Table of Contents
Advertisement
Quick Links
P/N 900807-00 REV. E 03/2019
Ce manuel est disponible en francais, simplement en
faire la demande. Numéro de la pièce 900807-03.
P900807-00
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future
reference.
Decorative Product: Not for use as a heating
appliance.
This appliance may be installed in an aftermarket permanently located, manufactured home (USA only) or mobile
home, where not prohibited by local codes. This appliance is only for use with the type of gas indicated on the
rating plate. This appliance is not convertible for use with other gases, unless a certified kit is used.
Cet appareil peut installé dans une maison préfabriquée (mobile) déjà installée à demeure, si les réglements
locaux le permettent. Ce appareil doit être utilisé uniquement avec le type de gaz indiqué sure la plaque
signalétique. Cet appareil ne peut être converti à d'autres gaz, sauf si une trousse de conversion est utilsée.
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could
result in serious injury, death, or property damage.
- Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
- WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier from a neigh-
bor's phone. Follow the gas supplier's instruc-
tions.
• If you cannot reach your gas supplier, call the
fire department.
- Installation and service must be performed by
a qualified installer, service agency or the gas
supplier.
Installation and Operation Instructions
Custom Series Decorative B-Vent Fireplace
Electronic Ignition System
Models
BRT4336TEN-B
PFS
BRT4536TEN-B
®
C
US
Report No. F09-143
Installateur : Laissez cette notice avec l'appareil.
Consommateur : Conservez cette notice pour
consultation ultérieure.
NOTICE: Fireplace is not to be operated by a
thermostat.
BRT4336TEP-B
BRT4536TEP-B
AVERTISSEMENT:
RISQUED'INDENDIE OU D'EXPLOSION
Le non-respect Des avertissements de sécurité
pourrait d'entraîner des blessures graves, la mort
ou des dommages matériels.
- Ne pas entreposer ni utilizer d'essence ni d'autres
vapeurs ou liquides inflammables dans le voisinage
de cet appareil ou de tout autre appareil.
- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucan interrupteur. Ne pas vous servir
des téléphones se trouvant dans le bâtiment où
vous trouvez.
• Sortez immédiatement de bâtiment.
• Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions du
fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service des incindies.
- L'installation et l'entretien doivent être assurés par
un installateur ou un service d'entretien qualifié
ou par le fournisseur de gaz.
BRT4342TEN-B
BRT4342TEP-B
BRT4542TEN-B
BRT4542TEP-B
Advertisement
Table of Contents
Related Manuals for Superior Fireplaces BRT4336TEN-B
Summary of Contents for Superior Fireplaces BRT4336TEN-B
- Page 1 Installation and Operation Instructions Custom Series Decorative B-Vent Fireplace Electronic Ignition System P/N 900807-00 REV. E 03/2019 Models Ce manuel est disponible en francais, simplement en faire la demande. Numéro de la pièce 900807-03. BRT4336TEN-B BRT4336TEP-B BRT4342TEN-B BRT4342TEP-B BRT4536TEN-B BRT4536TEP-B BRT4542TEN-B BRT4542TEP-B ®...
-
Page 2: Table Of Contents
Thank you for your purchase. We appreciate your TABLE OF CONTENTS business! Safety ..................... 2 Please carefully read and follow all instructions in this manual. Pay Unpacking ..................4 special attention to all warnings and safety information. Introduction ................... 4 Following these safety, care, and operation instructions will help Selecting Location ................ - Page 3 SAFETY Continued 3. If you smell gas WARNING: This product contains and/or generates • shut off gas supply chemicals known to the State of California to cause • do not try to light any appliance cancer or birth defects or other reproductive harm. •...
