Storage; Troubleshooting; Troubleshooting The Tractor - Murray MT200 Operator's Manual

8.

Storage

WARNING: Never store the unit with
fuel in an enclosed, non-ventilated structure. Fuel vapors
can travel to an ignition source (such as a furnace,
water heater, etc.) and cause an explosion.
Store away from furnaces, stoves, water heaters, or
•
other appliances that have pilot lights or other ignition
sources because they can ignite fuel vapors.
Tractor
Disengage the Power Take-Off (PTO), set the parking brake,
remove the key, and let the machine cool.
If you remove the battery, the battery life will increase.
Make sure that the battery is in a cool, and dry location, and
keep it fully charged. If the battery is left in the unit,
disconnect the negative cable.
36
Fuel System
Fuel can become stale when kept in a storage container for
more than 30 days. Each time you fill the container with
fuel,add STA-BIL 360° ® PROTECTION™ to the fuel as
specified by the manufacturer's instructions. This keeps fuel
fresh and decreases fuel-related problems or contamination
in the fuel system.
It is not necessary to drain fuel from the engine when
STA-BIL 360° ® PROTECTION™ is added as instructed. Before
storage, turn the engine ON for 2 minutes to move the fuel
and stabilizer through the fuel system.
Before starting the machine after it has been stored:
• Check all fluid levels. Check all maintenance items.
• Do all recommended checks and procedures found in this
manual.
• Fully charge the battery.
• Drive the tractor without a load to make certain all the
tractor systems are functioning properly.
MT200 LAWN TRACTOR
9.

Troubleshooting

WARNING: Before performing any type of maintenance, disengage all controls and stop the engine. Wait until all
moving parts have come to a complete stop. Disconnect spark plug wire and ground it against the engine to prevent
unintended starting. Always wear safety glasses during operation or while performing any adjustments or repairs.
NOTICE: If you can't solve the problem, take the tractor to an authorized service center for assistance.

Troubleshooting the Tractor

PROBLEM LOOK FOR
The engine will not start. The brake pedal is not pushed down.
The fuel tank is empty.
The PTO lever is in ON position.
The engine is flooded.
The battery terminals are dirty.
The battery is discharged or dead.
Loose or broken wiring.
The shifter lever is in reverse gear.
The engine starts hard or runs The fuel mixture is too rich.
poorly.
The engine knocks. Low oil level.
Incorrect grade of oil.
Excessive oil consumption. The engine is too hot.
Incorrect grade of oil.
Too much oil in crankcase.
The engine exhaust is black. The air filter is dirty.
The choke is closed.
MT200 LAWN TRACTOR
REMEDY
Fully push down on the brake pedal.
If engine is hot, let it cool, and then fill the
fuel tank again.
Move the PTO lever to the OFF position.
Disengage the choke.
Refer to Replacing the Battery and Cleaning
the Battery and Battery Cables section.
Charge or replace the battery.
Visually check wiring. If wires are frayed or
broken, see an authorized service center.
Move the shifter lever to the neutral position.
Clean the air filter.
Check and add oil as required.
Refer to the Changing Engine Oil
section.
Check the engine fins, blower screen,
and air filter.
Refer to the Changing Engine Oil
section.
Drain excess oil.
Refer to the Changing the Air Filter section.
Open the choke.
37