY04 3404-000178 SWITCH-TACT;12V,50mA,120gf,6x6mm,SPST
SWY05 3404-000178 SWITCH-TACT;12V,50mA,120gf,6x6mm,SPST
SWY06 3404-000178 SWITCH-TACT;12V,50mA,120gf,6x6mm,SPST
Samsung Electronics
Remark Loc. No. Code No.
SWY07 3404-000178
SWY08 3404-000178
CNY03 3711-002642
CNY04 3711-002642
CNY02 3711-002643
JKY01 3722-000544
JKY02 3722-001041
JKY04 3722-001042
JKY03 3722-001043
JY01 3812-000219
JY02 3812-000219
JY03 3812-000219
JY04 3812-000219
JY05 3812-000219
JY06 3812-000219
JY07 3812-000219
JY08 3812-000219
JY09 3812-000219
JY10 3812-000219
JY11 3812-000219
JY12 3812-000219
JY13 3812-000219
JY14 3812-000219
JY15 3812-000219
JY16 3812-000219
JY17 3812-000219
JY18 3812-000219
JY19 3812-000219
JY20 3812-000219
JY21 3812-000219
JY23 3812-000219
JY24 3812-000219
CNW902 AA39-00117A LEAD CONNECTOR-ASSY;,11P,YBNH250-11,35155-1100,1
CNW204 AA39-20159G LEAD CONNECTOR-ASSY;,12P,YBNH250-12,67096-012,17
PCB AA41-00067C
AA63-10002A BAND-TIE;-,NYLON66 V2,-,-,L100,NTR,-
AA68-01083V
*AA94-03388G ASSY PCB MAIN(OPT);HCL652WX/XAA,P54A,U.S.A
R673A 2001-001142
CN602 3711-002644
J379 3812-000219
J382 3812-000219
J384 3812-000219
J385 3812-000219
AA59-40003P
EY01 AA60-40011A EYELET;ID2.0,OD2.8,-,-,BST,-
EY02 AA60-40011A EYELET;ID2.0,OD2.8,-,-,BST,-
EY04 AA60-40011A EYELET;ID2.0,OD2.8,-,-,BST,-
BAND AA63-10002A BAND-TIE;-,NYLON66 V2,-,-,L100,NTR,-
WIRE AA65-30018A CLAMP-WIRE;NYLON-66,-,-,DATL-600,DONG-A,-
AA65-30104B
AA65-30105B
US0175 AA68-00526A LABEL-RATING;ART PAPER(90),ALL MODEL,LAMINATING,5
C904 2201-000119
*AA94-03600A ASSY CRT-(G);P16LSG03HKA,+380MG,7,PCL6215R,BARE
AA67-10066A LENS-ASSY;DELTA 37,-,-,CLEAR A/B,-,-,-
*AA94-03663A ASSY ACCESSORY;HCL552WX/XAA,P54A,U.S.A,SEA
AA68-01509A MANUAL USERS;HCL552W,ENG,W/P100(G),2(1),B5,P54A,6
Electrical Parts List
Description ; Specification
SWITCH-TACT;12V,50mA,120gf,6x6mm,SPST
SWITCH-TACT;12V,50mA,120gf,6x6mm,SPST
CONNECTOR-HEADER;BOX,3P,1R,2.5mm,STRAIGHT,SN
CONNECTOR-HEADER;BOX,3P,1R,2.5mm,STRAIGHT,SN
CONNECTOR-HEADER;BOX,4P,1R,2.5mm,STRAIGHT,SN
JACK-VHS;4P,11.5mm,AG,BLK,N
JACK-RCA;1P,3.4mm,#16-22,AU
JACK-RCA;1P,3.4mm,#16-22,AU
JACK-RCA;1P,3.4mm,#16-22,AU
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
PCB-CONTROL A/V;HCL552W,FR-1,1L,C,1.6T,330X245,P54
LABEL-MODULE;AA95-00306A,A/P90(G),-,-,-,-,-,CONTROL,-
ASSY PCB MAIN(OPT)
R-CARBON(S);3KOHM,5%,1/2W,AA,TP,2.4X6.4MM
CONNECTOR-HEADER;BOX,5P,1R,2.5mm,STRAIGHT,SN
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
WIRE-NO SHEATH CU;TCWA,300V,52mm(TAPING),1/0.6mm
MODULE-FOCUS,PACK;-,F300,NTSC,43,64x62,BK
CLAMP-WIRE;NYLON 66,V2,BLK,W2 Z5,ALL MODE
CLAMP-WIRE;NYLON 66,V2,NTR,25MM,ALL MODEL
C-CERAMIC,DISC;100nF,+80-20%,50V,Y5V,TP,8x3,5
ASSY CRT-(G)
ASSY ACCESSORY
Remark
7-65