COLOR TELEVISION RECEIVER Chassis : S56A(P) REV.1 Model: CW21A113NPXXEU CW28D83NSPXXEU COLOR TELEVISION RECEIVER CONTENTS Precautions Reference Information Specifications Alignment and Adjustments Troubleshooting Exploded Views and Parts List Electrical Parts List Block Diagrams Wiring Diagram Schematic Diagrams...
Heed the high voltage limits. These include not exceed 0.5 milliamp. Reverse the power- the X–ray Protection Specifications Label, and plug prongs in the AC outlet and repeat the the Product Safety and X-ray Warning Note on test. the service data schematic. Samsung Electronics...
Page 3
14. Components, parts and wiring that appear to have overheated or that are otherwise damaged should be replaced with parts that meet the original specifications. Always determine the cause of damage or overheating, and correct any potential hazards. Samsung Electronics...
Page 4
Make sure that the portion around 8. Always connect a test instrument’s ground the serviced part has not been damaged. lead to the instrument chassis ground before connecting the positive lead; always remove the instrument’s ground lead last. Samsung Electronics...
Page 5
4. Do not use freon-propelled chemicals. These unpackaged replacement ESDs. Motions such can generate electrical charges that damage as brushing clothes together, or lifting a foot ESDs. from a carpeted floor can generate enough static electricity to damage an ESD. Samsung Electronics...
Millimeter Hour Millisecond Inches Per Second Millivolt Kilowatt-hour Nanofarad Ω Kilogram Kilohertz Picofarad kΩ Kilohm Pound Kilometer Revolutions Per Minute km/h Kilometer Per Hour Revolutions Per Second Kilovolt Second (Time) Kilovolt-ampere Volt Kilowatt Volt-ampere Liter Watt Megahertz Watt-hour Samsung Electronics...
Page 7
Fail Safe Voltage Controlled Oscillator Ground VCXO Voltage Controlled Crystal Oscillator Green-Y Very High Frequency High Video Intermediate Frequency High-Frequency Variable Resistor HI-FI High Fidelity Video Tape Recorder Inductance-Capacitance VTVM Vacuum Tube Voltmeter Integrated Circuit Transistor Intermediate Frequency Samsung Electronics...
Page 9
15W x 2CH, 10W x 2CH, 5W x 2CH TDA7297 Table 2-3-4 TUNER REMARK FUNCTION SPEC Without LNA TECC0949PG35A SAMSUNG Without LNA TEDE9-203A TAEL-G671D With LNA ALPS Table 2-3-5 VIDEO OUTPUT AMP REMARK SPEC FUNCTION 25” Normal 29” Normal TDA6107Q 21” Flat 25” Flat TDA6108JF Samsung Electronics...
2. Turn on the TV. Set the Brightness and Contrast controls to minimum (zero beam current). 3. Adjust the Brightness and contrast controls to both extremes. Ensure that the high voltage does not exceed 30 KV under any conditions. Samsung Electronics...
Page 14
FM demodulator gain 0 ~ 3 19h(D7-D6) Peaking center frequency 0 ~ 1 20h(D1) Automatic color limiting 0 ~ 1 21h(D0) Forced color limiting SCBT 0 ~ 63 Screen brightness(different from INCH) 0 ~ 23 19h(D5-D0) Sub Sharpness gain adjustment Samsung Electronics...
Page 15
DVD Sub brightness(low light adjustment) DCDL 0 ~ 15 2Ah(D3-D5) DVD Cathode drive level DBLR 0 ~ 63 14h(D5-D0) DVD Black level offset R(low light R adjustment) DBLB 0 ~ 63 15h(D15-D0) DVD Black level offset B(low light B adjustment) Samsung Electronics...
Page 16
Entering G2-Adjust Mode Screen Adjust : Displyed As “NG”. ¡ Turn SCREEN VR OF FBT, Adjust Value Become To Be “OK”. ADJUST OPTION 52 2A 48 Screen Adjust : N.G G2-ADJUST RESET SPM-836EAN 2002/02/08 Screen Adjust : O.K Screen Adjust : N.G Samsung Electronics...
Page 17
Alignment and Adjustments 4-5-2(D) SCREEN CHANGE (I2C BUS GEOMETRIC ADJUSTMENT) V Shift V Amp V Slope V SC H EW H Trapizium H Symmetry H Parabola H Corner H Shift Samsung Electronics...
Page 18
SIFIN1/DVBIN1 SIF input 2 / DVB input 2 SIFIN2/DVBIN2 ground 2 for TV processor GND2 narrow band PLL filter SIFAGC/DVBAGCR Automatic Volume Leveling/subcarr reference output/sound IF input/external reference signal input for I signal mixer for DVB REFO/AMOUT/REFIN operation Samsung Electronics...
Page 19
XTLIN crystal oscillator output XTLOUT reset RESET digital supply to peryipher(+3.3 V) VDDP P1.0/INT1 port 1.0 or external interrupt 1 input P1.1/T0 port 1.1 or Counter/Timer 0 input port 1.2 or external interrupt 0 input P1.2/INTO Samsung Electronics...
Page 20
Exploded View & Parts List 6. Exploded View & Parts List 6-1 CW21A113NPXXEU You can search for the updated part code through ITSELF web site. Code No Description Specification Q’ty Remark S.N.A URL : http://itself.sec.samsung.co.kr AA96-01493A ASSY C P-FRONT;21A11,HIPS HB,G4309,S AA64-03435A CABINET-FRONT;21A11(SEH),HIPS...
Page 21
Exploded View & Parts List 6-2 CW28D83NSPXXEU You can search for the updated part code through ITSELF web site. Code No Description Specification Q’ty Remark S.N.A URL : http://itself.sec.samsung.co.kr AA96-01297D ASSY COVER P-FRONT;28D8,HIPS HB,SILVER,S AA64-03547A CABINET FRONT;28D8,HIPS,HB,SV012P,S56A AA64-70117B BADGE-BRAND;,AL,T1.5,10.6,L65,BLK,SILVER AA64-02316A KNOB-POWER;28D8(SEH),HIPS,HB,GRY AA61-60003J SPRING ETC-CS;-,SUS304,-,-,OD6,N7,OD6,-,...