SERVICE MANUAL CASSETTE RECEIVER MA093B 2005 KS-FX385,KS-FX385S,KS-FX385G KS-FX385 Area suffix UT ------------------------- Taiwan UH ---------------------- Thailand UN --------------------- Indonesia U -------------------- Other Areas KS-FX385S Area suffix UN --------------------- Indonesia KS-FX385G Area suffix UN --------------------- Indonesia TABLE OF CONTENTS PRECAUTION............... . . 1-3 SPECIFIC SERVICE INSTRUCTIONS .
Page 2
SPECIFICATION AUDIO AMPLIFIER SECTION Maximum Power Output Front 45 W per channel Rear 45 W per channel 17 W per channel into 4 Ω, 40 Hz to 20 000 Hz at no more Continuous Power Output (RMS) Front than 0.8% total harmonic distortion. 17 W per channel into 4 Ω, 40 Hz to 20 000 Hz at no more Rear than 0.8% total harmonic distortion.
SECTION 1 PRECAUTION Safety Precautions Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of this system. (No.MA093B)1-3...
SECTION 3 DISASSEMBLY Main body 3.1.1 Removing the front panel assembly (See Fig.1) (1) Push the detach button and remove the front panel assem- bly. Front panel assembly Detach button Fig.1 3.1.2 Removing the bottom cover (See Fig.2) • Prior to performing the following procedures, remove the front panel assembly.
Page 6
3.1.4 Removing the side panel (See Fig.4) • Prior to performing the following procedure, remove the front panel assembly. (1) Remove the screw B and two screws C attaching the side panel on the left side of the body, and remove the side pan- Side panel Fig.4 3.1.5 Removing the rear panel...
Page 7
3.1.7 Removing the cassette mechanism assembly (See Fig.7) • Prior to performing the following procedure, remove the front panel assembly, bottom cover, front chassis assembly, side Cassette mechanism assembly panel, rear panel and main board. (1) Remove the four screws H attaching the cassette mecha- nism assembly from the top chassis.
Page 8
3.1.10 Removing the mecha bracket (See Fig.10) • Prior to performing the following procedure, remove the front panel assembly, bottom cover, front chassis assembly, side Mecha bracket panel, rear panel, main board, cassette mechanism assembly, head amplifier board and relay board. (1) Remove the four screws L attaching the mecha bracket.
Page 9
Cassette mechanism assembly • Prior to performing the following procedures, remove the head 3.2.4 Removing the playback head amplifier board, the relay board and the mechanism bracket. (See Fig.2) • Prior to performing the following procedure, remove the direc- 3.2.1 Removing the direction switch board tion switch board and the FF / REW lever assembly.
Page 10
3.2.6 Removing the cassette hanger / cassette holder Cassette holder (See Fig.3) Return link Joint i • Prior to performing the following procedure, remove the FF / Cassette hanger REW lever assembly. Eject lever (1) From the rear of the unit, bend the two tabs f outwards and disengage the two joints g in the direction of the arrow.
Page 11
3.2.9 Removing the Flywheel (BF) and (BR) assembly 3.2.10 Removing the reel base assembly (See Fig.4 and 5) (See Fig.5 and 6) • Prior to performing the following procedure, remove the cas- (1) Raise the part k of the reel base assembly slightly and re- sette hanger / cassette holder.
Page 12
3.2.11 Removing the mute switch board (See Fig.8) Cassette mechanism assembly Rower switch (1) Unsolder the two wires l on the mute switch board on the back of the cassette mechanism assembly. Soldering l Motor assembly (2) Remove the screw H attaching the mute switch board. switch board Mute Fig.8...
SECTION 4 ADJUSTMENT Adjustment method Test instruments required for adjustment Standard volume position (1) Digital oscilloscope (100MHz) Balance and Bass, Treble volume, Fader : Center (Indication "0") (2) Frequency counter meter Loudness, Dolby NR, Sound, Cruise : Off (3) Electric voltmeter Volume position is about 2V at speaker output with following (4) Wow &...
Page 14
Information for using a car audio service jig (1) We're advancing efforts to make our extension cords common for all car audio products. Please use this type of extension cord as follows. (2) As a U-shape type top cover is employed, this type of extension cord is needed to check operation of the mechanism assembly after disassembly.
