Related Manuals for Pentair MYERS 4VLX P Series
Summary of Contents for Pentair MYERS 4VLX P Series
- Page 1 SUBMERSIBLE SOLIDS HANDLING PUMP 4VL(X*)P, 8SM(X*)P, 8VL(X*)P, 12VL(X*)P *(CLASS I, DIVISION 1, GROUPS C & D): FM (*Hazardous Location Motor End) OWNER'S MANUAL pentair.com ©2022 Pentair. All Rights Reserved.
-
Page 2: Table Of Contents
TABLE OF CONTENTS SAFETY INSTRUCTIONS ..................................3 GENERAL INFORMATION ..................................4 INSTALLATION......................................5 OPERATIONS & MAINTENANCE ................................6 TROUBLESHOOTING ....................................7 PARTS INDEX ......................................8 WIRING DIAGRAM ....................................14 WARRANTY ......................................15 MY12736 / 23833A737 (11/01/22) -
Page 3: Safety Instructions
SAFETY INFORMATION SAFETY SYMBOLS ELECTRICAL SAFETY Hazardous voltage. Can shock, burn, or kill. This is the safety alert symbol. When you see this symbol on When installing, operating, or servicing this pump, follow the your pump or in this manual, look for one of the following signal safety instructions listed below. -
Page 4: General Information
GENERAL INFORMATION POWER CORDS This manual contains important information for the safe use of this product. Read completely and do not throw away. The power cord and heat sensor seal failure cord are potted into the cord cap. The cords must not be spliced. Reasonable care and safe methods should be practiced. -
Page 5: Installation
INSTALLATION MAKING ELECTRICAL CONNECTIONS While prying evenly on both sides; separate the cord cap casting from the motor housing, the assembly is airtight All electrical wiring must be in accordance with local codes, and will have a vacuum effect when disassembling. and only competent electricians should make the installations. -
Page 6: Operations & Maintenance
OPERATIONS & MAINTENANCE PUMP OPERATIONS STARTING SYSTEM PUMP MAINTENANCE Double check all wire connections. As the motors are oil filled, no lubrication or other maintenance is required. Turn pumps to Off position on H-O-A switches. Turn on breakers. If the heat sensor and seal failure are hooked up properly, no attention is necessary as long as the seal failure indicator light Connect amprobe to pump power cord and turn pump on. -
Page 7: Troubleshooting
TROUBLESHOOTING PUMP TROUBLESHOOTING PUMP DOES NOT DELIVER PROPER CAPACITY Discharge gate valve may be partially closed or partially Below is a list of common problems and the probable causes. clogged. PUMP WILL NOT START Check valve may be partially clogged. Raise level up and No power to the motor. - Page 8 PARTS INDEX - MODELS 4VL(X)P, 8SM(X)P, 8VL(X)P, 12VL(X)P 3, 4 10-4, 8-4, 6-4 & 4-4 CORD CAP MY12736 / 23833A737 (11/01/22)
-
Page 9: Parts Index
PARTS INDEX 320 FRAME PUMPS 360 FRAME PUMPS ITEM ENG. NO. DESCRIPTION ENG. NO. DESCRIPTION 28013D000 Housing – Motor 30 hp – 75 hp 28014D000 Housing – Motor 150 hp 28013D001 Housing – Motor 20 hp – 25 hp 28014D001 Housing –... - Page 10 PARTS INDEX 4VL(X)P 8VL(X)P 8SM(X)P 12VL(X)P ITEM DESCRIPTION 4VL(X)P 8VL(X)P 8SM(X)P 12VL(X)P SCREW – MACH. FL. HD. 008290091 (4) 07597A021 (4) 07597A021 (4) – WASHER – IMPELLER 019450013 019450013 019450013 019450013 SCREW – CAP (HEX SOC.) 3/4 038790021 038790021 038790021 038790021 VOLUTE 136880002...
- Page 11 PARTS INDEX 320 FRAME PUMP MOTORS PARTS GROUP ITEM 4-POLE 1750 RPM 75 HP, 460/3/60 75 HP, 575/3/60 STATOR 27969D003 27969D603 ROTOR/SHAFT ASSEMBLY 27969D011 27969D011 BOLT-STATOR 005560181 (6) 005560181 (6) ITEM 6-POLE 1150 RPM 40-50 HP, 460/3/60 40-50 HP, 575/3/60 STATOR 27972D003 27972D603...
- Page 12 PARTS INDEX 320 FRAME PUMP IMPELLERS PARTS LIST 4VL(X)P - 320 FRAME CAT. NO. ENG. NO. VOLT/PH CORD TRIM IMPELLER 1750 RPM 4VLP750M4-43 28268E000 460/3 135321092 4VLP750M4-53 28268E001 575/3 135321092 4VLXP750M4-43 28268E600 460/3 135321092 4VLXP750M4-53 28268E601 575/3 135321092 8SM(X)P - 320 FRAME CAT.
- Page 13 PARTS INDEX 12VL(X)P CAT. NO. ENG. NO. VOLT/PH CORD TRIM IMPELLER 1150 RPM 12VLP400M6-43 28274E000 460/3 12.38 25456E559 12VLP400M6-53 28274E001 575/3 12.38 25456E559 12VLXP400M6-43 28274E600 460/3 12.38 25456E559 12VLXP400M6-53 28274E601 575/3 12.38 25456E559 12VLP500M6-43 28274E002 460/3 25456E556 12VLP500M6-53 28274E003 575/3 25456E556 12VLXP500M6-43 28274E602...
- Page 14 PARTS INDEX 360 FRAME PUMP IMPELLERS PARTS LIST 4VL(X)P - 360 FRAME CAT. NO. ENG. NO. VOLT/PH CORD TRIM IMPELLER 1750 RPM 4VLP1000M4-43 28269F000 460/3 135321052 4VLP1000M4-53 28269F001 575/3 135321052 4VLXP1000M4-43 28269F600 460/3 135321052 4VLXP1000M4-53 28269F601 575/3 135321052 4VLP1250M4-43 28269F002 460/3 14.5 135321032...
- Page 15 PARTS INDEX 8VL(X)P - 360 FRAME CAT. NO. ENG. NO. VOLT/PH CORD TRIM IMPELLER 1750 RPM 8VLP1000M4-43 28273F000 460/3 13 X 12 25252D558 8VLP1000M4-53 28273F001 575/3 13 X 12 25252D558 8VLXP1000M4-43 28273F600 460/3 13 X 12 25252D558 8VLXP1000M4-53 28273F601 575/3 13 X 12 25252D558 8VLP1250M4-43...
-
Page 16: Wiring Diagram
WIRING DIAGRAM MY12736 / 23833A737 (11/01/22) -
Page 17: Warranty
Warranty is effective only if Pentair Myers authorized control panels are used. All seal fail and heat sensing devices must be hooked up, functional and monitored or this warranty will be void. Pentair Myers will cover only the lower seal and labor thereof for all dual seal pumps. under no circumstance will Pentair Myers be responsible for the cost of field labor, travel expenses, rented equipment, removal/reinstallation costs or freight expenses to and from the factory or an authorized Pentair Myers service facility. - Page 18 PAGE INTENTIONALLY LEFT BLANK MY12736 / 23833A737 (11/01/22)
- Page 19 PAGE INTENTIONALLY LEFT BLANK MY12736 / 23833A737 (11/01/22)
- Page 20 Ph: 800.363.7867 All indicated Pentair trademarks and logos are property of Pentair. Third party registered and unregistered trademarks and logos are the property of their respective owners. Because we are continuously improving our products and services, Pentair reserves the right to change specifications without prior notice. Pentair is an equal opportunity employer.