-
Page 4: Unpacking
SAFETY Continued COMMONWEALTH OF MASSACHUSETTS REQUIREMENTS 20. Provide adequate clearances around air openings. These appliances are approved for installation in the US state of Mas- 21. Children and adults should be alerted to the hazards of high sur- sachusetts if the following additional requirements are met: face temperature and should stay away to avoid burns or clothing •... -
Page 5: Selecting Location
INTRODUCTION Continued 2. Consider a location where heat output would not be affected by drafts, WARNING: Installation of this appliance should be air conditioning ducts, windows or doors. done by a qualified service person well trained in the 3. A location that avoids the cutting of joists or roof rafters will make instal- installation of such appliances. -
Page 6: Product Specifications
PRODUCT SPECIFICATIONS GAS RATING - NATURAL BRT 4336TEN-B, 4536TEN-B BRT 4342TEN-B, 4542TEN-B Max. Input Rating: 40,000 Btu/Hr 45,000 Btu/Hr Manifold Pressure: 3.5" WC (.87 kPa) 3.5" WC (.87 kPa) Minimum Supply Pressure: 4.5" WC (1.12 kPa) 4.5" WC (1.12 kPa) Maximum Supply Pressure: 10.5"... -
Page 7: Pre-Installation Preparation
PRE-INSTALLATION PREPARATION CLEARANCES MANTEL CLEARANCES AND WALL DETAILS A combustible mantel shelf maybe installed a maximum 12" (22.9 Minimum clearances to combustibles are: cm) from wall. Figures 5 and 6 show the minimum allowable dis- Back and Sides of Outer Surround 0"... - Page 8 PRE-INSTALLATION PREPARATION Continued These Dimensions Allow for a 3/4" Clearance FRAMING at Sides and Back of Fireplace. However, 0" 1. Frame appliance enclosure as illustrated in Figures 7 and 8. Clearance is Permitted NOTE: If a wall covering is used to line enclosure, then all measurements must be from surface of covering.
-
Page 9: Venting Installation
VENTING INSTALLATION A B-type venting system must be connected to appliance for venting IMPORTANT NOTICE to the outside of building. The following section is provided as a guide to a standard B-type ANSI Z223.1/NFPA 54 (USA), or CSA B149.1 (Canada) vent installation. - Page 10 VENTING INSTALLATION Continued If venting horizontally through a side wall becomes necessary, a listed CHECKING FOR PROPER VENTING thimble approved for use with B-type vent must be used. Check with After completing and checking electrical, gas and vent connections, your local codes before venting through a side wall. follow the lighting instructions and allow the main burner to run for Some codes areas allow the use of existing B-type vent systems if approximately 5 minutes.
-
Page 11: Installation
INSTALLATION Battery Cover WALL SWITCH INSTALLATION 12 Volt Battery The installation of a wall switch allows you to activate the gas con- trol valve and turn the fireplace on and off. The wall switch is to be connected to the incoming 120 volt regular household wiring that supplies electricity to the fireplace. - Page 12 INSTALLATION Continued EMBER AND PAN MATERIAL PLACEMENT 1/2" NPT Incoming Black Iron Gas Line 1. Open bag(s) of vermiculite and fill until it is even across burner Flexible Gas Line pan (see Figure 20). (1 Provided) Can Be Extended Out 2.
- Page 13 INSTALLATION Continued Log 4 LOG PLACEMENT FOR MODEL BRT 4336TEN-B, 4536TEN-B, Log 3 4336TEP-B, 4536TEP-B 1. Place small front right log (log 1) on right front of grate as shown in Figure 23. 2. Place large back log (log 2) onto grate making sure notches rest over grate as shown in Figure 23.
- Page 14 INSTALLATION Continued LOG PLACEMENT FOR MODEL BRT 4342TEN-B, 4542TEN-B, 4342TEP, 4542TEP Log 3 1. Place large back log (log 1) onto grate making sure notches Log 4 rest over grate (see Figure 27). 2. Insert lower end of log 2A between first two grate fingers and posi- tion upper end into notch on front of log 1.
- Page 15 INSTALLATION Continued COMBUSTION AIR KIT MODEL AK4 (OPTIONAL) INSTALLING OPTIONAL GLASS DOOR ACCESSORY The outside air kit may be installed on the left side of fireplace only. CAUTION: Use only glass doors certified for use The vent can be installed through any outside wall a minimum of three feet below fireplace termination cap.
- Page 16 INSTALLATION Continued 10. Repeat process until both doors are evenly joined, spaced and Fold Bi-Fold Spring Clip working freely. Door After Releasing CAUTION: The glass panels become very hot while Spring Clip the appliance is operating. Do not attempt to adjust and Slide Door Out of or clean the glass doors until the appliance has fully...