Page 15
Arrangement of adjusting & test points Cassette mechanism (Surface) Motor assembly Tape speed adjust Playback head Azimuth screw Head section view Head azimuth screw Fixed screw Playback head Height adjusting screw a Height adjusting screw c Height adjusting screw b (No.MA093B)1-15...
Page 16
Item Conditions Adjustment and Confirmation methods S.Values Adjust Head Head height adjustment Test tape: azimuth Adjust the azimuth directly. When you SCC-1659 adjustment adjust the height using a mirror tape, VT703 (10kHz) remove the cassette housing from the mechanism chassis. After installing thecassette housing, perform the azimuth adjustment.
SECTION 5 TROUBLESHOOTING 16 PIN CORD DIAGRAM Black Green BL/WH Violet Blue Gray WH/BK White Yellow GN/BK VI/BK GY/BK 16 YL MEMORY 8 BK 7 RD 5 BL/WH REMOTE 4 WH 12 WH/BK 3 GN 11 GN/BK 2 VI 10 VI/BK 1 GY 9 GY/BK Rear Right...
Page 18
Victor Company of Japan, Limited AV & MULTIMEDIA COMPANY CAR ELECTRONICS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan (No.MA093B) Printed in Japan...
Page 19
SCHEMATIC DIAGRAMS CASSETTE RECEIVER KS-FX385, KS-FX385S KS-FX385G KS-FX385 CD-ROM No.SML200504 Area suffix UT ------------------------- Taiwan UH ---------------------- Thailand UN --------------------- Indonesia U -------------------- Other Areas KS-FX385S Area suffix UN --------------------- Indonesia KS-FX385G Area suffix UN --------------------- Indonesia Contents Block diagram (For UT, UH, UN U version)
Page 20
Safety precaution Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of this system.
Page 21
Block diagram (For UT, UH, UN, U version) Mechanism control board Relay board MAIN MOTOR HEAD MUTE SW TAPE/RADIO SW PROG.SW. SPEAKER LINE CP721 CD CHANGER CONNECTOR REAR OUT CN721 CP751 CP981 CJ921 CJ901 Main amplifier section Head amplifier section LFO+,LFO- LRO+,LRO- SI/SO...
Page 25
Block diagram (For UT3, UH3, UN3, U3 version) Mechanism control board Relay board MAIN MOTOR HEAD MUTE SW TAPE/RADIO SW PROG.SW. SPEAKER LINE CP721 CD CHANGER CONNECTOR REAR OUT CN902 J751 CP981 J931 CJ901 Main amplifier section Head amplifier section LFO+,LFO- LRO+,LRO- SI/SO...
Page 32
Victor Company of Japan, Limited AV & MULTIMEDIA COMPANY CAR ELECTRONICS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan Printed in Japan (No.MA093BSCH)
Page 33
PARTS LIST [ KS-FX385 ] [KS-FX385S] [KS-FX385G] * All printed circuit boards and its assemblies are not available as service parts. KS-FX385 Area suffix UT ------------------------- Taiwan UH ---------------------- Thailand UN --------------------- Indonesia U -------------------- Other Areas KS-FX385S Area suffix...
Page 34
Exploded view of general assembly and parts list Block No. only KS-FX385_UT Switch board...
Page 36
General Assembly Block No. [M][1][M][M] Symbol No. Part No. Part Name Description Local GE10043-012A TOP CHASSIS GE40135-001A EARTH PLATE GE30938-003A SIDE PANEL QYSDST2004ZA TAP SCREW M2 x 4mm(x2) QYSDST2604ZA TAP SCREW M2.6 x 4mm(x4) GE40235-001A SCREW (x2) QYSDST2606ZA TAP SCREW M2.6 x 6mm(x2) QYSDST2604ZA TAP SCREW...
Page 37
Cassette mechanism assembly and parts list Block No. CDS-363SJ2...
Page 39
Symbol No. Part No. Part Name Description Local 1-0363-7015S MUTE SWITCH BOARD 2-1331-7040-C2S SCREW S 2-1331-7060-C2S SCREW S 2-1382-0030-C2S SCREW B (x5) 2-1332-0040-C1S SCREW S 2-1032-0070-C2S SCREW (x2) 2-1032-0025-C2S SCREW (x2) 2-1012-0040-C2S SCREW 2-1012-0030-F2S SCREW 1-0138-5002S AZIMUTH SCREW (x3)
Page 42
Electrical parts list Main board (KS-FX385_UT,UH,UN,U/ Symbol No. Part No. Part Name Description Local FX385S_UN/FX385G_UN) C131 QERF1HM-105Z E CAPACITOR 1uF 50V M Block No. [0][1] C132 QERF1HM-105Z E CAPACITOR 1uF 50V M C133 QERF1HM-105Z E CAPACITOR 1uF 50V M ...