-
Page 17: Operation
OPERATION `FOR YOUR SAFETY 14. Visually locate pilot. Igniter should begin to spark and main burner READ BEFORE LIGHTING should ignite once flame appears at pilot. • If lighting appliance for the first time each season, it may take several attempts before supply gas can reach pilot and WARNING: If you do not follow these instructions main burner. -
Page 18: Inspecting Pilot And Burner Flame Patterns
INSPECTING PILOT AND BURNER FLAME PATTERNS CLEANING AND MAINTENANCE Periodically check pilot flame pattern and burner flame patterns often. WARNING: Installation and repair should be done PILOT ASSEMBLY by a qualified service person. The appliance should The pilot assembly is factory preset for the proper flame. Alterations be inspected before each use and at least annually may have occurred during shipping and handling. -
Page 19: Wiring Diagram
WIRING DIAGRAM PILOT MICRO SWITCH LIMIT SWITCH IGNITOR (IF EQUIPPED) (IF EQUIPPED) BURNER ORANGE GAS VALVE TRANSFORMER BLACK WHITE BLACK BLACK BLACK HIGH VOLTAGE BLUE GROUND BLUE GREEN IGNITION MODULE 120 VAC WARNING: Electrical Grounding Instructions - This appliance is equipped with a three-prong (grounding) plug for your protection against shock hazard and should be plugged directly into a properly grounded three-prong receptacle. -
Page 20: Service Hints
SERVICE HINTS REPLACEMENT PARTS See Pages 23 to 26 for a complete replacement parts list. Use only When Gas Pressure Is Too Low parts supplied from the manufacturer. • pilot will not stay lit Normally, all parts should be ordered through your IHP distributor •... -
Page 21: Troubleshooting
TROUBLESHOOTING NOTE: Before troubleshooting the system, make sure the gas shutoff valve is ON. The two most common causes of a malfunctioning gas appliance are: 1. Loose wiring connections 2. Construction debris clogging the pilot and/or gas control valve filter OBSERVED PROBLEM POSSIBLE CAUSE REMEDY... - Page 22 TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions. •...
-
Page 23: Parts
PARTS WARNING: Contact an IHP dealer to obtain any of these parts. Never use substitute materials not approved by IHP. Use of non-approved parts can result in poor performance and safety hazards. LOG SETS FOR 36"MODELS LOG SETS FOR 42" MODELS BRT4336 BRT4536 BRT4342... - Page 24 MODEL CAT. NO. INTERIOR F3205 BRT4542TEP-B White Herringbone F3204 BRT4542TEN-B White Herringbone F3201 BRT4536TEP-B White Herringbone F3200 BRT4536TEN-B White Herringbone F3213 BRT4342TEP-B White Stacked F3212 BRT4342TEN-B White Stacked F3209 BRT4336TEP-B White Stacked F3208 BRT4336TEN-B White Stacked 35 34 SuperiorFireplaces.us.com 900807-00E...
- Page 25 PARTS This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on Page 20 of this manual. KEY NO. CATALOG NO. DESCRIPTION 36" MODELS 42" MODELS QTY J6811 MICRO SWITCH • •...
- Page 26 PARTS WARNING: Contact an IHP dealer to obtain any of these parts. Never use substitute materials not approved by IHP. Use of non-approved parts can result in poor performance and safety hazards. BRT4336 BRT4536 NO. CATALOG NO. DESCRIPTION White Stacked White Herringbone F3225 Refractory Set, White Herringbone...
-
Page 27: Accessories
ACCESSORIES NOTICE: All accessories may not be available for all fireplace models. CAT NO. MODEL DESCRIPTION EXTRUDED ALUMINUM BI-FOLD GLASS DOORS F0981 BD36 36" Standard Bi-Fold Glass Door - Black finish F0984 BD42 42" Standard Bi-Fold Glass Door - Black finish OPTIONAL OUTSIDE AIR KITS Optional kit helps offset the negative pressure often existing in today's tightly constructed homes. - Page 28 ACCESSORIES Continued CAT NO. MODEL DESCRIPTION PERIMETER TRIM KIT F1042 PT36 36" Perimeter Trim Kit - Black F1045 PT42 42" Perimeter Trim Kit - Black PROPANE/NATURAL GAS CONVERSION KIT F1124 PCBE-36 36": Electronic Ignition - NG to LP F1125 NCBE-36 36": Electronic Ignition - LP to NG (Not Shown) F1128...
- Page 29 NOTES ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ 900807-00E SuperiorFireplaces.us.com...
- Page 30 NOTES ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ SuperiorFireplaces.us.com 900807-00E...
-
Page 31: Warranty
Innovative Hearth Products Superior Brand Gas Fireplaces, Stoves and Inserts ® 20 Year Limited Warranty THE WARRANTY Innovative Hearth Products ("IHP") 20 Year Limited Warranty warrants your Superior Brand gas fireplace, Stove or Insert ("Product") to be free from defects in materials ®... - Page 32 SuperiorFireplaces.us.com Record the following important information about your fireplace: Fireplace model number Fireplace serial number Date fireplace was Installed Type of gas fireplace uses Dealer name IHP reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products.