Page 43
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local QRE141J-103Y C RESISTOR 10kΩ 1/4W J R990 QRE141J-103Y C RESISTOR 10kΩ 1/4W J QRE141J-103Y C RESISTOR 10kΩ 1/4W J R991 QRE141J-273Y C RESISTOR 27kΩ...
Page 44
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local R615 NRSA63J-911X MG RESISTOR 910Ω 1/16W J CP721 QGB1214K1-06S CONNECTOR B-B (1-6) R635 NRS181J-221X MG RESISTOR 220Ω 1/8W J CP722 QGA2002F1-06 CONNECTOR W-B (1-6) R636 NRSA02J-122X...
Page 45
Main board (KS-FX385_UH3,UN3,U3) Symbol No. Part No. Part Name Description Local Block No. [0][4] C116 NCB31EK-333X C CAPACITOR 0.033uF 25V K Symbol No. Part No. Part Name Description Local C117 NCB31EK-123X C CAPACITOR 0.012uF 25V K C118 QERF1HM-105Z E CAPACITOR 1uF 50V M C119...
Page 46
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local NRSA63J-102X MG RESISTOR 1kΩ 1/16W J R756 NRSA63J-104X MG RESISTOR 100kΩ 1/16W J NRSA63J-102X MG RESISTOR 1kΩ 1/16W J R757 NRSA63J-104X MG RESISTOR 100kΩ...
Page 47
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local C204 QEKJ0JM-476Z E CAPACITOR 47uF 6.3V M R601 NRSA63J-681X MG RESISTOR 680Ω 1/16W J C205 QFV61HJ-103Z MF CAPACITOR 0.01uF 50V J R602 NRSA63J-561X MG RESISTOR 560Ω...
Page 49
Packing and Accessories Block No. [M][3][M][M] Symbol No. Part No. Part Name Description Local GE20137-003A MOUNTING SLEEVE GE20135-006A TRIM PLATE FX385GUN GE20135-003A TRIM PLATE FX385SUN FX385U,FX385U3,FX385UH,FX385UH3, GE20135-004A TRIM PLATE FX385UN,FX385UN3,FX385UT GET0226-001A INST BOOK ENG THA FX385U,FX385U3,FX385UH,FX385UH3 GET0226-002A INST BOOK CHI(TAIWAN) ARA PER FX385U,FX385U3 FX385GUN,FX385SUN,FX385UN,...
Page 50
PARTS LIST [ KS-FX385 ] [KS-FX385S] [KS-FX385G] * All printed circuit boards and its assemblies are not available as service parts. KS-FX385 Area suffix UT ------------------------- Taiwan UH ---------------------- Thailand UN --------------------- Indonesia U -------------------- Other Areas KS-FX385S Area suffix...
Page 51
Exploded view of general assembly and parts list Block No. only KS-FX385_UT Switch board...
Page 53
General Assembly Block No. [M][1][M][M] Symbol No. Part No. Part Name Description Local GE10043-012A TOP CHASSIS GE40135-001A EARTH PLATE GE30938-003A SIDE PANEL QYSDST2004ZA TAP SCREW M2 x 4mm(x2) QYSDST2604ZA TAP SCREW M2.6 x 4mm(x4) GE40235-001A SCREW (x2) QYSDST2606ZA TAP SCREW M2.6 x 6mm(x2) QYSDST2604ZA TAP SCREW...
Page 54
Cassette mechanism assembly and parts list Block No. CDS-363SJ2...
Page 56
Symbol No. Part No. Part Name Description Local 1-0363-7015S MUTE SWITCH BOARD 2-1331-7040-C2S SCREW S 2-1331-7060-C2S SCREW S 2-1382-0030-C2S SCREW B (x5) 2-1332-0040-C1S SCREW S 2-1032-0070-C2S SCREW (x2) 2-1032-0025-C2S SCREW (x2) 2-1012-0040-C2S SCREW 2-1012-0030-F2S SCREW 1-0138-5002S AZIMUTH SCREW (x3)
Page 59
Electrical parts list Main board (KS-FX385_UT,UH,UN,U/ Symbol No. Part No. Part Name Description Local FX385S_UN/FX385G_UN) C131 QERF1HM-105Z E CAPACITOR 1uF 50V M Block No. [0][1] C132 QERF1HM-105Z E CAPACITOR 1uF 50V M C133 QERF1HM-105Z E CAPACITOR 1uF 50V M ...
Page 60
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local QRE141J-103Y C RESISTOR 10kΩ 1/4W J R990 QRE141J-103Y C RESISTOR 10kΩ 1/4W J QRE141J-103Y C RESISTOR 10kΩ 1/4W J R991 QRE141J-273Y C RESISTOR 27kΩ...
Page 61
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local R615 NRSA63J-911X MG RESISTOR 910Ω 1/16W J CP721 QGB1214K1-06S CONNECTOR B-B (1-6) R635 NRS181J-221X MG RESISTOR 220Ω 1/8W J CP722 QGA2002F1-06 CONNECTOR W-B (1-6) R636 NRSA02J-122X...
Page 62
Main board (KS-FX385_UH3,UN3,U3) Symbol No. Part No. Part Name Description Local Block No. [0][4] C116 NCB31EK-333X C CAPACITOR 0.033uF 25V K Symbol No. Part No. Part Name Description Local C117 NCB31EK-123X C CAPACITOR 0.012uF 25V K C118 QERF1HM-105Z E CAPACITOR 1uF 50V M C119...
Page 63
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local NRSA63J-102X MG RESISTOR 1kΩ 1/16W J R756 NRSA63J-104X MG RESISTOR 100kΩ 1/16W J NRSA63J-102X MG RESISTOR 1kΩ 1/16W J R757 NRSA63J-104X MG RESISTOR 100kΩ...
Page 64
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local C204 QEKJ0JM-476Z E CAPACITOR 47uF 6.3V M R601 NRSA63J-681X MG RESISTOR 680Ω 1/16W J C205 QFV61HJ-103Z MF CAPACITOR 0.01uF 50V J R602 NRSA63J-561X MG RESISTOR 560Ω...
Page 66
Packing and Accessories Block No. [M][3][M][M] Symbol No. Part No. Part Name Description Local GE20137-003A MOUNTING SLEEVE GE20135-006A TRIM PLATE FX385GUN GE20135-003A TRIM PLATE FX385SUN FX385U,FX385U3,FX385UH,FX385UH3, GE20135-004A TRIM PLATE FX385UN,FX385UN3,FX385UT GET0226-001A INST BOOK ENG THA FX385U,FX385U3,FX385UH,FX385UH3 GET0226-002A INST BOOK CHI(TAIWAN) ARA PER FX385U,FX385U3 FX385GUN,FX385SUN,FX385UN,...
Page 67
SCHEMATIC DIAGRAMS CASSETTE RECEIVER KS-FX385, KS-FX385S KS-FX385G KS-FX385 CD-ROM No.SML200504 Area suffix UT ------------------------- Taiwan UH ---------------------- Thailand UN --------------------- Indonesia U -------------------- Other Areas KS-FX385S Area suffix UN --------------------- Indonesia KS-FX385G Area suffix UN --------------------- Indonesia Contents Block diagram (For UT, UH, UN U version)
Page 68
Safety precaution Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of this system.
Page 69
Block diagram (For UT, UH, UN, U version) Mechanism control board Relay board MAIN MOTOR HEAD MUTE SW TAPE/RADIO SW PROG.SW. SPEAKER LINE CP721 CD CHANGER CONNECTOR REAR OUT CN721 CP751 CP981 CJ921 CJ901 Main amplifier section Head amplifier section LFO+,LFO- LRO+,LRO- SI/SO...
Page 73
Block diagram (For UT3, UH3, UN3, U3 version) Mechanism control board Relay board MAIN MOTOR HEAD MUTE SW TAPE/RADIO SW PROG.SW. SPEAKER LINE CP721 CD CHANGER CONNECTOR REAR OUT CN902 J751 CP981 J931 CJ901 Main amplifier section Head amplifier section LFO+,LFO- LRO+,LRO- SI/SO...
Page 80
Victor Company of Japan, Limited AV & MULTIMEDIA COMPANY CAR ELECTRONICS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan Printed in Japan (No.MA093BSCH)